Professional Documents
Culture Documents
IMPORTANT - All
GENERAL MANAGER Service Personnel
PARTS MANAGER Should Read and
CLAIMS PERSONNEL Initial in the boxes
SERVICE MANAGER provided, right.
SERVICE BULLETIN
APPLICABILITY: 2010MY and later Legacy and Outback NUMBER: 06-41-11
SUBJECT: Vehicle Dynamic Control (VDC) DATE: 10/11/11
DTC C0074 and/or DTC C0075
INTRODUCTION
If you encounter a vehicle which has DTC C0074 (with detailed code 5078) and/or DTC
C0075 (with detailed code 5088 or 5099) stored in memory, there is the possibility it is caused
by low battery voltage.
The learning value of the brake pressure sensor is recorded after every time the IG (ignition)
is cycled to the Off position. If the battery voltage drops below a predetermined value before
the recording process has been completed, the learning value is lost and a DTC will be
stored and MIL turned on the next time the IG (ignition) is cycled to the ON position. As an
example, if the engine is started by jump-starting and the IG is switched to OFF before the
battery has regained sufficient voltage, the learning value will be lost.
NOTE: SSMIII software update, October 2011 version, includes the “Zero setting mode of
Pressure sensor”.
REPAIR PROCEDURE/INFORMATION
Conduct “Zero setting of Pressure sensor” according to the following procedure. The vehicle
needs to be parked and the wheels pointing straight forward.
Connect SSMIII to vehicle and select the menu as follows.
WARRANTY/CLAIM INFORMATION
For vehicles within Warranty, this repair can be claimed using the following.