EPAO7/10/GH614 DD Platform General Information / Preventive Maintenance Workshop Manual
EPA07/EPA10/GHG14/GHG17 Preventive Maintenance Tables - 93K222(CK-4) and
93K223(FA-4)
ot Note: Actual fuel filter life will vary based on fuel quality
st Note: Diesel Oxidation Catalyst (D0C) and the Selective Catalytic Reduction (SCR
Catalyst) do not require maintenance. (Does not apply to EPAO7)
“Note: ifyour vehicle has the Maintenance System enabled, please follow the
recommendations communicated via the ICU Panel or Detroit Connect for Engine Oil
and Oil Filter.
wt Note: Refer to your vehicles Driver's Manual for a detailed explanation of the
Maintenance System.
93K222(CK-4) and 93K223(FA-4) Oil Service Interval Definitions (applies to the following tables):
Efficient Long Haul (over-the-road transport) service applies to vehicles that annually travel more than 60,000 mi
(96,000 kilometers) and average greater than 7 mi per gallon with minimal city stop-and-go operation and
minimum idle.
Long Haul (over-the-road transport) service applies to vehicles that annually travel more than 60,000 mi (96,000
kilometers) and average between 6.0 and 6.9 mi per gallon with minimal city stop-and-go operation
Short Haul service applies to vehicles that annually travel up to 30,000-60,000 mi (48,000-96,000 kilometers) and
average between 5.1 and 5.9 mi per gallon
Severe service applies to vehicles that annually travel up to 30,000 mi (48,000 kilometers) ot average less than 5
mi per gallon or that operate under severe conditions. Severe service also applies to RV applications. Only one of
these conditions needs to be met to categorize an application as Severe Service.DD13: Maintenance Intervals EPA07/EPA10/GHG14/GHG17 with ULSD Fuel
EPA10/GHG14/GHG17 Using DFS 93K222(CK-4) or 93K223(FA-4) Approved Oils
EPAQ7 Using DFS 93K222(Ck-4) Approved Oils
Efficient Long Haul
(7.orbetter Long Haul Short Haul + Severe +
component | MPG* (60-69MPGy* |(6.1-59MPG)* | (Up to SOMPG)*
Replace every Replace every | Replace every 40,000 Replace every 35,000
Oil Filter § 65,000 mi (105,000 | $5,000 mi (89,000 | mi (64,000 km) or | mi (56,000 km) or 750
km)
km)
1000 hrs
hrs
Lubricating Oil §
Replace every
65,000 mi (105,000
km)
Replace every
55,000 mi (89,000
km)
Replace every 40,000
mi (64,000 km) or
1000 hrs,
Replace every 35,000
mi (56,000 km) or 750,
hrs
Engine Fuel Filter *
Replace every
65,000 mi (105,000
km)
Replace every
$55,000 mi (89,000
km)
Replace every 40,000
‘mi (64,000 km) or
1000 hrs
Replace every 35,000
mi ($6,000 km) or 750
hrs
Engine Fuel Filter *
w/ Frame-Mounted
Replace every
100,000 mi
Replace every
100,000 mi
Replace every 80,000
mi (128,000 km) or
Replace every 70,000
mi (113,000 km) or
site (161,000 km) (161,000 km) 1000 hrs 750 hrs
Frame Mounted Replace every Replace every | Replace every 40,000| Replace every 35,000
Fuel Filters ¢ 65,000 mi (105,000 | 55,000 mi (89,000 | mi (64,000 km) or | mi (56,000 km) or 750
km) km) 1000 hrs hrs
Valve Lash ‘Adjust every 500,000 mi (800,000 km) ‘Adjust every 200,000
Adjustment imi (322,000 km)
(GHG17)
Valve Lash ‘Adjust at 100,000 mi (160,000 km), at 500,000 mi (800,000 km), and then every 500,000,
Adjustment mi (800,000 km) thereafter
(EPAQ7, EPA10,
GHG14)
Coolant - Standard
Life
Maintain every
65,000 mi (105,000
km)
Replace every
300,000 mi
(482,000 km)
Maintain every
$55,000 mi (89,000
km) or 1 yr
Replace every
