Professional Documents
Culture Documents
Flsun QQ-S Pro Delta 3D Printer 255X360mm Printing Size
Flsun QQ-S Pro Delta 3D Printer 255X360mm Printing Size
AAuuttoom
maattiicc BBeedd LLeevveelliinngg W
Wiitthh SSeennssoorr
New auto leveling method using auto level sensor. Say Good bye to the old USB plate bed leveling method.
LLaattttiiccee BBeedd
TTiittaann EExxttrruuddeerr
3322--BBiitt M
Mootthheerrbbooaarrdd
1. QQ-S PRO is equipped with a 32-Bit motherboard and a separate MOS module, allowing for stable prints even at high printing speed.
2. Equipped with a touchscreen, it can resume printing from the breakpoint, save in case of a power outage.
All in all, it’s pretty much all you can ask for from an operating system.
FFuullll M
Meettaall FFrraam
mee
The printer is fully made out of stainless steel (SAE 304), allowing for less wobble, and therefore more accurate prints.
QQuuiieett PPrriinnttiinngg
The QQ-S PRO has an operating-noise of less than -50 dB, making it suitable for workplaces.
No, because there is no reserved installation interface for the second extruder on the motherboard.
NTC 100K.
24V 40W
Repetier-Host.
6.What is the length of each belt of QQ-S Pro and what is its model?
The length of each belt of QQ-S Pro is 1486mm, and the model is 2GT 6mm.
4 A4988.
Yes, QQ-S Pro can be upgraded to TMC 2208, TMC 2209, etc., but the firmware needs to be updated.
9.What is the length of the parallel arm of QQ-S Pro?
280mm,the distance between the center of the two fish eyeball heads.
10.What are the models of the three fans on the QQ-S pro hot end?
11.What is the model and size of the QQ-S Pro heating block?
400X360X950mm.
PLA/ABS(Enclose)/PETG/WOOD.
14.What is the maximum temperature of QQ-S Pro nozzle and hot bed?
The temperature of the nozzle does not exceed 250°C, and the temperature of the hot bed does not exceed 90°C.
780mm.
16.Can the extruder of QQ-S Pro be replaced with another type of extruder, such as BMG extruder, which parameters in the firmware need to be modified?
The extruder of QQ-S Pro can be replaced with another type of extruder. You need to modify the pulse value of the extruder in the line ">EXT0_STEPS_PER_MM 367" to the pulse
of the new extruder in the firmware configuration file.
PC4-01.
18.Can QQ-S Pro upload the latest Marlin? Does FLSUN have Marlin for QQ-S Pro?
QQ-S Pro can upload Marlin, but flsun don’t have official Marlin firmware.