Professional Documents
Culture Documents
A B
3"
@ top of each Continuous through angles for †" dia. A325 bolts 1‚"
TS 4"x 4"x ‚" 1'-0"
vertical bar. holes in channel. 3" ƒ" x 2†" slotted holes in
(typ.) TS 1"x 1"x „" 1"
Top of Cap is held in place
C C angles for †" dia. A325 bolts
9"
channel with two self tapping
L 5"x 3"x •"
screws (180° apart).
C4x 5.4 (2•" long)
03-2016
road)
C4x 5.4 1Ž "1ˆ" 2†" Typ.
„
6" Œ" Typ.
l
‚
n.for Rai
es
L 3"x 2" x •"
Vari
ƒ" dia. hole in channels for †" dia. A307 bolt.
n.
(2•" long)
-0" mi
det3243
B
washers, allowing screening horizontal movement.
-0" mi
TYPICAL EXPANSION JOINT CONNECTION DETAILS
8'
Extg. 4"
10'
1‚"
Top of rail 3" ƒ" x 1‚" slotted holes in
(
channel TS 1"x 1"x „" •"
angles for †" dia. A325 bolts (typ.)
C4x 5.4
Top of conc.
A
parapet wall
Note:
C4x 5.4 Typ.
‚" x 3" plate Anchorage configuration varies „
depending on structure details. L 3"x 2" x •" Typ.
See Detail "B" ‚
Shim as needed See detail drawings. (2•" long) typ.
3" x 3" x ‚"
Welded wire mesh to make level and plumb TYPICAL CONNECTION DETAILS
SECTION "C-C"
-0"
No Scale
1'
-0"
SECTION
1'
ELEVATION - TYPICAL SCREENING PANEL
Scale : ƒ"= 1'-0"
-0"
Slope of screening panels may vary. Provide ‰" long flare bevel groove welds @ 2'-0" each
1'
See plan sheets for additional details at specific structures. way to 1" square tubes.
Screening panels shall match the slope of the bridge (|1% slope) Provide a minimum of 2 welds in mesh below bottom C4 x 5.4.
while maintaining vertical alignment of wire mesh and 1" square tubing. Wire mesh to be parallel with vertical bars.
Fabricate parallelogram panels in 0, 2, 4, 6, 8% step increments. Place and weld wire mesh on the outside face of the
See Detail "A"
See DET3244 for Fence Support Details. protective screening.
Maximum ‚" gap between wire mesh and edge members.
C3 x 5 Outside Diameter= C
(C= B-(1'-10•") or C= (B+1•")-2'
3" x 3" x ‚"
Welded wire mesh
B B
1•"
3" x 3" x ‚" BTC-P10-GF
A A Welded wire mesh 5@2'-0" *
3"
1:16 - det3243