Professional Documents
Culture Documents
5 Port DSC Remote Manual
5 Port DSC Remote Manual
Display:
Remote:
Step 2: Click on the Select button. User will have the display as shown below.
Step 3: Click on Model user have display as shown. Click on UP & Down buttons
to select the model, either ‘Validate’ or ‘Test’. Display for both the models will be
as shown below:
Step 4: Now click on OK Button to go for the model selection. Display will be as
shown below:
Step 5: Now click on the Process Start Button to start the selected model
process. After the process started the running display will be as shown below.
Step 6: When the process is completed user will have the display as shown
below.
In this display the Model Validate is showing that Validate Model was processed
and Total 2 is showing that 2 Validate model has been processed.
LED INDICATION
RGB LEDs used for indication of results. Red LED indicates if that port is fail.
Green LED indicates if port is pass. Yellow LED indicates when port is in testing
condition.
LED RESULT
PASS
FAIL
TESTING