Professional Documents
Culture Documents
PRD CV 350
Note: The images provided here are for reference only and do not depict the exact specification outlined in this document.
Application Domestic Water wells
Rig hydraulic system is powered from suitable Deck Engine - 105 kw (140
Prime Mover*
HP)
Mounting Platform Heavy I and C section welded steel structure covered with 5mm chequered
Structure plate
Expandable Drill Table is capable to handle upto 21" (533.4 mm) Casing pipe
The tele mast is specially designed to handle upto 6 mtr length casing pipe
Mast Raising
The mast is raised and lowered by Double hydraulic cylinder
Cylinder
Feed System Pull Down Force: 9942 kgf (21922 lb.f) @ 210 bar
Fabricated steel body with spur gear reduction and oil bath lubrication type
Rotary Head
gearbox along with bottom air entry and spindle with 2 7/8" IF driven by
Assembly
double hydraulic motor.
(Top Head Drive)
Maximum Torque : 815 kg.m (8000 Nm)
Rotation Speed: 0-100 rpm Fine controlled
Centralized control panel at rear end of the equipment for convenient view
of drill table provided with all necessary gauges, control system and
Control Panel
emergency switch. Locking arrangement is provided for the safety of control
panel
4 x Hydraulic levelling jacks are provided for quick setting and levelling of
the drill rig. Locking check valves for safety with adequate capacity to
Levelling Jacks withstand load.Expandable jacks are provided for self-loading purpose.The
clearance between ground level to rig 1400 mm is provided for easily
loading on low bed trailer.
Hydraulic operated break out wrench is provided for fast breaking of rod
Breakout Wrench
joints
Hydraulic operated water injection triplex pump with necessary fittings,
pressure regulator, flow regulator, check valve and suction filter are
Water / Foam provided.
Injection Pump
Maximum Flow: 50 lpm
A positive acting venturi type inline lubricator is provided for injecting oil to
the down hole hammer.
Airline Lubricator
Tank capacity: 15 litres
Additional
Night Lights, Tools box, Hammer stand
Fitments
Crawler 10 T Crawler
Maximum Hoist
Winch : 2 ton (20 KN)
Capacity(up)
Optional
Single Rod Changer
Attachments