Professional Documents
Culture Documents
com
knowledge
――――
Expiration date of flare
Please purchase at a Toyota dealer before the expiration date displayed on the main unit expires.
When the expiration date expires, it may not ignite or the flame may become smaller.
warning
――――
Places where flares should not be used
――――
In the tunnel
――――
Near combustibles such as gasoline
――――
Handling of flares
Please be sure to observe the following.
If you do not observe it, you may be seriously injured and it is dangerous.
――――
Do not point or bring the flare toward or close to your face or body during use.
――――
Do not let your child touch the flare
Ten thousand
one
of
Field
Go
NS
teeth
296 7-1. First of all
Only in an emergency when the vehicle does not stop, stop the vehicle according to the
following procedure.
Keep pressing the brake pedal with both feet and decelerate as much as possible
KBPA710401
warning
――――
When the engine is unavoidably stopped while driving
――――
It is dangerous because it becomes difficult to control the car because the braking effect becomes
worse and the steering wheel operation becomes heavier. Make sure to decelerate sufficiently before
stopping the engine.
――――
Vehicles without the key-free system: Never remove the key as the steering wheel will ,
be locked when the key is removed.
Ten thousand
one
of
Field
Go
NS
teeth
298 7-2. Emergency measures
About towing
In the following cases, the drive system may be defective, so contact your Toyota
dealer or a specialist.
The engine starts but the car doesn't move
――――
There
―――― is an unusual sound
KBPA720101 KBPA720102
Release the parking brake Lift the rear wheels using a dolly
7-2. Emergency measures 299
KBPA720103
Tied up in place
After transportation, it is attached to the rear side.
KBPA720104
Ten thousand
one
of
Field
Go
NS
teeth
KBPA720105
300 7-2. Emergency measures
Please protect.
KBPA720106
KBPA720108
KBPA720109
7-2. Emergency measures 301
MODA
Use a flat-blade screwdriver
Remove the data
Please protect.
KBPA720110
KBPA720111
one
of
Field
Go
NS
teeth
302 7-2. Emergency measures
Hook the rope on the tow hook so that the car body is not scratched
Be careful not to scratch the car body. Also, please tow in the forward direction.
Vehicles without key-free system: The driver rides in a towed vehicle and
applies an engine.
If the engine does not start, set the engine switch to "ON".
Vehicles equipped with a key-free system: The driver rides in a towed vehicle and applies
an engine.
If the engine does not start, set the engine switch to the ignition ON mode.
Set the shift position of the towed vehicle to N, and then release the
parking break.
During towing, adjust to the speed of the vehicle in front even when decelerating so that the rope does not
sag.
knowledge
――――
Purpose of use of tow hook
――――
When you have another car tow
If the engine is stopped, the brakes will not work well and the steering wheel will
be heavier than usual.
――――
About wheel nut wrench
It is installed in the luggage room. (→ P. 318, 329)
――――
About the rear hook
This hook is unavoidable for cars that are lighter than your own
KBPA720118
――――
About transport hooks
When this hook transports a vehicle by ship lashing
It is for fixing. Pull to another car
Have them pull out or tow another car
Can't be 7
Ten thousand
one
KBPA720119
of
Field
Go
NS
teeth
304 7-2. Emergency measures
warning
――――
When towing with a tow truck
FF car
KBPA720115
4WD car
KBPA720116
7-2. Emergency measures 305
warning
――――
About driving when you have another car tow
――――
Avoid sudden starts that put an excessive load on the tow hook or rope. The tow
hook or rope may be damaged, and the debris may hit people around you and
cause serious damage.
――――
Set the engine switch to “LOCK” (Vehicles without key-free system) or engine
Do not turn off the switch (vehicles equipped with a key-free system). The
handle may be locked and you may not be able to operate the handle.
――――
When attaching the tow hook to the vehicle
caution
――――
When towing with a tow truck
KBPA720117 7
――――
When tying a car to a vehicle carrier
Ten thousand
one
Do not overtighten the cables, etc. There is a risk of damage to the vehicle. of
Field
Go
NS
teeth
306 7-2. Emergency measures
caution
――――
To prevent damage to drive train components
――――
Be sure to observe the following when you have another vehicle tow you.
Lift the front wheels with a tow truck (FF vehicle), or tow with all four wheels
lifted. If you do not tow with a tow truck, the brakes may overheat and become
less effective.
――――
About the rear hook
Do not use unless it is unavoidable. It may lead to deformation of the device or
damage to the vehicle.
――――
About transport hooks
Do not have another vehicle pull it out or tow it with a transport hook. It may
lead to deformation of the device or damage to the vehicle.
7-2. Emergency measures 307
When the engine is stopped and the SRS airbag is activated, the fuel
pump shut-off system is activated to stop the fuel supply and minimize
fuel leakage.
caution
――――
Before starting the engine
If you find a fuel leak on the ground, the fuel system is damaged and needs to
be repaired. In that case, do not restart the engine.
