Professional Documents
Culture Documents
Hu
3-b
To
ROTOR MU
FROM ABO
ular center piece: Bearing is p
depron Tube is app
2 mm carbon rod Important: p
leading edge Retain rotor
Tape to rotor blade
1 mm plywood
ood or
depron®
Motor: 25 grams out
Prop: 8"-9" GWS Slo
ESC: 10A-12A
Battery: 2S360 - 2S5
Servo: rotor tilt: 9 gra
Firewall to suit
Rotor blade LE is 2 mm
trunner, 1300-1500 kv
ow Fly Dummy rotary engine
Paste paper template
500 onto 6 mm depron
ams, rudder & elevator 6 grams Cut out center section and areas
between cylinders
er motor
7 prop was
R
t motor mount
Battery
ESC Rx
m carbon
1 mm plywood control horn
1 mm pl
Use CA wick type hinges or Tyvek® (both sid
Use foam friendly CA!
x
lywood disk to anchor LG
des of fuselage)
3 mm
ubing
rod taped to depron
Depron® 3mm, 10 mm
Put UNDER rotor blad
o stick out
glueing area
ub center block
x. 7 mm
R
m depron.
Use 45-60 mm
lightweight wheels
A-A'
LG reinforcement
section of fuselage)
Rotor mast
Hinge control surfaces
with clear tape
Control s
Balance:
Rotor tilt
Elevator:
Rudder: +
m plywood disks
ia.) on bottom and
or hub for reinforcement
settings:
: hang angle approx. -3°
t: 7° each way
: +/- 25°-30°
+/- 20°
Do not forget this cutout for the LG brace!
J-AG4
An easy to build and very eas
high fun factor. 4 Ch. required
Target weight approximately
Construction: fuselage 6 mm
3 mm (1/8") Depron®.
Based upon the J-AG3 au
Drawing by Willem Bravenboer
© Gary L. Jones
REV. 2010-03-22
sy to fly autogyro with an extremely
d (rudder, elevator, rotor tilt, throttle).
200 grams (6.5 oz.) ready to fly.
(1/4") Depron® or FFF. Rotor blades: