Professional Documents
Culture Documents
Note: Use full scale for all your construction works and dimensions should be in millimeters.
A well established border line and title block make up 20% mark in this section.
All construction lines must be shown clearly. Accuracy and good draughtsmanship are essential.
QUESTION 1
Construct the isometric drawing below
QUESTION 2
Draw a parabola when the distance between its focus and directrix is 40mm. Also, draw a tangent
and normal at a point 60mm from the directrix.
QUESTION 3
In the mechanism shown in the figure 26, OA revolves anti-clockwise about 0 while AB slides
through the pivoted block C. Draw the locus of B for one revolution of OA. OA is 40mm and AB is
145mm.
QUESTION 4
The crank OA revolves anti-clockwise about 0, and B moves to and fro along the horizontal line
through O. Plot the locus of P if OA is 30 mm, AB is 95 mm and AP is 20 mm.
QUESTION 5
Construct the development of the below truncated Cylinder.