300,000 mi
(482,000 km)
Maintain every
40,000 mi (64,000
km), 895 hrs or 1 yr
Replace every
300,000 mi (482,000
km)
Maintain every 35,000
mi (56,000 km), 640
hrs or 6 months
Replace every 300,000
mi (482,000 km)DD13: Maintenance Intervals EPA07/EPA10/GHG14/GHG17 with ULSD Fuel
EPA10/GHG14/GHG17 Using DFS 93K222(CK-4) or 93K223(FA-4) Approved Oils
EPAQ7 Using DFS 93K222(Ck-4) Approved Oils
Component
Efficient Long Haul
(7.0or better
MPG)
Long Haul
(6.0-69 MPG)
Short Haul + Severe t
(6.1-59MPG)* —_| (Up to 50 MPG)***
Coolant - Extended
Life
Maintain every
130,000 mi
(210,000 km) or 1
yt
Replace every
600,000 mi
(965,000 km)
Maintain every
110,000 mi
(178,000 krn) or 1
yt
Replace every
600,000 mi
(965,000 km)
Maintain every Maintain every 70,000
80,000 mi (128,000 | mi (112,000 km) or 1
km) oF 1 yr yr
Replace every Replace every 600,000
£600,000 mi (965,000 | mi (965,000 km)
km)
Coolant System
Filter (if equipped)
Current engine designs no longer use coolant filters. If you have @ coolant filter, you may
choose to remove th
bulletin 157S-10Rev.
fe filter at your next maintenance interval. For more details reference
Inspect at oil Inspect at oil Inspect at oil Inspect at oil change**
change** changet* change*
Replace every 100,000
Belts? Replace every Replace every Replace every mi (161,000) 2600 hrs
200,000 mi 200,000 mi 100,000 mi (161,000)
(322,000 km) (822,000 km) 2600 hrs
Inspect at oil Inspect at oil | Inspect at oll change | Inspect at oil chan
Air System pect pect at spect at oll change | Inspect at oil change
change change
‘it Cleaner Inspect at oil Inspect at oil | inspect at oil change | Inspect at oll change
change change
Inspect at oil Inspect at oi! | Inspect at oll change | Inspect at oil change
Exhaust System r r Ps ge fins
change change
Inspect at oi in il chan il chan
Air Compressor Inspect at oil Inspect at oil | Inspect at oil change | Inspect at oil change
change change
Aftertreatment
Devices
Inspect external hardware and connections every 6 months or at oil change intervals. +DD13: Maintenance Intervals EPA07/EPA10/GHG14/GHG17 with ULSD Fuel
EPA10/GHG14/GHG17 Using DFS 93K222(CK-4) or 93K223(FA-4) Approved Oils
EPAQ7 Using DFS 93K222(Ck-4) Approved Oils
Component
Efficient Long Haul
(7.0or better Long Haul Short Haul + severe t
Mpc) (6.0-69MPc™ |(51-59MPG* — | (Upto SOMPG)"**
Diesel Particulate
Filter
EPA10 & GHG14
ACheck Engine Indicator or mileage/time intervals indicate when ash cleaning is,
required, Use DETROIT Diesel Corporation's authorized DPF cleaning procedure. Failure
to follow this procedure could result in engine and/or aftertreatment damage, causing
degraded vehicle performance including excess fuel consumption and decreased engine
lite
Normal DPF ash clean intervals are 300,000 mi (480,000 km) 9,000 hrs to 400,000 mi
(640,000 km) 10,250 hrs.
Detroit highly recommends exchanging the DPF with a Detroit™ genuine DPF to ensure
maximum life
Diesel Particulate
Filter
GHG17
ACheck Engine Indicator or mileage/time intervals indicate when ash cleaning is
required. Use DETROIT Diesel Corporation's authorized DPF cleaning procedure. Failure
to follow this procedure could result in engine and/or aftertreatment damage, causing
degraded vehicle performance including excess fuel consumption and decreased engine
life
Normal DPF ash clean interval is 500,000 mi (800,000 km) 11,000 hrs to $50,000 mi
(880,000 km) 11,500 hrs.
