Professional Documents
Culture Documents
HSI
www.renishaw.com/hsi
Specification
Principal application The HSI processes signals from RENGAGETM probes or standard hard-wired probes and
converts them into machine outputs, which are then transmitted to the CNC controller.
Transmission type Hard-wired
Probes per system One
Compatible probes MP250, LP2, TS27R, TS34 and RP3
Supply voltage 12 Vdc to 30 Vdc
Supply current 40 mA @ 12 V, 23 mA @ 24 V
Output signal Probe status
Voltage-free solid-state relay (SSR) output, configurable normally open or normally
closed.
Input/output protection Supply protected by resettable fuse.
Outputs protected by overcurrent protection circuit.
Diagnostic LEDs Error, status and probe type.
Connection provided for remote device (LED or buzzer).
Probe vibration filter On MP250 a trigger delay circuit (8 ms) helps to reduce false triggers caused by machine
vibration
Mounting DIN rail mounting. Alternative mounting using screws.
Operating temperature +5 °C to +55 °C (+41 °F to +131 °F)
For further information, and the best possible application and performance support, please contact Renishaw or visit
www.renishaw.com/hsi
Renishaw plc T +44 (0)1453 524524
New Mills, Wotton-under-Edge F +44 (0)1453 524901
Gloucestershire, GL12 8JR E uk@renishaw.com
United Kingdom www.renishaw.com
HSI dimensions
134 (5.28)
34.7 (1.37)
98 (3.86)
HSI interface
Cable
CNC
machine
controller
MP250
Stylus LP2
TS27R
TS34
or NOTE: Only one probe can be
RP3 connected at a time. The connection
between the probe socket and the
Workpiece HSI interface must be screened and
connected to ground at the interface.
RENISHAW HAS MADE CONSIDERABLE EFFORTS TO ENSURE THE CONTENT OF THIS DOCUMENT IS CORRECT
*H-5500-8250-02*
AT THE DATE OF PUBLICATION BUT MAKES NO WARRANTIES OR REPRESENTATIONS REGARDING THE CONTENT.
RENISHAW EXCLUDES LIABILITY, HOWSOEVER ARISING, FOR ANY INACCURACIES IN THIS DOCUMENT.