Ten thousand
one
of
Field
Go
NS
teeth
308 7-2. Emergency measures
If the warning light stays on or blinking, calm down and take the following
actions. Even if it lights up or blinks, it is not a malfunction if it goes out
afterwards. However, if the same phenomenon occurs again, please have a point
inspection at a Toyota dealer.
(As the water temperature rises, it changes from blinking to lighting. → P. 346)
(Blinking red
→ Immediately stop at a safe place and contact your Toyota
Or lit)
dealer.
Engine warning light
ABS abnormality
→ Please have an inspection at a Toyota dealer immediately.
→ The steering wheel operation will be heavy, so operate the steering wheel for a while.
(yellow)
Please refrain. After about 10 minutes, it will return to normal
weight.
Master warning★
"Smart Assist failure" is displayed on the multi-information
display★
※Four Abnormality of Smart Assist II
→ Please have an inspection at a Toyota dealer immediately.
★
: Depending on the grade, options, etc., it may or may not be equipped.
310 310 7-2. Emergency measures
The remaining amount of fuel is 5.4L or less for 2WD vehicles and 6.6L or less
for 4WD.
→ Refuel
Driver / passenger seat belt warning light for forgetting to fasten* 7 (Warning buzzer* 8)
Forgetting to fasten the driver / passenger seat belt
(Blinking) → Wear a seat belt
Warning light for forgetting to fasten the rear seat belt* 9(Warning buzzer
※Ten)Forgot to fasten the rear seat belt
→ Wear a seat belt.
★
: Depending on the grade, options, etc., it may or may not be equipped.
7-2. Emergency measures 311
* 7 Passenger seat belt occupant detection sensor for forgetting to fasten the warning light:
Even if there are no passengers in the passenger seat, if you put luggage on the seat, the sensor
may detect the weight and the warning light may blink.
If you lay a cushion on the passenger seat, the sensor may not detect the occupant and the warning
light may not operate.
the rear seat belt is not attached, or when the rear seat belt is removed. one
of
increase. Field
Go
It goes off after wearing the rear seat belt or about 30 seconds after driving. It also lights up NS
teeth
when the rear door is opened and closed with the rear seat belt removed after driving.
seconds. Once the warning buzzer sounds, it will continue to sound for about 30 seconds even if you drive at a speed of about 5
km / h or less.
The buzzer will stop when you wear the rear seat belt or open and close the rear
door.
* 11 Warning buzzer when driving without parking brake released:
The warning buzzer sounds when the vehicle speed exceeds 5 km / h with the parking brake
applied.
312 7-2. Emergency measures
Warning buzzer
Warning light Warning content / remedy
(Inside the car)
* 1 If the engine does not start even if the electronic card key is in the car, the battery is dead.
It may be. (→ P. 268)
* 2 If the battery is almost dead, the engine switch will be in accessory mode.
It also blinks when the ON mode is set.
7-2. Emergency measures 313
Warning buzzer
Warning light Warning content / remedy
(Inside the car)
warning
――――
When the power steering warning light (yellow) lights up
Ten thousand
one
of
Field
Go
NS
teeth
314 7-2. Emergency measures
When the function of Smart Assist II deteriorates, "Stop smart assistance" and functional deterioration
The window of the laser radar (front side of the vehicle) is dirty
→ Clean the sensor window and recover when the cause is resolved.
The temperature inside the laser radar (front side of the vehicle) became high.
★
: Depending on the grade, options, etc., it may or may not be equipped.
7-2. Emergency measures 315
Snow ice and mud are attached to the sonar part (rear side of the vehicle)
→ Clean the sonar part and recover when the cause is resolved.
The monocular camera cannot recognize the front due to dirt on the front window
glass, etc.
→ Clean the front window glass to eliminate the cause.
Then return
Ten thousand
one
of
Field
Go
NS
teeth
316 7-2. Emergency measures
Vehicles equipped with the tire puncture emergency repair kit do not have spare
tires.
If a tire has a flat tire, you can use the tire puncture emergency repair kit for
emergency repair. You can make an emergency repair for a mild flat tire that has
been pierced by a nail or screw. (One tire can be repaired for each puncture repair
agent bottle.) Depending on the damage of the punctured tire, the emergency repair
kit may not be able to repair the tire. (→ P. 317)
For repair or replacement of tires that have been repaired with the tire puncture
emergency repair kit, contact your Toyota dealer. Emergency repair with a tire
puncture emergency repair kit is a temporary measure. Repair or replace the tires as
soon as possible.
warning
――――
When a tire punctures
Do not drive with a flat tire.
Even at short distances, the tires and wheels can be irreparably damaged and can lead to
unexpected accidents, which is dangerous.