Detroit highly recommends exchanging the DPF with a Detroit™ genuine DPF to ensure
maximum life,
DEF Pump Filter
EPA10
Replace filter every 175,000 mi (280,000 km) or 3 yrs.t
DEF Pump Yellow
Filter GHG14.
Replace filter every 175,000 mi (280,000 km) or 3 yrs.t
DEF Pump White
Filter
GHG14 & GHGT7
Replace filter every 500,000 mi (805,000 km) or 3 yrs.t
DEF Pump Air
Bladder
2010 Engines only: Refill bladder with air every 24 months.DD13: Maintenance Intervals EPA07/EPA10/GHG14/GHG17 with ULSD Fuel
EPA10/GHG14/GHG17 Using DFS 93K222(CK-4) or 93K223(FA-4) Approved Oils,
EPAQ7 Using DFS 93K222(Ck-4) Approved Oils
Efficient Long Haul
(7.Oor better Long Haul Short Haul + severe t
component | MPG** (60-69mPGy* |(5.1-59MPG)»* — | (Upto SOMPG)**
~11 Vehicles used a majority of time on rough, dirty, rocky roads should have their belts replaced sooner than
recommended. Debris can get caught in the belt system and wear out belts sooner than vehicles used on
paved highway roads,
- tWhichever comes first. Note: Reaching the Davco change line supersedes these intervals.
-*Engine fuel filters should be changed at recommended service intervals, or when the "Fuel Filter Service
Lamp activates on the dashboard. For maximum life of fuel system components, itis not recommended to
exceed 100k mi on engine fuel filters under any condition,
-** Check per section “Poly-V-Belt inspection’
- ***Fyel Economy represents overall fuel economy (including idle time)
- +Currently, only Detroit™ Fuel Filter/Water Separator & Davco 385/482/485/487 are the only frame-mounted
filtration systems compatible for Detroit Engines.
= §Maintenance System can be enabled for this component.
Refer to "Routine Preventive Maintenance” and "How To Procedures" for a description of all items.
DD15: Maintenance Intervals EPAU7/EPA10/GHG14/GHG17 with ULSD Fuel
EPA10/GHG14/GHG17 Using DFS 93K222(CK-4) or 93K223(FA-4) Approved Oils,
EPAQ7 Using DFS 93K222(CK-4) Approved Oils
Efficient Long Haul
Long Haul Short Haul + Severe t
(7.0orbetter a
MPG) (6.0-6.9 MPG)*** (5.1-5.9 MPG) to 5.0 MPG)**
component * ¢ y ¢ yee (Up )
Replace every Replace every Replace every 45,000 | Replace every 35,000
il Filters 75,000 mi (121,000 | 60,000 mi (97,000 | mi (72,000 km) or | mi (56,000 km) or 750
km) km) 1000 hrs. hrs
Replace every, Replace every Replace every 45,000 | Replace every 35,000
Lubricating oil§ | 75,000 mi (121,000 | 60,000 mi (97,000 | mi (72,000 km) or | mi (56,000 km) or 750
km) km) 1000 hrs hrs
Replace every, Replace every Replace every 45,000 | Replace every 35,000
Engine Fuel Filter * | 75,000 mi (121,000 | 60,000 mi (97,000 mi (72,000 km) or | mi (56,000 km) or 750
km) km) 1000 hrs. hrsDD15: Maintenance Intervals EPA07/EPA10/GHG14/GHG17 with ULSD Fuel
EPA10/GHG14/GHG17 Using DFS 93K222(CK-4) or 93K223(FA-4) Approved Oils,
EPAQ7 Using DFS 93K222(Ck-4) Approved Oils
Component
Efficient Long Haul
(7.0or better
Mpc)
Long Haul
(60-69 MPG)
Short Haul +
(5.1-5.9MPG)"*
Severe t
(Up to 5.0 MPG)***
Engine Fuel Filter *
w/ Frame-Mounted
Replace every
100,000 mi
Replace every
100,000 mi
Replace every 90,000
mi (144,000 km) or
Replace every 70,000
mi (113,000 km) or
site, (161,000 km) (167,000 km) 1000 hrs 750 hrs
