Professional Documents
Culture Documents
SOP Vacuum Oven
SOP Vacuum Oven
Location of SOP and Machine Operating & Safety Manual: Composites Lab website
under resources; Composites Lab TRACS site; and Hardcopy near machine.
Emergency Contact:
Call 911
Call EHS & Risk Management at 512-245-3616
Call Head Lab Technician, Dr. Ray Cook (office 512-245-2050)
Call Dr. Jitendra S Tate (office 512-245-4872)
Safety Precautions:
Important Safeguards:
1. To avoid explosion, glassware that has been rinsed with an organic solvent
should be rinsed with distilled water before use in oven.
2. Be cautious of chemicals that might pose a hazard because of acute or
chronic toxicity. The following safety equipment must be accessible and
ready for use: (e.g. chemical fume hood, biological safety cabinet, laminar
flow hood, chemical spill kits) Exhaust system or/and respirators for toxic
material.
3. In the event that a hazardous material spills during a procedure, be prepared
to execute the following emergency procedure: Clean with cleaner
according to MSDS of materials used.
4. This procedure will result in the follow regulated waste which must be
disposed of in compliance with environmental regulations
Page 1
VWR Vacuum Oven Standard Operating Procedure [Updated Dec 19, 2014]
VACUUM OVEN
General information
VWR 1430S vacuum oven is ideal for general drying, curing and desiccating, annealing,
outgassing, and aging tests. It is configured to work with reduced pressures and/or N2
atmosphere. The oven is equipped with separate vacuum and gas ports, each with its own
manual valve. The temperature is manually controlled and varies from ~ 20ºC to 250ºC.
The maximum achievable vacuum is ~ -27 in. Hg. The N2 flow can be regulated from 0
to 10 liters / min.
Specifications:
Weight-115 lbs.
Dimensions- Exterior : 23.8*26.3*20.3(W*D*H) Interior : 12*20*12(W*D*H)
Capacity-1.7 cubic feet
Temperature- Range: Amb. +5○ to 200○C
Uniformity: 3.0@ 100○
Sensitivity: 1.0○ C
Page 2
VWR Vacuum Oven Standard Operating Procedure [Updated Dec 19, 2014]
Accessories:
Vacuum filters:
Vacuum hose:
Page 3
VWR Vacuum Oven Standard Operating Procedure [Updated Dec 19, 2014]
1.Turning on
Flip power switch to ON position
Press red activation switch.
If executed properly green Heat
Activated” light will turn on.
Once heated to desired temperature
“Heat Activated” light will turn off
and red light turn on.
Setting Temperature
Temperature chart corresponding to
desired temperature is located
above the vacuum oven.
Set the number corresponding to
desired temperature using "Set
Temperature” knob
Formula is as follows:
a. y= number value to set
b. x= desired temperature
“Safety Control” should be set to
maximum working temperature for
current material being used.
Will automatically turn off the
vacuum oven, when desired
temperature is met or exceeded.
Pressure Control
Ensure gasket is in place between
door and oven.
Close “Vent” valve
Open “Vacuum” Valve
Turn vacuum pump to “on” position.
Pump down to desired pressure
using “Vacuum Gauge”
Close “Vacuum” valve and turn
vacuum pump to “off” position.
Turning Off
Once the pressure was utilized,
open “Vent” valve to release internal
pressure.
Turn “Power Switch” to “off” position.
Page 4
VWR Vacuum Oven Standard Operating Procedure [Updated Dec 19, 2014]
Cleaning
Page 5