7-2. Emergency measures 317
―――― Move to a safe place where the ground is hard and flat
・ If you know the puncture point, move the vehicle so that the puncture
point is on top to prevent the puncture repair agent from leaking.
knowledge
――――
A flat tire that cannot be repaired with an emergency repair kit
In the following cases, the emergency repair kit cannot be used for emergency repair. Please contact your Toyota
dealer. 7
――――
When driving with insufficient tire pressure and the tires are damaged
――――
When there is a hole or damage other than the ground contact surface such as the side of the tire Ten thousand
one
of
――――
When the tire is clearly off the wheel Field
Go
――――
When the tire has a cut or puncture of 4 mm or more NS
teeth
――――
When the wheel is damaged
――――
When two or more tires are flat
――――
When one tire has more than one cut or puncture wound
318 7-2. Emergency measures
2 3 FourFive
KBPA720501
1 2 3
Four Five 6 7
KBPA720502
Ten thousand
one
of
Field
Go
NS
teeth
320 7-2. Emergency measures
KBPA540202
KBPA720517
Shake the puncture repair agent bottle before screwing in the injection hose.
increase.
KBPA720503
7-2. Emergency measures 321
KBPA720504
nine
Turn the valve core around the valve in the direction shown in the figure.
KBPA720505
KBPA720507
322 7-2. Emergency measures
KBPA720508
After injecting, insert the injection hose into the tire bar. BukaPull out
Valve core as a tire valve
Screw in firmly
The empty puncture repair agent bottle is
Repair at the time of ear replacement or permanent repair
KBPA720509
do
The hose is firmly attached to the tire valve
I will squeeze in.
Set the engine switch to "ACC" (vehicles without key-free system) or set
the engine switch to accessory mode (vehicles with key-free system).
The specified tire pressure can be confirmed on the tire pressure label on the driver's
side. (→ P. 255)
7-2. Emergency measures 323
Please go.
(How to use the jack → P. 334)
KBPA720512
The tires may be severely damaged. In this case, the tire puncture emergency 7
repair kit cannot be used for repair. Please contact your Toyota dealer.
If the air pressure can be boosted to the specified level, turn off the compressor and Ten thousand
one
remove it from the vehicle. of
Field
Start running immediately Go
NS
teeth
Avoid sudden acceleration, sudden braking, and sudden steering, and drive carefully at 80km / h or less.
After driving for 10 minutes or about 5 km, stop at a safe place that does not interfere
(No key-free system
with traffic and set the engine switch to "LOCK".
(Arrival) or set the engine switch to ignition ON mode (vehicle with
key-free system)
324 7-2. Emergency measures
If the air pressure is 130kPa or more, complete the puncture emergency repair.
If the air pressure is 130 kPa or more and does not reach the specified air pressure, turn the compressor power to “ON” and boost
the voltage.
KBPA720515
Avoid sudden braking, sudden acceleration, and sudden steering, and drive carefully at 80km /
h or less to go to a Toyota dealer.
knowledge
――――
About tire valves after emergency repair
When using the emergency repair kit, replace the tire valve core with a new one.
――――
About inspection of emergency repair kit
Check the expiration date of the flat tire repair agent on a regular basis.
Do not use an expired puncture repair agent. Repairs with the emergency repair
kit may not be successful.
Replace it before it expires. For replacement, please contact your Toyota dealer.
Insert the power plug of the compressor for filling tire pressure into the accessory
socket, set the engine switch to "ACC" (vehicle without key-free system) or
accessory mode (vehicle with key-free system), and check the operation. Please.
――――
About the emergency repair kit
――――
The emergency repair kit is for inflating automobile tires.
――――
The puncture repair agent bottle in the emergency repair kit allows you to make an emergency repair of
one tire only once. Please contact your Toyota dealer to replace the used puncture repair agent bottle.
――――
It can be used when the outside air temperature is -30 ° C to 60 ° C.
――――
Only for tires installed on vehicles equipped with an emergency repair kit. Do not use for tires
other than the specified tire size or for other purposes.
7
――――
If a flat tire repair agent adheres to clothing, it may cause stains.
――――
If the puncture repair agent adheres to the wheel or body, it may not be Ten thousand
one
removed if left unattended. Wipe it off immediately with a wet cloth. of
Field
――――
There is a loud noise while the tire pressure filling compressor is operating, but this is not a Go
NS
malfunction. teeth
――――
Do not use the tire pressure filling compressor to check or adjust the tire
pressure.
――――
The empty container of the puncture repair agent bottle will be used to remove the repair agent, so
please bring it to your Toyota dealer.
――――
Purchase a new repair agent at a Toyota dealer.
326 7-2. Emergency measures
――――
When you put in too much air
Loosen the base of the hose and remove the air.
Mouthpiece
when.
KBPA720513
warning
――――
About the emergency repair kit
――――
Store the emergency repair kit in the designated position. It is dangerous because the emergency
repair kit may pop out and be damaged during sudden braking, or it may lead to unexpected
accidents.
――――
The emergency repair kit is for your vehicle only. Please do not use it for other cars. It is dangerous to
use it for other cars as it may lead to an unexpected accident.
――――
Do not use for tires other than the specified tire size or for other purposes. It is dangerous because
the puncture repair is not completely performed and it may lead to an unexpected accident.
――――
About puncture repair agent
――――
If swallowed by mistake, it will be harmful to your health. In that case, drink as much
water as possible and see a doctor immediately.
