Professional Documents
Culture Documents
Turning Power On
WARNING
Do not use the patient monitor for any monitoring procedure
on a patient if you suspect it is not working
properly, or if it is mechanically damaged. Contact your service
personnel or us.
Starting Monitoring
Coution
Although not recommended, you can press and hold the power
on/off switch for 10 seconds to forcibly shut
French ^ â, ê, û, î, ô
¨ Ä, Ë , Ü, Ï , Ö
Note
The changed language is applied only after the patient monitor is
restarted.
Setting Parameters
Switching the Parameters On/Off
To switch the parameters on or off, select
[Main Menu]→[Screen Setup >>→ ][Screen
Layout >>→ ][Parameters
NOTE
ECG is always selected, and you cannot switch it off.
Operating Mode
This section lists the major operating
Modes.
Monitoring Mode
This is the normal, everyday working mode
that you use for monitoring patients. Your
monitor automatically enters the
monitoring mode after being turned on.
Privacy Mode
Privacy mode is only available when an
admitted patient at a patient monitor is also
monitored by the central station.
To activate the privacy mode, select [Main
Menu→ ][Screen Setup >>→ ][Privacy
Mode].
monitor.
power] is presented.
monitor.
Night Mode
Outdoor Mode
The outdoor mode is intended for
transferring patients outdoors. In this
mode, the parameter color is white and
Demo Mode
In Demo mode, the monitor can
demonstrate its major functions when a
patient or patient simulator is not
connected.
The Demo mode is password protected.
To enter the Demo mode,
1. Select [Main Menu]→[Maintenance >>].
2. Select [Demo >>]. Enter the required
password and then select [Ok].
To exit the Demo mode,
1. Select [Main Menu]→[Maintenance >>].
2. Select [Exit Demo] →[Ok].
WARNING
The Demo mode is for demonstration purpose only. To avoid the
potential risk of the simulated data being
Mistaken for the monitored patient’s data, do not enter the Demo
mode while monitoring a patient.
Otherwise, improper patient monitoring and delayed treatment could
occur.
Standby Mode
In Standby mode, you can temperately stop
patient monitoring without turning off the
monitor. To enter the standby
mode, select [Main Menu→ ][Standby].