Frame Mounted Replace every Replace every | Replace every 45,000 | Replace every 35,000
Fuel Fiters ¢ 75,000 mi (121,000 | 60,000 mi (97,000 | mi (72,000 km) or | mi (56,000 km) or 750
km) km) 1000 hrs hrs
Valve Lash ‘Adjust every 500,000 mi (800,000 km) Adjust every 200,000
Adjustment mi (322,000 km)
(GHG17)
Valve Lash Adjust at 100,000 mi (160,000 km), at 500,000 mi (800,000 km), and then every 500,000
Adjustment mi (800,000 km) thereafter
(EPAQ7, EPA10,
GHG14)
Coolant - Standard
Life
Maintain every
75,000 mi (121,000
km)
Replace every
300,000 mi
(482,000 km)
Maintain every
60,000 mi (97,000
km) or 1 yr
Replace every
300,000 mi
(482,000 km)
Maintain every
445,000 mi (72,000
km) 895 hrs or 1 yr
Replace every
300,000 mi (482,000
km)
Maintain every 35,000
mi (56,000 km) 640,
hrs or 6 months
Replace every 300,000
‘mi (482,000 km)
Coolant - Extended
Life
Maintain every
150,000 mi
(242,000 km) or 1
yt
Replace every
600,000 mi
(965,000 km)
Maintain every
120,000 mi
(194,000 km) or 1
yr
Replace every
600,000 mi
(965,000 km)
Maintain every
90,000 mi (144,000
km) or 1 yr
Replace every
600,000 mi (965,000
km)
Maintain every 70,000
mi (112,000 km) or 1
yr
Replace every 600,000
‘mi (965,000 km)
Coolant System
Fitter (if equipped)
Current engine designs no longer use coolant filters. If you have a coolant filter, you may
choose to remove the filter at your next maintenance interval. For more details reference
bulletin 15TS-10Rev.DD15: Maintenance Intervals EPA07/EPA10/GHG14/GHG17 with ULSD Fuel
EPA10/GHG14/GHG17 Using DFS 93K222(CK-4) or 93K223(FA-4) Approved Oils,
EPAQ7 Using DFS 93K222(CK-4) Approved Oils
Efficient Long Haul
Long Haul Haul t Severe t
(oorbetter -ong Haul Short Haul ne
MPC .0-6.9 MPG) *** .1-5.9 MPC 3.0 MPG)***
Component aad (6.0-6.9 MPG) (51-5.9MPG)** —_| (Up to 5.0 MPG)
Inspect at oil Inspect at oil Inspect at oil Inspect at oil change**
change change* change™*
8 9 3 Replace every 100,000
Belts? Replace every Replace every Replace every mi (161,000) 2600 hrs
200,000 mi 200,000 mi 100,000 mi (161,000)
(322,000 km) (322,000 km) 2600 hrs.
Inspect at oil Inspect at oil h st at oil che In t at oil ch
niesystem ps pect at oil | Inspect at oil change | Inspect at oil change
change change
Inspect at oil Inspect at oil | Inspect atoll ch Inspect at oil chi
sir Cleaner inspect ato inspect at oll | Inspect atoll change | Inspect at oil change
change change
Exhaust System Inspect at oil Inspect at oil —_| Inspect at oil change | Inspect at oil change
change change
Inspect at oil Inspect at oil | Inspect at oll change | Inspect atoll change
Air Compressor ps p ps ‘a pe s
change change
Aftertreatment
Devices
Inspect external hardware and connections every 6 months or at oll change intervals. +
Diesel Particulate
Filter
EPA10 & GHG14
ACheck Engine Indicator or mileage/time intervals indicate when ash cleaning is
required. Use DETROIT Diesel Corporation's authorized DPF cleaning procedure. Failure
to follow this procedure could result in engine and/or aftertreatment damage, causing
degraded vehicle performance including excess fuel consumption and decreased engine
life
Normal DPF ash clean intervals are 300,000 mi (480,000 km) 9,000 hrs to 400,000 mi
(640,000 km) 10,250 brs.
