Professional Documents
Culture Documents
bearings
Inner ring
d tΔdmp1) tVdsp1) tVdmp tΔBs tVBs tKia
Diameter series All Normal Modified3)
> ≤ U L 7, 8, 92) 0, 1 2, 3, 4 U L L
mm μm μm μm μm μm μm
– 2.5 0 –8 10 8 6 6 0 –40 – 12 10
2.5 10 0 –8 10 8 6 6 0 –120 –250 15 10
10 18 0 –8 10 8 6 6 0 –120 –250 20 10
Outer ring
D tΔDmp tVDsp4) tVDmp4) tΔCs tKea
Open bearings Capped tVCs
1)Tolerances
Diameter series bearings5)
for tapered bores (taper 1:12 → table and taper 1:30 → table).
2)>
Diameter ≤ U 8 not covered
series 7 and L by7,ISO 92) 0, 1
8, 492. 2, 3, 4 2, 3, 4
3)Applies to inner rings and outer rings of bearings of matched bearing sets consisting of two or more bearings. Does not apply
mm μm μm μm μm μm
to universally matchable angular contact ball bearings.
4)Applies to bearings prior to mounting and after removal of internal or external snap ring.
5)Capped bearings are sealed or shielded bearings.
2.5 18 0 –8 10 8 6 10 6 Identical15
18 30 0 –9 12 9 7 12 7 to tΔBs 15
and
30 50 0 –11 14 11 8 16 8 20
tVBs of
an
50 80 0 –13 16 13 10 20 10 inner 25
ring of
80 120 0 –15 19 19 11 26 11 35
the
120 150 0 –18 23 23 14 30 14 same 40
bearing
150 180 0 –25 31 31 19 38 19 as the 45
outer
180 250 0 –30 38 38 23 – 23 50
ring
250 315 0 –35 44 44 26 – 26 60