Professional Documents
Culture Documents
PART 1 GENERAL
1.03 REFERENCES
1.04 SUBMITTALS
B. Shop Drawings: Indicate wiring diagrams of system, showing interface with branch
circuit wiring.
C. Product Data: Provide data showing dimensions and ratings for components.
D. Manufacturer's Instructions: Indicate application conditions and limitations of use
stipulated by Product testing agency specified under Regulatory Requirements.
Include instructions for storage, handling, protection, examination, preparation, and
installation of Product.
1.05 PROJECT RECORD DOCUMENTS
1.07 QUALIFICATIONS
B. Furnish products listed and classified by Underwriters Laboratories, Inc. testing firm
acceptable to authority having jurisdiction as suitable for purpose specified and shown.
2.01 MANUFACTURERS
2.02 COMPONENTS
C. Key Switches: Match non-key switch ratings; provide spade key, or cylinder lock type
(as suitable).
D. Switches with Pilot Lamp: Momentary contact / three position rocker type, ivory color,
rated as suitable with integral red pilot light.
F. Master Selector Switch: pushbutton type position rotary dial type, with key lock out (as
suitable).
H. Cabinets and Enclosures: Shop fabricate and wire. Include appropriate barrier strips
for mounting relays and separating energy-limited wiring from line voltage wiring.
Include knockouts for relay mounting. Include space for 20 percent minimum
additional relays and one additional power supply in each cabinet and enclosure.
PART 3 EXECUTION
3.01 INSTALLATION
C. Install relays to be accessible. Allow space for adequate ventilation and circulation of
air.
3.02 DEMONSTRATION
2. PLP-GH/Lighting Circuits.
END OF SECTION