Detroit highly recommends exchanging the DPF with a Detroit™ genuine DPF to ensure
maximum life,DD15: Maintenance Intervals EPA07/EPA10/GHG14/GHG17 with ULSD Fue!
EPA10/GHG14/GHG17 Using DFS 93k222(CK-4) or 93K223(FA-4) Approved Oils,
EPAQ7 Using DFS 93K222(Ck-4) Approved Oils
Component
Efficient Long Haul
(7.0orbetter Long Haul Short Haul + Severet
Mpc (o69mecy* |(61-59MPGy — | (Upto 50 MPG)
Diesel Particulate
Filter
GHG17
ACheck Engine Indicator or mileage/time intervals indicate when ash cleaning is,
required. Use DETROIT Diesel Corporation's authorized DPF cleaning procedure. Failure
to follow this procedure could result in engine and/or aftertreatment damage, causing
degraded vehicle performance including excess fuel consumption and decreased engine
lite
Normal DPF ash clean interval is 500,000 mi (800,000 km) 11,000 hrs to $50,000 mi
(880,000 km) 11,500 hrs.
Detroit highly recommends exchanging the DPF with a Detroit™ genuine DPF to ensure
maximum life
DEF Pump Filter
EPA10
Replace filter every 175,000 mi (280,000 km) or 3 yrs. +
DEF Pump Yellow
Replace filter every 175,000 mi (280,000 km) or 3 yrs. +
Filter GHG14
DEF Pump White Replace filter every 500,000 mi (805,00 km) or 3 yrs. t
Filter
GHG14 & GHG17
DEF Pump Air 2010 Engines only: Refill bladder with air every 24 months.
BladderDD15: Maintenance Intervals EPA07/EPA10/GHG14/GHG17 with ULSD Fue!
EPA10/GHG14/GHG17 Using DFS 93K222(CK-4) or 93K223(FA-4) Approved Oils
EPAQ7 Using DFS 93K222(Ck-4) Approved Oils
Efficient Long Haul
(7.or better Long Haul Short Haul + Severet
component | MPG* (60-69MPG)** |(51-59MPG)* — | (Up 1050 MPG)
= 1 Vehicles used a majority of time on rough, dirty, rocky roads should have their belts replaced sooner than
recommended. Debris can get caught in the belt system and wear out belts sooner than vehicles used on
paved highway roads.
- tWhichever comes first. Note: Reaching the Davco change line supersedes these intervals.
-*Engine fuel filters should be changed at recommended service intervals, or when the "Fuel Filter Service
Lamp" activates on the dashboard. For maximum life of fuel system components, it is not recommended to
exceed 100k mi on engine fuel filters under any condition
* Check per section "Poly-V-Belt inspection’
- **#Fuel Economy represents overall fuel economy (including idle time)
- #Currently, only Detroit™ Fuel Filter/Water Separator & Davco 385/482/485/487 are the only frame-mounted
filtration systems compatible for Detroit™ Engines.
~ §Maintenance System can be enabled for this component,
Refer to ‘Routine Preventive Maintenance” and "How To Procedures" for a description of all items.
