Professional Documents
Culture Documents
In this document, I’ll describe how to construct a pilot seat on a very easy way.
For the base of the seat we use the wood of 18mm thickness.
Cut out these parts to create the base of the seat:
Make a few holes on the side.
Now add some glue.
If this is done, you can screw all parts together to form the base of your seat.
Now we can start with the second part of the seat.
This is what we need:
We can proceed as we did for the base of the seat and this is the result.
If all parts were fit together well, then the top part can slide over the base of the seat.
Now we can make two holes in the top part of our seat.
I made two 8mm holes on each side because I use 8mm bolts to construct the seat.
On the base, we also make two holes on each side.
The height where we make these holes depends a little bit on the height of the pilot ;-)
In my case, I used these measurements:
If we now attach both parts with the bolts, we get this result:
At the back, we attach two pieces of wood that connect the back of the seat to our base.
Now we can attach the second part.
Now that everything is put together, this is the final result.