Professional Documents
Culture Documents
for
Prepared By:
Engineering
1
P.O. Box 1047 Addis Ababa Ethiopia
Tel. +251 (0) 115 505 678
Fax: +251 (0) 115 515 777
1
Simon Mekonnen simon.mekonnen@ethiotelecom.et +251-911-255974
1
Atsedemariam Gebeyehu amariam.gebeyehu@ethiotelecom.et 251-912422071
2
P.O. Box 1047 Addis Ababa Ethiopia
Tel. +251 (0) 115 505 678
Fax: +251 (0) 115 515 777
I. Background
Ethio Telecom delivers fixed wireless broadband (FWBB) with point to point (PtP)/point to multipoint
(PtMP) wireless radio system solution for those customers at location out of fixed cable connection
due to unfavorable topography or needing backup connectivity with different media. This solution is
available anywhere without location barrier in short period of time easily with the customer delivered
CPE (e.g. router).
Suweys three and two-wheel assembling workshop at Somali region, around Jijiga town is such
customer & found in EER. Suweys three and two-wheel assembling workshop customer contact is
Mr. Anbes Getahun & his number 0915744521 or 0923172221.
Bandwidth
No. Customer name Latitude Longitude
Requested
1 Suweys three and two-wheel assembling workshop 20Mbps Internet 9.36648 42.725393
Table 1. Requested BW and Customer location
3
P.O. Box 1047 Addis Ababa Ethiopia
Tel. +251 (0) 115 505 678
Fax: +251 (0) 115 515 777
Increases network uptime
Enhances the user experience through fault management and performance monitoring
The solution is easily mountable at ethio side with the existing tower and customer side with customer
provided mounting structure.
RADWIN 2000 Alpha has element management system (RADWIN WINManage) hence it needs
configuration of management on top of user traffic configuration. The PtP wireless equipment
extends the Ethernet interface to customer location & the customer has to deliver CPE device (e.g
router).
Internet
Router
& BRAS
NMS for
Core SW PTMP&PTP
ETH
ETH LEGEND
ET-IPRAN UTP
NetworkETH
Wireless link
Internet traffic
RTN/ Managemtnt traffic
IPRAN PTP radio A
PTP radio B
CPE (e.g
router)
4
P.O. Box 1047 Addis Ababa Ethiopia
Tel. +251 (0) 115 505 678
Fax: +251 (0) 115 515 777
The 7-EG6-2(PORT-2) on wireless microwave site (RTN Site ID: 151043) has Ethernet interface
and in this opening RJ45 shall be used. On the PtP wireless side, UTP cable shall be connected to
the port LAN IN on DC PoE device (RW-9921-2059 PoE/DC/GBE/ET/10-60/). DC power cable
drawn from the exiting RTN site PDB shall be connected to PoE DC connector. The PoE output (P-
LAN-OUT) can be pulled to lighting protection unit (LPU) device nearby to outdoor unit (ODU) radio
device at suitable position of the existing tower.
At customer end, the reverse is implemented with AC PoE device (RW-9921-1021
PoE/AC/GBE/24V/EU) then goes to the customer prepared socket. The data from PoE shall be
connected to the customer purchased CPE device (e.g. enterprise router).
RF Cable Rx RF Cable
Tx Rx Tx
ET Tower
UTP
Power Plug
AC Socket
CPE (router)
Radwin NMS server
(WinManage) Power Plug Customer Side
PDB Network
UTP
ET Network
Internet
Gatway MW(RTN) Device
5
P.O. Box 1047 Addis Ababa Ethiopia
Tel. +251 (0) 115 505 678
Fax: +251 (0) 115 515 777
The wireless PTP ODU antenna shall be deployed on the MW/BTS tower (RTN site ID: 151043) at
the height of 20m and customer side tower/mast/pole at 9m from the ground as shown in figure 2
and the air distance between the two antennas is 2.6km.
The parameters for PtP wireless equipment are listed in the table blow.
6
P.O. Box 1047 Addis Ababa Ethiopia
Tel. +251 (0) 115 505 678
Fax: +251 (0) 115 515 777
Azimuth 78.3° 258.3°
As above snapshot indicates, with only 10MHz channel bandwidth 57.9Mbps aggregate or 29Mbps
full duplex can be achieved.
7
P.O. Box 1047 Addis Ababa Ethiopia
Tel. +251 (0) 115 505 678
Fax: +251 (0) 115 515 777
IP Address/Mask VRF
B. VLAN Plan
Basestation Name MGMT SVLAN Remark
Note: please confirm the VLAN before starting configuration. Any of them have to be updated if not free.
C. Topology
Fig. 4 IP Topology
8
P.O. Box 1047 Addis Ababa Ethiopia
Tel. +251 (0) 115 505 678
Fax: +251 (0) 115 515 777
D. Configuration procedure
Management Service
9
P.O. Box 1047 Addis Ababa Ethiopia
Tel. +251 (0) 115 505 678
Fax: +251 (0) 115 515 777
interface smartgroup1//To-JG-PE-A interface smartgroup1 //To-JG-PE-B
switchport hybrid vlan 3094-3095 tag switchport hybrid vlan 3094-3095 tag
# #
switchport hybrid vlan 3094-3095 tag switchport hybrid vlan 3094-3095 tag
# #
JG-PE
Use description
VRRP-first IP Address
Second IP PE-A
Third IP PE-B
Fourth IP P2P
VRF OAM
Summary
10
P.O. Box 1047 Addis Ababa Ethiopia
Tel. +251 (0) 115 505 678
Fax: +251 (0) 115 515 777
PtP wireless Device Location for Material Requisition (MR)