DD16: Maintenance Intervals EPAU7/EPA10/GHG14/GHG17 with ULSD Fuel
EPA10/GHG14/GHG17 Using DFS 93K222(CK-4) or 93K223(FA-4) Approved Oils,
EPAQ7 Using DFS 93K222(CK-4) Approved Oils
Efficient Long
Haul
oorbetter Hong Haul Short Haul + Severe t
component [PSY (6.0-6.9MPG)* — | (5.1-5 9 MPG) (Upto 50 My
Not Applicable | Replace every | Replace every 40,000 | Replace every 35,000 mi
Oil Fiterg 55,000 mi (89,000 | mi (64,000 km) or | (56,000 km) or 750 hrs
km) 1000 hrs
Not Applicable | Replace every | Replace every 40,000 | Replace every 35,000 mi
Lubricating Oilg 55,000 mi (89,000 | mi (64,000 km) or | (56,000 km) or 750 hrs.
km) 1000 hrsDD16: Maintenance Intervals EPA07/EPA10/GHG14/GHG17 with ULSD Fuel
EPA10/GHG14/GHG17 Using DFS 93k222(CK-4) or 93K223(FA-4) Approved Oils,
EPAQ7 Using DFS 93K222(Ck-4) Approved Oils
Efficient Long
Haul
oorbetter [Here Hau! Short Haul t Severe t
Component |MPS** (6.0-6.9MPG)#* | (5.1-59MPG)#* | (Up to SOMPG)+#*
Not Applicable | Replace every _| Replace every 40,000 | Replace every 35,000 mi
Engine Fuel Filter *
55,000 mi (89,000
km)
mi (64,000 km) or
1000 hrs
(56,000 km) or 750 hrs
Engine Fuel Filter*
w/ Frame-Mounted
Filter
Not Applicable
Replace every
100,000 mi (167,000
km)
Replace every 80,000
mi (128,000 km) or
1000 hrs
Replace every 70,000 mi
(113,000 km) of 750 hrs
Frame Mounted
Not Applicable
Replace every
55,000 mi (89,000
Replace every 40,000
Replace every 35,000 mi
Fuel Filters ¢ mi (64,000 km) or | (56,000 km) or 750 hrs
km) 1000 hrs
Valve Lash ‘Adjust every 500,000 mi (800,000 km) Adjust every 200,000 mi
Adjustment (822,000 km)
(GHG17)
Valve Lash ‘Adjust at 100,000 mi (160,000 km), at 500,000 mi (800,000
Adjustment kmn), and then every 500,000 mi (800,000 km) thereafter
(EPAQ7, EPA10,
GHG14)
Coolant - Standard
Life
Not Applicable
Replace every
55,000 mi (89,000
km) oF 1 yr
Replace every
300,000 mi (482,000
km)
Replace every 40,000
mi (64,000 km) 895
hrs oT yr
Replace every 300,000
mi (482,000 km)
Replace every 35,000 mi
(56,000 km), 640 hrs or
6 months
Replace every 300,000
mi (482,000 km)
Coolant - Extended
Life
Not Applicable
Replace every
110,000 mi (178,000
km) or 1 yr
Replace every
600,000 mi (965,000
km)
Replace every 80,000
mi (128,000 km) or 1
yr
Replace every 600,000
mi (965,000 km)
Replace every 70,000 mi
(112,000 krn) or 1 yr
Replace every 600,000
mi (965,000 km)
Coolant System
Filter (if equipped)
Current engine designs no longer use coolant filters. If you have a coolant filter, you may
choose to remove the filter at your next maintenance interval. For more details reference
bulletin 15TS-10Rev,DD16: Maintenance Intervals EPA07/EPA10/GHG14/GHG17 with ULSD Fuel
EPA10/GHG14/GHG17 Using DFS 93K222(CK-4) or 93K223(FA-4) Approved Oils,
EPAQ7 Using DFS 93K222(Ck-4) Approved Oils
Efficient Long
Haul
Long Haul ‘Short Haul t ‘Severe t
oorbetter |‘?
