Professional Documents
Culture Documents
198
Nylon nut M12 2
The standard preload is 2 mm from a free
length of 200 mm, giving 198 mm installed MOUNTED ON SHOCK ABSORBER
length, see fig ③. Spring preload Adjuster 2
adjuster
Set-up Data USED FOR BOTH FRONT AND REAR
33
C-spanner 1
Height
Recommended set-up C-spanner 1
adjuster
Rebound 10 clicks Öhlins sticker 1
605
Spring preload 2 mm Öhlins Owner's Manual 1
Shock absorber length 605 mm
Spring
Spec H200, ID65, 100N/mm
Please note that during storage and
The actual vehicle height
transportation, especially at high ambient
With both the preload and height adjustments
temperature, some of the oil and grease used for
in their standard positions, the vehicle is
assembling may leak and stain the packaging.
lowered approximately 20 mm when compared
This is in no way detrimental to the product, wipe
to the original suspension. As the height
off the excess oil/grease with a cloth.
adjuster is turned one rotation, the position
moves 1.5 mm.
6 Cut
Install the Öhlins shock absorbers on the
vehicle.
7
Fasten the upper attachments.
Adjustments Before installing this product, check the contents
of the kit. If anything is missing, please contact an
③ Öhlins dealer.
Before driving, always make sure that the
basic settings made by Öhlins are according to
recommended Set-up Data. Read about
adjustments and setting up in the Öhlins Kit Contents Pcs.
Owner's Manual before you make any Shock absorber 2
adjustments. Contact an Öhlins dealer if you Dust boot 2
have any questions about setting up the shock Height Top mount 2
absorber. adjuster Nylon nut M10 2
Nut M12 2
Spring 2
Set-up Data Spring height adjuster
Tie-rap
2
4
Recommended set-up
44
155
Rebound 10 clicks
USED FOR BOTH FRONT AND REAR
C-spanner 1
Spring height adjuster 1
C-spanner
44 mm (see fig ③) Öhlins sticker 1
Öhlins Owner's Manual 1
Spring
492
Bearing spacer
44
4 spring seat
Remove the original spring.
5
Set the spring height adjuster to the position
according to fig ②. It is set at the bottom when Tie-rap Rebound
delivered.
adjuster
6
Install the Öhlins spring and the spring height
adjuster on the vehicle.
7
Nut M12 Std bolt
Mount the the dust boot on the Öhlins shock
absorber according to fig ①. Tighten only the
lower tie-rap. Fit the top mount on the shock
absorber according to fig ①. Tighten the
nylon nut to 20 Nm.