Professional Documents
Culture Documents
文章编号:CPPC-2019-D011
摘 要: 花瓣形电子回旋加速器(Rhodotron)中,电子束在加速器中心发生交叉,将对束流品
质形成影响。通过脉冲电子枪的栅极调制,以较高重复频率产生电子束脉冲,从而降低电子束的能散
度以及降低加速器中的束流损失。本文以 Blumlein 传输线结构为基础,结合驱动-MOSFET 一体封装
的开关 IXYS IXZ631DF12N100,并且通过 PCB 电路布局优化、驱动电路抗弹地设计,实现开关开通
时间小于 1.7ns。为避免高频脉冲对控制信号干扰,设计了具有高传输带宽的光纤隔离触发电路。同时,
本文也对超高频运行工况下发生器散热方案进行了设计。在 50Ω负载上实现了连续重频 5MHz,100ms
间隔触发下 10.75MHz 运行。最终输出脉冲半宽 5ns,上升时间 1.6ns 的亚纳秒超高频脉冲。
关键词: 脉冲源;脉冲电子枪;亚纳秒;超高频
随着我国航天航空、国防军工、轨道交通等行业的快速发展,用于关键设备无损检测高能 X 射线
工业 CT 越来越凸显其价值 [1-3]。具有微焦点、大剂量率的加速器是高能工业 CT 的关键部件 [4]。1989
年法国的 J.Pottier 提出一种新型的射频加速器 Rhodotron(花瓣加速器,或者花瓣回旋加速器)是可选
方案之一 [5] 。但由于多个射频周期内的电子束同时在同轴线谐振腔中加速,电子束将在加速器的中心
发生交叉、碰撞,这将对束流品质造成影响。通过电子枪栅极的脉冲调制,可以有效规避以上问题。
此时,电子枪将以 10.75MHz 的重复频率产生电子束脉冲,每个电子束脉冲的宽度达到亚纳秒级,从
而降低电子束的能散度以及降低加速器中的束流损失。这要求用于进行电子枪束流引出和栅极控制的
电子腔电源的重复频率达到 10.75MHz,且脉冲宽度 5ns 的亚纳秒脉冲源。
1 发生器设计
1.1 电路设计
发生器以 Blumlein 传输线结构为主电路结构,如图 1 所示。其中 Z1 和 Z2 为形成脉冲的传输线;
开关 M1 用于控制传输线波过程;电阻 Rcharge 为电路充电电阻,阻值大小直接影响高频下输出效率;
电阻 Ro 为大阻值隔离电阻。从 Blumlein 传输线形成的基本原理可知,开关 M1 的动作时间直接决定了
形成脉冲的上升时间。从本文设计参数可知脉冲宽度需要达到 5ns,此时要求脉冲上升时间接近 2ns。
由于使用了 IXYS 公司驱动开关一体的开关,通过设计低杂散电感电路、扩大接地避免弹地等方案设
Rcharge M1
C0 Z1 Z2
Udc Ro
RL
计实现了尽可能快的开关前沿。
Fig.1 Generator circuit schematic diagram
图 1 发生器电路原理图
673
第六届全国脉冲功率会议论文集
Signal-In Signal-Out
Fiber
transmitter receiver Gate Driver
图 2 光纤隔离电路原理图
1.2 散热方案
开关损耗主要由开通损耗、关断损耗和通态损耗三部分组成,脉冲运行条件下开关的开关损耗是
引起发热的主要原因。瞬时损耗功率可以由电压电流相乘得到,而平均损耗功率如公式(1)。
1
T
P uds (t )i (t )dt (1)
d
0.15mm 23mm
3.18mm
9mm
0.15mm
开关
散热片
图 3 散热结构示意图
c v 1/5 Pr 2/3
Rsa (2)
1.16kbne 0.037 SL4/5 pc p u 4/5
674
第六届全国脉冲功率会议论文集
(a).未施加散热方案 (b).施加散热方案
Fig.4 Simulation results of heat dissipation
图 4 散热仿真结果
2 实 验
图 5 为实验过程图,通过同轴线实现脉冲输出负载端匹配 50Ω无感电阻,测量方式为力科 500M
低压探头,当然由于探头测量方式的误差,其输出波形为尖顶波,波形如图 6 所示,此时可以看到输
出频率为 10.75MHz,电压峰值为 508V,脉冲上升时间小于 2ns。
Fig.5 Experiments
图 5 实验图
图 6 10.75MHz 输出波形
675
第六届全国脉冲功率会议论文集
图 7 5ns 方波波形
图 8 温度记录结果
3 结 论
本文中,我们采用驱动-MOSFET 一体封装的开关 IXYS IXZ631DF12N100,以 Blumlein 传输线结
构为发生器主电路结构。通过阵列充电电阻隔离、分流,实现 10.75MHz 频率下脉冲可靠输出。为了
有效避免高频脉冲对信号控制端的干扰,设计了基于光纤隔离的信号驱动电路。同时通过分析主开关
热阻模型,提出发生器散热方案。最终实现发生器在 50Ω负载条件下,连续 5MHz,触发 10.75MHz
的动作,上升时间小于 2ns,脉冲宽度小于 5ns。
676
第六届全国脉冲功率会议论文集
参考文献:
2016(1)..(Kang Kejun, Chen Zhiqiang, Xiao Yongshun, et al. industrial CT imaging for detecting defects in large scale
equipments. Chinese journal of stereology and image analysis, 2006, 21(1): 0014-0021)
[2] Lawrence Livermore National Laboratory. A CAT Scanner for Nuclear Weapon. 2009
[3] National Nuclear Security Administration Nevada Field Office. Ten -Year Site Plan. 2015.
[4] Uhlmann N , Voland V , Salamon M , et al. Metrology, applications and methods with hig h energy CT systems[J]. Security,
2014, 1581(1):1778-1785.
[5] Pottier J . A new type of rf electron accelerator: The rhodotron[J]. Nuclear Instruments & Methods in Ph ysics Research,
China;2. Institute of Fluid Physics China Academy of Engineering Physics , Mianyang Sichuan 621999 , China)
Abstract: In the petal-shaped electron cyclotron (Rhodotron), the electron beam crosses at the center of the accelerator,
which will affect the beam quality.The pulse electron beam is generated at a ultra -high frequency by the gate modulation of
the pulse electron gun, thereby the energy dispersion of the electron beam and the beam loss in the accelerator are all
reduced.Based on the structure of Blumlein line, combined with the driver-MOSFET integrated package switch IXYS
IXZ631DF12N100, and through the optimization of PCB circuit layout and the anti-bullet design of driving circuit, the
turn-on time of the main switch is less than 1.7ns.In order to avoid the interference of ultra -high frequency pulses on
control signals, an optical isolation trigger module with high transmission bandwidth is designed.At the same time, this paper
also designs he generator cooling scheme of the generator under ultra-high frequency operating conditions.The continuous
re-frequency is 5MHz on a 50Ω load and the 10.75MHz operation is triggered at 100ms intervals.The final output pulse has a
half-width of 5 ns and a sub-nanosecond ultra-high frequency pulse with a rise time of 1.6 ns.
Key words: pulse generator; pulse electron gun; sub-nanosecond; ultra-high frequency
677