Professional Documents
Culture Documents
Supplement To The Operating Manual: Punch and Multi-Purpose Machines
Supplement To The Operating Manual: Punch and Multi-Purpose Machines
operating manual
Stripper selection
Punch and multi-purpose machines
Supplement to the
operating manual
Stripper selection
Punch and multi-purpose machines
Edition: 10/2006
Ordering information Please state the title of the document, the desired language
and the date of issue.
M087EN.DOC 5
1. Stripper selection
1)
The selection of the stripper dimension depends on :
x The (programmed) sheet thickness.
x The size of the shape to be punched.
x The tool length of the punch (new, reground).
– The tool length is defined as the dimension from the upper
edge of the alignment ring to the cutting edge.
1 Tool length
Fig. 45779
Special punch The following criteria apply to stripper selection when using special
punches:
x With special-purpose punches with an outer circle diameter
< 10.5 mm, the stripper must be selected from the line
"Punch 10.51-30.0" in the stripper selection table.
x With special-purpose punches with outer circle diameters
larger than 10.5 mm, the stripper must be selected according
to the outer circle diameter of the special punch.
1
The working height is increased by 1 mm if non-scratch machining is
selected. That is why the column in the stripper selection table with the
next highest sheet thickness must be referred to for the selection of the
stripper (with LDP - and UDP - offset 0 0).
Tab. 1
Tab. 2
Tab. 3
Tab. 4
2.1 Example 1
Fig. 45782en
Fig. 45783en
Fig. 45859en
Solution Note
For non-scratch machining, 4+1 mm must be selected for the sheet
thickness in step 3.