――――
If it gets in your eyes or gets on your skin, wash it off thoroughly with water. If
you still feel any abnormalities, see a doctor.
――――
When repairing a flat tire
――――
Stop the vehicle on a safe and flat surface.
――――
Immediately after driving, do not touch the wheels or around the brakes. Immediately
after driving, the temperature around the wheels and brakes may be high, so if you
touch your hands or feet, you may get burned.
――――
Tire pressure filling compressors can overheat if operated for extended periods of time.
Do not operate continuously for more than 10 minutes.
――――
If the compressor for filling tire pressure becomes sluggish or the main body
becomes hot, immediately turn off the power and leave it for at least 30
minutes.
――――
Do not put the speed limit sticker outside the designated position. Placing a speed
limit sticker on the SRS airbag deployment, such as the pad on the steering wheel,
can cause the SRS airbag to malfunction.
7-2. Emergency measures 327
warning
――――
About driving to spread puncture repair agent evenly
・ Check the air pressure. 130 kPa (1.3 kg / cm)2If it is less than), the tire may
have been seriously damaged.
caution
――――
When making an emergency repair
――――
Perform emergency repairs without removing the nails and screws stuck in the tire. If you
remove it, you may not be able to make an emergency repair with the emergency repair kit.
――――
The emergency repair kit is not waterproof. When it rains, do not allow it to
get wet.
――――
Do not place it directly on a dusty place such as sand. Inhaling dust may cause
a malfunction. 7
――――
About the emergency repair kit
――――
The emergency repair kit is for DC12V only. It cannot be used with other power supplies.
Ten thousand
one
of
――――
Gasoline on the emergency repair kit can cause it to deteriorate. Do not run Field
Go
out of gasoline. NS
teeth
――――
Store the emergency repair kit away from dust and water.
――――
Store the emergency repair kit in the designated position and be careful not to accidentally
touch your child.
――――
Never disassemble or modify it. Also, do not give an impact to the pressure
gauge. It may cause a malfunction.
328 7-2. Emergency measures
Replace the flat tire with the provided emergency tire. (Refer to P. 254
for a detailed explanation of tires.)
warning
――――
When a tire punctures
Do not drive with a flat tire.
Even at short distances, the tires and wheels can be irreparably damaged and can lead to
unexpected accidents, which is dangerous.
1 2
3 Four 5 6
7
KBPA720401
Ten thousand
one
of
Field
Go
NS
teeth
330 7-2. Emergency measures
warning
――――
About the use of jacks
Please observe the following.
Mishandling the jack can cause the vehicle to fall and cause serious injury or
even death in the worst case.
――――
Do not use the jack for any purpose other than tire replacement, tire chain attachment /
removal.
――――
The built-in jack can only be used in your car, so do not use it in another car or
use the jack of another car in your car.
――――
Jack correctly on the jack set position
――――
Do not put your body under a car supported by a jack
――――
Do not start the engine or drive the car while it is supported by a jack
――――
Do not lift the car with people in the car
――――
When lifting the car, do not put anything on or under the jack
――――
When lifting the car, do not raise it above the height at which the tires can be changed.
――――
Use a jack stand when working under the car
――――
When lowering the car, make sure that there are no people around, and if there are people, call out
and then lower it.
7-2. Emergency measures 331
KBPA540202
K BPA720403
knowledge
――――
To store the jack
After use, return it to its original position and fix it securely.
――――
When storing tools 7
Wheel nut wrench, jack as shown
Store the key handle and tow hook in the tool bag Ten thousand
KBPA720417
Push in
KBPA720418
332 7-2. Emergency measures
KBPA540202
KBPA720405
warning
――――
When storing emergency tires
Be careful not to get your fingers caught between the body and the emergency tires.
7-2. Emergency measures 333
KBPA720406
front wheel
Rear wheel
please.
7
KBPA720407
Meru one
of
Field
Go
NS
teeth
KBPA720408
334 7-2. Emergency measures
KBPA720409
KBPA720410
KBPA720411
7-2. Emergency measures 335
warning
――――
About tire replacement
―――― ..
Do not touch the disc wheels or brakes immediately after driving. The temperature
of the disc wheels or brakes immediately after driving is high, so if you touch your
hands or feet due to changing tires, you may get burned.
――――
Failure to observe the following may result in loose nuts, wheels falling off,
serious injury or, in the worst case, death.
-Do not apply oil or grease to the threaded part or the tapered part of the
nut. When tightening the nut, it may be tightened more than necessary,
which may damage the bolt or the disc wheel. Also, the nut may loosen and
the wheel may fall. If oil or grease is attached to the threads, wipe it off.
・ Immediately after replacing the wheel, tighten the nut with a force of 103N ・ m (1050kgf ・
cm).
-Use nuts for the wheel you are using to install the tires.-If there are any abnormalities
such as crushing or cracking in the bolts and nut threads, or in the bolt holes of the
wheel, check with a Toyota dealer. receive
・ When installing the nut, be sure to install it with the taper part inside (
→ P. 257).
