Professional Documents
Culture Documents
CC Filter
VFK1345 VFK1346
VFK1659
VFK1660
INF-1
2. Recommended Measuring Instrument
Name Remarks
Vector scope For Camera Adjustment
USB cable (A type ↔ B type) For Camera Adjustment
Audio level meter For Audio Adjustment
Audio analyzer For Audio Adjustment
INF-2
3. Lithium Battery
3-1. Replacement Procedure
1. Remove the Sholder Pad and Side Case (R). (Refer to “SEC3. Disassembly Procedures” )
2. There is a Lithium battery “Ref No.: B8100 / Part No.: ML-614S/ZT” on the “R SIDE Board”
3. Insert the screwdriver to groove of the Lithium Battery Holder and press down it to remove the Lithium Battery.
(Pay attention for remove of battery to be pop-up)
R SIDE Board
Lithium Battery
NOTE:
The lithium battery is a critical component.
It must never be subjected to excessive heat of discharge.
It must therefore only be fitted in equipment designed specifically for its use.
Replacement batteries must be of the same type and manufacture.
They must be fitted in the same manner and location as the original battery, with the correct polarity contacts
observed.
Do not attempt to re-charge the old battery or re-use it for any other purpose.
It should be disposed of in waste products destined for burial rather than incineration.
INF-3
4. Service Mode
4-1. Indication method of the service menu
1. Set the mode dial other than PC connection mpde.
2. While keep pressing “LEFT (◄) of Cursor” button and Delete button, hold down the Mode Select Switch
towards to FOCUS position for more than 3 seconds unit the top screen of the Service Menu being displayed.
NOTE:
Do not using mode except [1] of Service Menu.
INF-4
4-2. Factory Setting
4-2-1. How to turn on the Factory Setting
1. Open the Service mode.
2. Under the codition of the Item No.1 is yellow high lighted, press the RIGHT (►) of cursor button.
3. Press the UP (▲) of cursor button to select “YES” and then press the CENTER (●) of cursor button to start
the Factry Setting processing.
4. After few seconds“END” is displayed on LCD monitor and the shutter effect is sounded.
END
INF-5
5. Operation after major part exchanged
5-1. Operation List
These are items that must be done when the major part has been changed.
X: Operation required
Version Clock
Board or Ass’y Adj. EEPROM Setting Remark
Conf.
MAIN X X X
SUB Not required
AUDIO POWER Not required
OP CN Not required
R SIDE X
MONITOR Not required
INF-6
5-2. Operation flow chart after board exchange
NO
Exchange the MAIN Board and load
the back up data to new board.
MAIN Board is exchange
Overall check
INF-7
5-2-2. R SIDE Board
Overall check
Overall check
Overall check
INF-8
6. Circuit Board Layout
MIC P.C.Board
EVF/HANDLE UNIT
HANDLE CN
BATTERY / P.C.Board
REAR JACK UNIT
EVF BL P.C.Board
BATTRY P.C.Board
GRIP CN P.C.Board
XLR SUB P.C.Board
JACK P.C.Board
USB CN P.C.Board
SD CARD P.C.Board
EXT MIC P.C.Board
R SIDE P.C.Board
CAMERA UNIT MAIN P.C.Board
AUDIO POWER
P.C.Board
SUB P.C.Board
SIDE CASE (R) UNIT
INF-9