Professional Documents
Culture Documents
1
INSTRUCTION
Precautions and recommendations
1 9
Do not leave the marina in strong If the anchor caught the ground, don’t
winds above 27 knots! pull it up, otherwise the chain may be
broken and the anchor will stay on the
2 ground.
Do not use the engine speed above 2500 10
turns.
To lift the hooked anchor up you need
3 to loose some more chain, after that turn
It is allowed to use the engine the yacht at another angle and try to pull
speed above 2500 turns only for up the anchor once again.
maneuvering. 11
4 When starting the engine at idle,
Don’t use the bow thruster increase its speed up to 3500 turns for a
(maneuvering device on the bow) couple of seconds and check if the water
more then 5 seconds. is coming of the exhaust pipe.
5 12
Don’t anchor in the wrong place.
Watch on the water during
When sleeping at anchor, check
parking reverse to avoid
the weather forecast. Make sure
winding of the mooring lines on
that your bay is safe.
the propeller
13
6 It’s better to give the way to all
Also during reverse parking beware vessels for you can be out of sight
of hidden hazards that may damage of another boat . Avoid collisions !
the rudder. 14
7 When anchoring, make sure that your
Removing the anchor go ahead at a chain does not cross another one.
low speed 0.3 kn in the line of the 15
chain. This will unload anchor winch Don’t forget to adjust backstay! Keep it
and the anchor winch fuse will not be tight on a broad course, and loose it on a
broken. close course.
8
When you leave the boat and there
is no one on it closes the board .
Otherwise in the case of unfavorable
wind it may smash hinge side against
pier.
Well, it’s the first time you are onboard ELAN I 45.1
Seven unforgettable days and nights (maybe more) are
ahead. Yacht is your home now, and it means that your should
learn its either technical or household features to avoid
embarrassing situations and breaks.
3
WC WC
(toilet + sink + shower)
First you should pay attention to the
toilet. Those who have no prior sailing
experience may face some difficulties with
bathroom and in particular toilet bowl
exploitation.
Grate
If the water does not go If the hose does not come out don’t
down, check there is no pull it!
dirt under the water grate It may catch on something inside.
To release the hose , open the box
under the sink and correct it.
5
Galley
Galley and dining area are the most spacious space of a lower
deck. There’s enough place for three hostesses during of
cooking and whole crew can sit for dinner easily.
The galley is equipped with everything needed for
housekeeping.
Washer
There is a built-in washer in the kitchen. Just like stove, it can
be closed with piece of table top. The tap is standard.
6
When the yacht
goes under sails all
things must be fixed.
Put the food, dishes,
cutlery into the
boxes. Each box has
a locking handle.
button.
.
Door lock
7
Refrigerator
Gas
8
Grill and refrigerator in the cockpite
9
Captain’s brdige
If there is no WI-Fi
signal
1) Check the network
breakdown.
2) Check the tumbler 9
(WIFI) is on
3) If everything is
on, switch off the
1)Cockpit radio. tumbler 9 (WIFI)
2) Remote control for a few minutes
for TV and switch it on
3)Air conditioning again.
control panel 4) The network is to
4) Universal resume in a few
adapter for Euro minutes.
socket 220 volts
Tank and battery level indicator
1 10 19
2 11 20
3 12 21
4 13 22
5 14 23
25 28 6 15 24
26 29 7 16
27 8 17
9 18
1. Anchor light
2. Navigation lights 16. Anchor winch
3. Running lights 17. Bow thruster
4. Tricolor top lights 18. Fridge
5. Deck lights 19. Water heater
6. Interior lights 20. Battery charger
7. Cockpit lights 21. Air condition
8. USB/12V Sockets 22. Galley appliances
9. WI- FI 23. Sockets 220V
10. Water pump
11. Shower pump 24.
12. Bilge pump (automatic) 25.Engine
13. Bilge pump (manual) 26.Consumers
14. Waste pump 27.Inverter
15. Instruments, autopilot
11
Main circuit breakers and switches
One Cable is
responsible for
power supply from
the shore and the
air conditioner
If anchor winch doesn’t work check
the circuit breaker (yellow) Is on . It is
located in the back cabin under the
mattress in the last box..
12
If the fuse is blown
Warning!
Replace the fuse with an equivalent rated one !
13
Cabins
All cabins equipped with lockable cabinets and lights
Start and service batteries are Above the mattress is anchor winch ‘s
under the mattress in aft port box. Under the mattress there is There is the battery under
cabin . Also main switches empty box the mattress
*Batteries on the yacht are designed for 24 hours of battery life, to charge the batteries you need to
connect to the shore power supply or start the motor for 1-2 hours.
Warning !
If you are going to put your suitcase unddr the
mattress choose an empty box!
Otherwise , due to the pitching , the suitcase
may damage the wiring , switches, bow
thruster and so on.
14
Smart TV connected to the
Internet
Prohibited
16
Climate system filter cleaning
17
Where are the important things on the yacht?
18
There is a bow thruster in the
forward cabin under mattress.
Do not put anything on it!
Its safety fuse is also there
Autopilot
Multifunctional
GPS B&G
Music is operated via
the drop-down menu
of the chartplotter
(FUSION Bluetooth
function )
12
Multifunctional device 3
shows yacht’s speed, wind
direction and force, depth
Horn
.