Wipe off
7
If the wheel contact surface is dirty, it will run
The nut loosens inside and the tire comes off
There is a risk of
Ten thousand
one
of
Field
Go
NS
teeth
KBPA720412
336 7-2. Emergency measures
Install the emergency tire and temporarily tighten the nut by hand until the tire
does not rattle.
Turn until the tapered part of the nut lightly hits the seat part of the wheel.
KBPA720415
KBPA720416
knowledge
――――
About emergency tires
――――
TEMPORARY USE ONLY is written on the side of the tire. Use only for emergency
purposes.
――――
Be sure to check the air pressure. (→ P. 357)
――――
When wearing emergency tires
The vehicle height is lower than when standard tires are installed. Please be careful when climbing
over steps.
――――
When the front wheel punctures on a snowy road or an icy road
Remove the punctured front wheel and replace it with the rear wheel
warning
――――
When using emergency tires
――――
Please do not use it for other vehicles as it is exclusively for your vehicle.
――――
Do not use more than one emergency tire at the same time.
――――
Replace with regular tires as soon as possible.
――――
Avoid using sudden acceleration, sudden steering, sudden braking, or sudden engine
braking due to shift operation.
――――
When storing emergency tires 7
Be careful not to get your fingers caught between the body and the emergency tires.
Ten thousand
one
of
Field
Go
NS
teeth
338 7-2. Emergency measures
warning
――――
When wearing emergency tires
The exact vehicle speed may not be detected and the following systems may
not work properly.
・ ABS ・ VSC
・ Brake assist ・ TRC
・ EPS ・ Smart Assist II★
In addition, the following systems may not only perform sufficiently, but may also
adversely affect the drive train components.
――――
Speed limit when using emergency tires
Emergency tires are not suitable for high-speed driving and may lead to unexpected
accidents.
caution
――――
Precautions while wearing emergency tires
While the emergency tires are installed, the vehicle height may be lower than when the standard
tires are installed. Be careful when climbing over steps.
――――
About tire chain installation
Do not attach tire chains to emergency tires. The tire chains may hit the vehicle
body and damage the vehicle or adversely affect driving.
★
: Depending on the grade, options, etc., it may or may not be equipped.
7-2. Emergency measures 339
If the engine does not start even if you follow the correct way to start
the engine (→ P. 126, 129), check the following.
If the starter is running normally but the engine does not start
The following causes are possible.
Please refuel.
You may be sucking in too much fuel.
――――
P. 58)
When the starter turns slowly / The interior light / headlamp is dark / The sound of the
horn is low or does not sound
The starter does not turn (vehicles equipped with a key-free system)
7
There is a possibility of an electrical system abnormality such as a broken electrical component
――――
or a blown fuse. Depending on the type of anomaly, the engine can be started as a temporary Ten thousand
one
measure. (→ P. 341) of
Field
There may be something wrong with the steering lock system.
―――― Go
NS
teeth
★
: Depending on the grade, options, etc., it may or may not be equipped.
340 7-2. Emergency measures
When the starter does not turn / The interior light / headlamp does not turn on / The horn
does not sound
If you do not know how to take the procedure, or if the engine does not start even after taking the
procedure, contact your Toyota dealer.
7-2. Emergency measures 341
If the communication between the electronic card key and the vehicle is interrupted (
→ P. 89) or the battery of the electronic card key runs out, the key-free system and
wireless remote controller cannot be used. In such cases, you can open the door or
start the engine by following the steps below.
KBPA720801
KBPA720802
knowledge
――――
How to stop the engine
Set the shift lever to P and press the engine switch in the same way as when stopping the engine
normally.
――――
About battery replacement
The engine starting method described here is a temporary measure. If the battery runs out, we
recommend that you replace the battery immediately. (→ P. 268)
――――
Switching the engine switch mode
If you take your foot off the brake pedal and press the engine switch in the procedure for starting
the engine, the engine will not start and the mode will switch each time you press the switch. (→ P.
130)
7-2. Emergency measures 343
If the battery is dead, you can start the engine by following the steps
below.
With a booster cable and a rescue vehicle with a 12V battery, you can
start the engine by following these steps:
Remove the cover of the + terminal of the battery and connect the booster cable in the
following order.
Connect the red booster cable to the + terminal of your car's battery
Connect the other end of the red booster cable to the + terminal of the rescue
vehicle battery
Connect the black booster cable to the-terminal of the rescue vehicle battery
1 Four
7
3
Ten thousand
one
of
Field
2 Go
NS
KBPA720901
teeth
Start the engine of the rescue car, increase the rotation a little, and FiveMinutes of your car
charge the battery about
When the engine of your car starts, disconnect it in the reverse order of connecting the
booster cable.
Even if the engine starts, have it inspected at a Toyota dealer as soon as possible.
knowledge
――――
About starting when the battery is dead
――――
When the engine is not running, turn off the lamp and air conditioner.
