Professional Documents
Culture Documents
Application example: VCSEL energy distribution directly depends on parameters such as current, pulse width and repetition rate and temperature of the
device. Therefore, it is essential to measure the angle distribution of VCSELs at various stages of the manufacturing process as well as in R&D and field
service. VCSEL behavior on the LIV sweep test: VCSELs are in a so called “LED mode” when there is only a low current applied. Once the current applied
to the VCSEL rises, its beam profile changes to “Laser mode”:
0.74 A
5000 0.78 A
0.8 A
4000
0.85 A
Intensity (Normalized)
0.88 A
3000
0.92 A
2000
1000
0
1800 2300 2800 3300 3800 4300
Beam Profile (µm)
268 I 01.01.2023 For latest updates, please visit our website: www.ophiropt.com
WB-I VIS:
WB-I SWIR:
Specifications
Model Wide Beam Imager VIS Wide Beam Imager SWIR
Wavelengths 350 (1)-1100nm 900-1700nm
Active area (2) Ø45mm Ø45mm
Beam sizes (2), (3) 10mm– 45mm 10mm– 45mm
Angle of incidence <70° <70°
Minimum detail (4), (5) 0.5mm 0.5mm
Lowest measurable signal 100µW/cm2 (6) 3µW/cm2 (With Iris fully opened at 1550nm)
Maximum power exposure CW (7) 200W unlimited, 1000W for 1 minute 50W unlimited time
Maximum energy exposure WB-I
(8)
WITH IRISForCONTROLL
ns pulses 1.5J/cm2 N/A
Imager recess supported 4.5mm 17.5 mm (C-Mount)
Camera model recommended SP932U SP1203
Dimensions L=265mm X Ø57mm (Ø73mm Iris control) L=265mm X Ø57mm (Ø73mm Iris control)
Weight (with support) 0.6 kg (0.8 kg) WB-I SWIR 0.6 kg (0.8 kg)
Part number SP90612 SP90605
Notes: (1) Camera response down to 350nm. Below this, fluorescence of screen will be imaged
(2) Limited to 43 mm in Y direction by camera sensor
(3) 5mm possible with reduced accuracy
(4) For low contrast artefacts, due to blur effect (~0.8mm)
(5) Small diameter evaluation error is < 5%, decreases proportionally with increased diameter
(6) With two ND1 filters mounted on camera
(7) For WB-I VIS: 20% is backward scattered, WB-I SWIR: 50% is backward scattered
Beam Analysis
(8) At 1.064μm. For wavelengths below 0.9μm, derate to 40% of above , for <0.4μm to 20%
250
ROLL
NTROLL Wide Beam Imager VIS Wide Beam Imager SWIR A CONFIGURATION
IRIS CONTROL RING
A CONFIGURATION 920S L
CONFIGURATION 287
2X M6 X1 920S 287 mm
920S
928 287
278
1``-32 UNF
30.2
928 278 mm
928 278
WB-I
WB-I SWIR
22.3
4X10
WB-I SWIR SWIR
44.0
56.1
73
87
78
2.1 MAX
2X 1/4-20
50 3.0
8 2X SET SCREW WITH
78
SECTION A-A A258 PLUNGER
FOR CAMERA MOUNT WITH A
35
2 ND FILTERS
250 50
250 250
A 2X M6 x1
A A 2X M6 x1 2X M6 x1
A A
UNF
IRIS CONTROL
IRIS CONTROL
RING RING
6 X1
1``-32 UNF
UNF
30.2 30.2
22.3
1``-32
22.3
22.3
1``-32
56
73
87 87
44.0
44.0
56.1
56.1
87
73
73
78
78
2.1 MAX
2.1 MAX 3.0
2.1 MAX
3.0 3.0 IRIS CONTROL RING
50 50
8 8 78 35
2X SET2X
SCREW
SET SCREW
78WITH WITH 2X 1/4-20
A258 A258 PLUNGER
PLUNGER
78
A 35 35
SECTION
2X 1/4-20 2X 1/4-20
FOR CAMERA
FOR CAMERA
2 ND FILTERS
MOUNT
2 ND FILTERS
MOUNT
WITH WITH A 50 A SECTION SECTION
A-A
A-A
A-A
50 50
56 56
73 73
56
73
For latest updates, please visit our website: www.ophiropt.com 01.01.2023 I 269