MPG) (6.0-6.9 MPG) (5.1-5.9 MPG) *#* to 5.0 MPG)**
component ) ( yee | ) up )
Not Applicable | inspect at oil Inspect at oil Inspect at oil change**
change** changet*
Replace every 100,000
Belts * Replace every Replace every 100,000 | mi (167,000 km) 2600
200,000 mi (322,000 | mi (167,000 km) 2600 | hrs
km) hrs
Air System Not Applicable | inspect at oil change | Inspect at oil change | Inspect at oil change
Air Gleaner Not Applicable | inspect at oil change | inspect atoilchange | Inspect atl change
Exhaust System
Not Applicable | inspect at oil change | Inspect at oil change | Inspect at oil change
Air Compressor
Not Applicable | Inspect at oil change | Inspect at oil change | Inspect at oil change
Aftertreatment
Devices
Inspect external hardware and connections every 6 months or at oil change intervals. t
Diesel Particulate
Filter
EPA10 & GHG14
‘A.Check Engine Indicator or mileage/time intervals indicate when ash cleaning is
required. Use DETROIT Diesel Corporation's authorized DPF cleaning procedure. Failure
to follow this procedure could result in engine and/or aftertreatment damage, causing
degraded vehicle performance including excess fuel consumption and decreased engine
lite,
Normal DPF ash clean intervals are 300,000 mi (480,000 km) 9,000 hrs to 400,000 mi
(640,000 km) 10,280 hrs.
Detroit highly recommends exchanging the DPF with a Detroit” genuine DPF to ensure
maximum life
Diesel Particulate
Filter
GHG17
‘ACheck Engine Indicator or mileage/time intervals indicate when ash cleaning is
required. Use DETROIT Diesel Corporation's authorized DPF cleaning procedure. Failure
to follow this procedure could result in engine and/or aftertreatment damage, causing
degraded vehicle performance including excess fuel consumption and decreased engine
lite,
Normal DPF ash clean interval is 500,000 mi (800,000 km) 11,000 hrs to 50,000 mi
(880,000 km) 11,500 hrs.
Detroit highly recommends exchanging the DPF with a Detroit” genuine DPF to ensure
maximum lifeDD16: Maintenance Intervals EPA07/EPA10/GHG14/GHG17 with ULSD Fuel
EPA10/GHG14/GHG17 Using DFS 93K222(CK-4) or 93K223(FA-4) Approved Oils,
EPAQ7 Using DFS 93K222(Ck-4) Approved Oils
Efficient Long
Haul
Long Haul ‘Short Haul t Severe t
oorbetter 49
MPG) (6.0-6.9 MPG) (5.1-5.9 MPG) *#* to 5.0 MPG)*#
component ) ( yee | ) up )
DEF Pump Filter Replace filter every 175,000 mi (280,000 km) or 3 yrs. t
ePA10
DEF Pump Yellow Replace filter every 175,000 mi (280,000 km) or 3 yrs. +
Filter GHG14
DEF Pump White Replace filter every 500,000 mi (805,00 km) o 3 yrs. t
Filter
cHo148 cHo17
DEF Pump Air 2010 Engines only: Refill bladder with air every 24 months.
Bladder
- 1 Vehicles used a majority of time on rough, dirty, rocky roads should have their belts replaced sooner than
recommended. Debris can get caught in the belt system and wear out belts sooner than vehicles used on.
paved highway roads.
- tWhichever comes first. Note: Reaching the Davco change line supersedes these intervals.
-*Engine fuel filters should be changed at recommended service intervals, or when the "Fuel Filter Service
Lamp" activates on the dashboard. For maximum life of fuel system components, itis not recommended to
exceed 100k mi on engine fuel filters under any condition,
~* Check per section "Poly-V-Belt Inspection’
- **#Fuel Economy represents overall fuel economy (including idle time)
- $Currently, only Detroit™ Fuel Filter/Water Separator & Davco 385/482/485/487 are the only frame-mounted
filtration systems compatible for Detroit™ Engines
= §Maintenance System can be enabled for this component.
Refer to ‘Routine Preventive Maintenance” and "How To Procedures" for a description of all items.
Nae
Parent opie: Prevetve Mantensnice nervale
Numero del Dacunente0000022270
Fecha depublescn.2022-0608
Comentar osjrwn comentano