Bow thruster is activated by pressing
simultaneously buttons 1 and 2 .
Operation: Button 1- Bow to port
Button 2- Bow to starboard
Button 3- Off
Automatic shutdown after 5 min standby mode.
Do not hold the button (1 or 2 ) more 5
seconds.
It may blow a fuse! 19
Electric winches
20
Manual bilge pump
Stern shower.
Cold and hot
water.
21
Gas handle
Gas handle
A rather tricky
mechanism.
To go ahead, smoothly
move gas handle
forwards (towards the
1 bow).
To go back, smoothly move
gas handle abaft (towards
the stern).
All movements should be
smooth.
Watch the engine speed!
Do not go above 2.5
mark!
22
Engine handling
23
Anchor locker contains the
zinced chain and anchor
winch.
The chain is tied !
Do not give up the chain
completely, keep some chain
for future use!
Anchor winch
operation buttons
Life raft
24
Engine
Engine coolant
Don’t forget to check coolant
level before sailing!
Dip stick
(a probe for checking
engine oil level)
Don’t forget to check oil
level before sailing!
25
Departing marina in Pirovac
Pirovac
Заправка
Use only marked passages otherwise the depth will not let you go
between other islands.
26
DO NOT go under Ugljan-Pasman
bridge !
×
Ždrelac Bridge, connecting Ugljan and
Pasman islands is rather low – only
16,5 m high. There is no passage for
yachts under the bridge!
×
×
27
Information page Emergency phones and radio
channels
+385 23 77 70 08
112 — Emergency operations
Base manager phone number service
+385 91 222 30 55
Major emergency
phones:
SEA HELP – VIKTORIA ORLIC
(tel. +385 919 112 112 or 0800 192 — Police
112 00 112) (VHF 16 ) 193 — Fire emergency
194 — Ambulance
195 — Rescue service
Coast guard
Response at VHF channel 16
In case of emergency
contact the charter
company!
What actions you should take if accident happened?
tel/fax
Pula Dolores 052 222 037
052 535 877
52100 Pula, Brenko tel. 052 535 881 tel.
052 535 888
Riva 18 Škerjanc 052 535 870
Pula.pomorskipromet@pomorstvo.hr
voditelj Odjela:
Edo Kovačević
Rijeka
voditelj Odjela: tel.
51000 Rijeka, 051 211 422
Darko Glažar Vladimir Malnar 051 214 031
Senjsko 051 211 537
tel. 051 212 474 fax.
pristanište 3
fax. 051 212 696 051 313 265
Rijeka.pomorskipromet@pomorstvo.hr
voditelj Odjela:
Senj
inspektor: Danijel Vrzić
53270 Senj, Nenad 053 881 301
Neven Tomljenović tel.
Obala kralja Bugarin 053 884 128
tel. 053 881 301 053 881 301
Zvonimira 12
senj.pomorskipromet@pomorstvo.hr
voditelj Odjela:
Denis Livljanić
Zadar
inspektor: tel.
23000 Zadar, Alen 023 254 888
Boris Medić 023 254 880
Liburnska obala Rukavina 023 250 235
tel. 023 254 886 fax.
8
023 254 876
Zadar.pomorskipromet@pomorstvo.hr
voditelj Odjela:
-
Šibenik
inspektor: tel.
22000 Šibenik, Robert 022 217 217
Peroslav Kronja 022 217 214
Obala Franje Baljkas 022 217 378
tel. 022 217 217 fax.
Tuđmana 8
022 212 626
sibenik.pomorskipromet@pomorstvo.hr
voditelj Odjela:
Ivica Vuletić
Split
voditelj Odjela: tel.
21000 Split, Željko 021 302 400
Ivan Paušić, v.d. 021 362 436
Obala Lazareta Kuštera 021 361 298
tel. 021 302 409 fax.
1, p.p. 317
021 346 555
Split.pomorskipromet@pomorstvo.hr
voditelj Odjela:
Ploče Dubravko Paskojević v.d.
inspektor:
20340 Ploče, tel. 020 679 008
Joško Nikolić Toni Grgić
Trg kralja 020 679 008 020 678 621
tel. 020 670 506
Tomislava 24 020 670 206
Ploce.pomorskipromet@pomorstvo.hr
voditelj Odjela:
Dubrovnik Zvonimir Cetinić 020 418 988
voditelj Odjela:
20000 tel/fax. tel/fax.
Mato Kekez Igor Jadrušić
Dubrovnik, 020 418 989 020 418 987
tel. 020 418 984
Vukovarska 16 020 419 211 020 418 9
Dubrovnik.pomorskipromet@pomorstvo.hr
31
Information page
CROATIAN OFFICE
CONTACTS
OFFICE PHONE NUMBER IN Office schedule:
CROATIA Fri, Sat: 08-20
+385 23 77 70 08 Sun: 08-12
OFFICE ADDRESS Mon - Thu: 08-16
Obala Rtine 1A, 22213 Pirovac,
Croatia EMAIL
info@aquatoria-yachting.com
MARINA PIROVAC office@aquatoria-yachting.com
BEARINGS
43°48'58,32" N TELEGRAMM
15°39'47,65" E aquatoriapirovac