――――
If you have been stopped for a long time due to traffic jams, turn off unnecessary electrical components.
――――
When the battery is dead
The information stored on your computer will be erased. When the battery is
dead, have it inspected at a Toyota dealer.
――――
About charging the battery
Battery power is consumed little by little, even when the vehicle is not in use, due to consumption
by some electrical components and spontaneous discharge. Therefore, if the vehicle is left
unattended for a long period of time, the battery may run out and the engine may not start. (The
battery is automatically charged while driving)
――――
When the battery is dead or removed (vehicles equipped with a key-free system)
――――
Immediately after the battery is dead, the key-free system may not be able to
unlock the door. If you cannot unlock it, use the wireless remote controller or
mechanical key to unlock and lock it.
――――
The first engine start after the battery is dead may fail. The second and
subsequent engine starts will work normally, so this is not a problem.
――――
The vehicle always remembers the state of the engine switch. When the battery is dead,
after the battery is removed, it will return to the state before the battery was removed.
Before installing or removing the battery, turn off the engine switch. Be especially careful
when connecting the battery if you are unsure of what it was like before the battery was
dead.
――――
When replacing the battery
The installed battery is exclusively for the Stop & Start system. Replace
with one of equivalent performance.
If you do not use the proper battery, the battery may deteriorate prematurely
and, in the worst case, the engine may not restart.
Please contact your Toyota dealer for details.
7-2. Emergency measures 345
warning
――――
To prevent battery ignition or explosion
The flammable gas generated from the battery of the rescue vehicle may ignite and explode,
which is dangerous. Therefore, please observe the following to prevent fire and sparks.
――――
Do not accidentally touch the booster cable to anything other than the correct terminal or connection.
――――
Do not allow the tip of the booster cable connected to the + terminal to come into contact with nearby
brackets or unpainted metal parts.
――――
The booster cable never touches the + and-side terminals.
――――
Do not smoke or ignite with a match or lighter near the battery
――――
About handling of battery
The battery contains a toxic and corrosive acidic electrolyte, and the related
parts contain lead or a mixture of lead, so be sure to observe the following
when handling.
――――
Wear protective goggles when handling the battery to prevent liquid oxygen from adhering to
your skin, clothing or vehicle.
――――
Keep your face and head away from the battery more than necessary
――――
If you accidentally get battery fluid on your body or in your eyes, immediately wash with plenty
of water and see a doctor immediately.
Also, apply a sponge or cloth soaked in water to the affected area until you see a doctor.
――――
If you accidentally swallow battery fluid, drink plenty of water and see a doctor
immediately.
7
――――
Wash your hands after handling battery stanchions, terminals and other related parts
――――
Keep your child away from the battery Ten thousand
one
――――
To prevent car damage of
Field
Go
Do not push or pull the vehicle to start it. The catalytic converter NS
may overheat and cause a fire. teeth
caution
――――
Handling of booster cables
When connecting or disconnecting the booster cable, be careful not to get
caught in the cooling fan or belt.
346 7-2. Emergency measures
When overheated
Workaround
When
―――― the high water temperature warning light blinks or lights up
Stop in a safe place, turn off the air conditioner, and then stop the
engine.
If there is steam:
After confirming that steam is no longer emitted, carefully open the
hood.
If there is no steam:
Carefully open the hood
After the engine has cooled sufficiently,
Radiator core part (heat dissipation part)
And cooling water from hoses, etc.
Check it
fan 1
radiator
If there is a large amount of cooling water leaking,
2 KBPA721001
Please contact your Toyota dealer immediately.
when.
7-2. Emergency measures 347
The amount of cooling water is “FULL” in the reservoir tank. (Upper limit) and “LOW”(under
Check if it is between
Reservoir tank “LOW” (lower limit)
Four 2
KBPA721002
cold
RejectIf there is no water , Please replenish water as a first aid measure.
KBPA721003
7
Start the engine, operate the air conditioner, check that the radiator
cooling fan is working, and check again that there is no cooling water Ten thousand
one
leak from the radiator core, hose, etc. of
Field
Immediately after starting the engine when it is cold, turn on the air conditioner to operate Go
NS
the fan. Check with the sound of the fan and the wind. If it is difficult to understand, turn teeth
warning
――――
To prevent accidents and injuries during engine room inspection
――――
Keep your hands and clothes (especially ties, scarves, scarves, etc.) away from fans and belts. It
is dangerous because your hands and clothes may get caught and you may be seriously
injured.
――――
Do not open the radiator cap and cooling water reservoir tank cap if the
engine and radiator are hot.
High temperature steam or cooling water may spurt out due to pressure.
caution
――――
When adding cooling water
――――
Do not use additives for cooling water
7-2. Emergency measures 349
If the tires slip or get stuck in muddy, sandy or snowy roads, try the
following methods.
Apply the parking brake, set the shift lever to P, and stop the engine.
If it is difficult to escape due to the operation of TRC / VSC, stop TRC or VSC. (→ P.
