Professional Documents
Culture Documents
1. The overhanging beam shown in the figure below carries a uniformly distributed load of
intensity 100kN/m, which includes the self-weight of the beam. The beam is constructed
of three plates welded together to form the cross-section shown. The allowable bending
stress and the allowable shear stress are 100MPa and 60MPa respectively.
a) Determine the required width b of the top and bottom flanges
b) Using the calculated width, find
(i) the maximum bending stresses at a section 2m from the left support
(ii) the shear stress at a section 2m from the left support and 525mm below the top
flange
25mm
100kN/m
20mm
1200mm
6m 1m
25mm
30kN/m
300mm
25mm
6m
20mm
200mm
150mm
3. The stress at a point is indicated. Using both the transformation equation and Mohr’s
circle, determine:
a) The shear stress, x1y1 about axis b-b, which is oriented at an angle of =45o.
b) The principal stresses and maximum shear stresses at the point and show them
on a sketch of a properly oriented element.
a
b
x1y1
80MPa
60MPa
b
a