Professional Documents
Culture Documents
Mold venting is critical to the quality and consistency of the finished part.
Venting is required to remove air from the sprue, runner and cavity from the tool
as the melt flows into the cavity. Inadequate venting may cause short-shots,
poor surface appearance, or weak weld-lines.
ø6 30
The Vacuum Jet may be the venting solution for you. Each unit uses 21
compressed air to create a venturi vacuum within the cavity to remove 16 8.5
trapped air. A seal should be placed around the cavity to maximize its AIR
efficiency. 17
VACUUMJET+
28
M6x25 ø10 52
DIN7991
3
Benefits: CUMSA
VG.523016
96
In the injected plastic part: In the process:
- Superior visual appearance (less sink marks) - Reduced scrap
- Dimensional stability (decreased weld lines) - Lower injection temperature & pressure
WARNING
EXHAUST AIR
- Uniform color - Increase in production
- Improve plastic distribution Silencer
ø16
ø6 30
21
16 8.5 Air
entrance
AIR
Air
entrance Vacuum
17 18
VACUUMJET+
28
M6x25 ø10 52
DIN7991
ø10+0.1
3
CUMSA
WARNING
EXHAUST
VG.523016
96
AIR
Min. 25 34
WARNING
EXHAUST AIR
Silencer Pin
© 2020 DME Company. All Rights Reserved. toll-free U.S. 800-626-6653 • toll-free Canada 800-387-6600
VACJ-4.20
dme.net • dme@dme.net • www.dme.net/estore