Professional Documents
Culture Documents
Note!
No spring included in this kit. See the Spring
Rebound Adjuster Guide in this folder, or contact an Öhlins dealer
for advice.
Öhlins products are subject to To find the latest information contact Shock Absorber for Yamaha WR 450 F
YA 1384
continuous improvement and your Öhlins distributor. Please
development, therefore, although consult your Öhlins dealer if you
these instructions include the most have any questions regarding the
up-to-date information available at contents in this document.
the time of printing, minor updates
Part no. YA 1384_0
may occur.
Issued 2012-10-15 Mounting Instructions
© Öhlins Racing AB. All rights Öhlins Racing AB
reserved. Any reprinting or Box 722
unauthorized use without the written S-194 27 Upplands Väsby, Sweden
permission of Öhlins Racing AB Phone +46 8 590 025 00
is prohibited. fax +46 8 590 025 80
www.ohlins.com
Spring Guide How to install
Brand Rider’s weight* Spring Spring rate Warning! 2
kg/pounds N/mm It is advisable to have an Öhlins dealer install the Make sure that all removed parts are
Yamaha WR450F 60/132 06310-10 52
65/143 06310-11 54 shock absorber. reinstalled in the same way as they were
70/154 06310-11 54 before the installation of the Öhlins shock
75/165 06310-11 54 Warning! absorber.
80/176 06310-12 56 When working on a raised vehicle, make sure
85/187 06310-12 56
90/198 06310-12 56 the vehicle is securely supported so that it will Caution!
95/209 06310-13 58 not tip. Make sure that all screws are tightened to the
100/220 06310-13 58
correct torque and that nothing fouls or restricts
105/231 06310-14 60
110/242 06310-14 60 When installing, consult your Vehicle Service movement of the shock absorber when the
115/253 06310-15 62 Manual. suspension is fully compressed or extended.
Install the Spring * Rider’s weight: Rider wearing all riding equipment at low speed to make sure that your vehicle has
maintained its stability.
Note!
Install the spring to the shock absorber before If the suspension makes an abnormal noise,
installing the shock absorber on the vehicle. Spring or the function is irregular, or if you notice any
platform leakage from the product, please stop the
1 vehicle immediately and return the product to an
clamp 2
Measure the free length of the spring (A). Öhlins Service Centre.
2 Spring
1
Loosen the screw on the spring platform platform
clamp so that you can move the spring
1
platform as far up as needed to install the
Bump rubber Install the Öhlins shock absorber according to
spring.
the vehicle manual.
3
Put the shock absorber up-side-down in a Note!
vice so that you can install the spring and the Spring Before installing the Öhlins shock absorber clean
spring clip. the vehicle thoroughly.
A 1
3
Note!
The spring platform and spring are press fitted.
Push hard to install the spring.
4 Spring clip
Measure the spring length. Adjust the spring
preload to the recommended setting, see
section Adjustments and Set-up data in this
folder.
5
Note!
Install the shock absorber to the vehicle
Tighten the screw on the spring platform clamp
according to the procedure in this folder.
before riding the motorcycle.
Check sag and ride height (see the Owner’s
Manual) and adjust the spring preload again
if necessary.
1 2