200, 201)
warning
――――
When to escape
If you repeatedly move forward and backward to escape from the stack, make sure there is
nothing around you to avoid collisions with other vehicles, objects or people.
Be especially careful when escaping the stack, as the car may jump forward or
backward.
――――
When operating the shift lever 7
one
of
Field
Go
NS
caution teeth
――――
To avoid damage to the transmission and other parts
――――
Avoid spinning tires and do not step on the accelerator pedal more than necessary.
――――
If you are unable to escape using the above method, you will need help by towing.
350 7-2. Emergency measures
351
Vehicle information
8
8-1. Specification list
Maintenance data
(Designated fuel ・
Oil amount, etc.) ...................... 352
The quality of the oils and liquids used will significantly affect the life of your car. Our genuine oils
and liquids that are most suitable for cars (hereinafter referred to as It is called "designated brand"
fuel
engine oil
With oil
Designated brand engine Oil only oil
Exchange filter
Exchange
* 1 The capacity of engine oil is a guide when changing. Check the amount of oil by engine
Stop after warming up, and wait at least 5 minutes before using the level gauge.
* 2 0W-20 is the most fuel-efficient oil among the designated brands in the above table.
car
Both
Information
Information
354 8-1. Specification list
Use oil that meets the API standards SN / RC, SM / EC, or ILSAC
standards. The cans of oil that have passed the ILSAC standard bear
the ILSAC CERTIFICATION mark.
API mark
ILSAC CERTIFICATION Mar 1 2
nine
KBPA810101
Recommended
―――― viscosity of engine oil
Based on the figure below, use one with a viscosity suitable for the outside air temperature.
KBPA810102D
* 0W-20 is filled when the car is new, and it is the most fuel-efficient in the above figure.
An excellent oil.
About oil viscosity (explained with 0W-20 as an example):
・ 0W of 0W-20 indicates the engine starting characteristics at low temperature. The
smaller the number before W, the easier it is to start the engine in winter or cold
weather.
・ 20 of 0W-20 shows the viscosity characteristics at high temperature. Highly
viscous (high numbers) oils are suitable for high speed or heavy load driving.
8-1. Specification list 355
radiator
Capacity [L]
Designated brand engine
(Reference value)
Automatic transmission
Capacity [L]
Designated brand
(Reference value)
Information
356 8-1. Specification list
break
Brake fluid
――――
Designated brand
break pedal
――――
play 0.5-3
Gap with the floor board when stepping on* 80 and more
* Gap with the floor plate when a pedaling force of 294 N (30 kgf) is applied while the engine is rotating.
minimum value
Parking brake
――――
Step on
5-7
Notch when operating force is 245 N (25 kgf)*number
washer
2.0 2.0
8-1. Specification list 357
Tires / wheels
250 250
Standard tire 165 / 65R14 79S 14 x 5J
(2.5) (2.5)
Emergency tires T115 / 70D14 88M 14 x 4T 420 (4.2)
head lamp
Vehicles equipped with halogen headlamps
Backlight 16 16
car
Vehicle specifications Both
Information
Information
1KR-FE
M700A FF (front wheel drive)
(1.0L gasoline)
1KR-FE
M710A 4WD (4 wheel drive)
(1.0L gasoline)
358 8-2. Customization function
→ P. 79, P. 88)
(→ P. 187)
Somewhat early
Starting of the preceding vehicle start notification function
standard
Notification timing quick
★
: Depending on the grade, options, etc., it may or may not be equipped.
8-2. Customization function 359 359
――――Illuminations (→ P. 226)
OFF OFF
Room that lights up after opening and closing the door
15 seconds
Time until the light turns off automatically 7.5 seconds
slow car
Both
4 seconds at the start of intermittent operation
do do not
Information
Information
★
: Depending on the grade, options, etc., it may or may not be equipped.
360 8-2. Customization function
The following items require initial settings for the system to work properly, such
as after reconnecting the battery or performing maintenance.
car
Both
Information
Information
362 8-3. Initial setting
363
Index
In such a case
(Index by symptom) ........................................ 364
If you have any problems, please check the following before contacting your
Toyota dealer.
If you lose your key or mechanical key, you can make a new Toyota
――――
If you lose your key or electronic card key, the risk of theft is extremely high,
――――
Vehicles
―――― equipped with a key-free system
Vehicles
―――― equipped with a key-free system
The function may not be working properly depending on the radio wave condition.
(→ P. 83)
If the child protector is on, it will not open from inside the car. Please
open it from the outside of the car and release the child protector. (→
P. 92)
In such cases (symptom-specific index) 365
Are you pressing the engine switch while pressing the brake pedal
――――
firmly? (→ P. 129)
Is the shift lever set to P? (→ P. 129)
――――
The shift lever does not move from P even when the brake pedal is depressed
To prevent theft, it will be locked when the key is removed from the engine
switch (→ P. 126).
