This document provides instructions for making a "Twister Stone Capture" jewelry piece. It uses various gauge silver wire rings and a 17mm twister stone from Swarovski. The instructions include 12 steps showing how to assemble the rings in a specific configuration, weave in the stone, and close the piece securely with additional rings. Making this capture involves rotating and weaving the rings together to create an intricate cage-like structure around the center stone.
This document provides instructions for making a "Twister Stone Capture" jewelry piece. It uses various gauge silver wire rings and a 17mm twister stone from Swarovski. The instructions include 12 steps showing how to assemble the rings in a specific configuration, weave in the stone, and close the piece securely with additional rings. Making this capture involves rotating and weaving the rings together to create an intricate cage-like structure around the center stone.
This document provides instructions for making a "Twister Stone Capture" jewelry piece. It uses various gauge silver wire rings and a 17mm twister stone from Swarovski. The instructions include 12 steps showing how to assemble the rings in a specific configuration, weave in the stone, and close the piece securely with additional rings. Making this capture involves rotating and weaving the rings together to create an intricate cage-like structure around the center stone.
This is a quick guide to how to make this capture!
18 SWG 1/4”
14 SWG 5/8”
18 SWG 1/8” 16 SWG 5/16”
18 SWG 5/32”
Also needed is a 17mm
twister fancy stone from Swarovski. Close the 18 SWG 5/32 then add them on to the 14 SWG 5/8”. There should be eight. Take the four 18 SWG 1/4” and attach each one as shown through two of the 18 SWG 5/32” Arrange the rings as shown. It is sort of like you would with euro 4 in 1. You will take one of the 18 SWG 1/8” and attach two 18 SWG 5/32” as shown in the photo below. Repeat previous step all around. It should look like the picture above. This is the trickiest part. Rotate the rings outward. This step may take a few attempts. It should look as above after the rotation. NOTE: this is shown above with the back side facing you. The next step you will need to turn it over. Now it’s time for the 16 SWG 3/8” rings. You will only take two at first and weave them onto the 18 SWG 1/4” as shown. Place the stone inside as shown and add another 16 SWG 3/8” onto the 18 SWG 1/4” as you did with the previous two. This time over the corner of the stone. Woohoo! The last 16 SWG 3/8” ring is woven in like the third. Your stone should be secure enough to not fall out at this time but it is still a little loose. This is a view of the back before we cinch it up. The last two rings added are 18 SWG 1/8”. They will connect as shown above two of the 18 SWG 1/8” from earlier. These will be tight to get in but they tighten up the entire piece.