Vehicles
―――― equipped with a key-free system
Door glass does not open or close even when the power window switch is operated
If the window lock switch is pressed, the power window other than the
driver's seat cannot be operated. (→ P. 110)
If you leave it in the accessory mode or ignition ON mode (when the engine is not
――――
applied) for a certain period of time, the automatic power off function will be
activated. (→ P. 131)
In such cases (symptom-specific index) 367
When the warning sound starts to sound,"When you hear a sound from your car (sound index)
―――― "
Please check (→ P. 368).
Tire is punctured
Vehicles
―――― with emergency tires
Park your car in a safe place and replace the flat tire with an
emergency tire. (→ P. 328)
Vehicles
―――― equipped with a tire puncture emergency repair kit
Park your car in a safe place and use the tire puncture emergency
repair kit to repair punctured tires. (→ P. 316)
Stuck
Try an escape method when you get stuck in muddy, sandy, snowy
――――
In the following situations, a horn sounds to notify you of the condition of the car or erroneous
operation.
When driving
When the car is stopped Even if the preceding vehicle started, it continued to stop★ P. 187
* The buzzer may sound even if you have luggage in the passenger seat.
★
: Depending on the grade, options, etc., it may or may not be equipped.
Alphabetical order 369
Alphabetical order
4WD
(4 wheel drive) .. .. .. .. .. .. .. .. .. .. .. .. .. .. .. .. .. .. P. 199A / C
a Indicator ................................ 64
Armrest ................................ 238 Interior lamp ......................... 226
Armrest pocket .................. 233 Switch .................................. 226
Idling stop .................. 189 Wattage ..................... 357
Idling stop time ....... 69 Inner mirror ...................................... 106
SMART STOP ............ 189
Stop & Start Cancel Cormorant
Indicator light ..................... 190 Turn signal (direction indicator) ............ 137
Stop & Start system ........ 189 Replacing the light bulb (bulb) ............ 276
Stop & Start indicator light ............ 189 Direction indicator lever ........................ 137
Switch ..................................... 126, 129 Position Switch ........................ 144, 146 Tank
exchange capacity ..................... ........... 356
(Tire rotation) ............. 254 Preparation and inspection before winter ... 205
Arrangement ............................. 33
eco Drive Oh
Indicator ............... 116 oil
engine Capacity and brand of fats and oils ..... 353
Backdoor ..................... 94
Bonnet .................. 250
372 Japanese syllabary index
Warning when carrying a child ... 31 How to install the floor mat ....... 22
Key battery warning ........ 271 Outside air temperature display .................................. 70
Keyless entry .......... 79, 88 I lost my light was on ..................... ..... 308
Starting the engine ........... 129 flashing light ..................... ......... 293
Radio waves
About the impact ........................... 87
Locking / unlocking the door ...................... 91
(horn) ............... 105 Lane departure warning OFF indicator light ...... 309
Clearance lamp (vehicle side light) ... 139 Charging ..................................................... 308
Makeup mirror (vanity mirror) ... 236 Direction indicator lever ........................ 137
Seat under tray .................. 229 Lane departure warning function ..................... 184
Seat heater ............................ 222 Lane departure warning system light ..................... 158
Pretensioner warning light ...... 308 Vehicle specifications (specs) ..................... 357
Interior lamp (interior lamp) ....... 226 Recording vehicle data ............... 7
Interior lamp ......... 226 To stop the vehicle in an emergency .............. 296
How to start ..................... 126, 129 Specifications (vehicle specifications) ........................ 357
Defogger ............. 211, 217 Replacing the light bulb (bulb) ............ 276
Exterior ..................................... 244 Replacing the light bulb (bulb) ............ 276
ancestor
blood hand
Chain (tire chain) ....... 205 Display ..................... 68
Change lever (shift lever) Trip
automatic Information ................ 69
Transmission ............. 134 Care ..................... 244, 247
The shift lever Aluminum wheels ........... 245
I can't shift ..... 135 Exterior ........................................... 244
Reverse warning buzzer ............... 135 Seat belt ........................... 248
Child seat .................. 41 Interior ..................................................... 247
Installation with ISOFIX bar ........ 52 Tail lamp (tail light) ..................... 139
Fastening with seat belts ............... 51 Replacing the light bulb (bulb) ............ 276
When NS
door................................................. ..91 Interior
fire buzzer
Vehicle stability Forgetting to fasten the seat belt Warning .... 310
Auto air conditioner ....................... 215 Warning when driving half-door ..................... 310
How to connect ..................................... 343 There is a squeaking noise from near the brake
Front seat ................................ 98 Forgetting to turn off the lamp Warning buzzer .... 142
Seat heater ...................... 222 Function to prevent forgetting to turn off the lamp ........ 141
Replacing the light bulb (bulb) ............ 276 Direction indicator lever ........................ 137
Door mirror ............................ 107 Replacing the light bulb (bulb) ............ 276
Wiper &
NS Washer ..................... 144, 146 Wiper
Room mirror blade (for cold regions) .... 206
(Inner mirror) ............ 106 Wireless remote control ........................88
Room lamp (indoor light) .................. 226 Operation signal .................................. 88
P. 250 P. 150
KBPAI50001