You are on page 1of 14

Android industrial control LCD display

Model
STAD070WT-05

Equipment Manual
All rights reserved by STONE

Technologies

Contents

1 Android LCD Specification Introduction....................................................................3


1.1 Introduction.......................................................................................................... 3
1.2 Technical Parameters............................................................................................4
2 Interface Description...................................................................................................6
2.1 Serial Ports............................................................................................................6
2.2 USB-HOST Interface........................................................................................... 6
2.3 USB-DEVICE Interface....................................................................................... 7
2.4 GPIO Interface......................................................................................................7
2.5 Network Interface.................................................................................................7
2.6 TF Card Holder.....................................................................................................7
2.7 Audio Interface.....................................................................................................7
2.8 WIFI and Bluetooth Module................................................................................ 8
2.9 4G Module (Optional).......................................................................................... 8
2.10 GPS Module (Optional)......................................................................................9
3 Accessories................................................................................................................10
3.1 Antenna Selection...............................................................................................10
3.2 Speaker............................................................................................................... 10
4 Physical Dimensions................................................................................................. 11
5 International Certification......................................................................................... 12
6 Naming Rule............................................................................................................. 13

STAD070WT-05 Equipment Manual www.stoneitech.com


Release 01/2019 2
All rights reserved by STONE

Technologies

1 Android LCD Specification Introduction


1.1 Introduction

STAD070WT-05 Android LCD is a new model Android LCD by STONE Tech.


It is equipped with 1.2GHz Quad-core Coretex A7. Recommended power
supply is DC 12V, with capacitive touch screen, the PCB board integrates a
variety of peripheral interfaces.

STAD070WT-05 Equipment Manual www.stoneitech.com


Release 01/2019 3
All rights reserved by STONE

Technologies

1.2 Technical Parameters


Main Parameters
Parameter Description
CPU Quad-core 1.2Ghz ARM Cortex™-A7
System Android 4.4.2 Rooted
RAM 1GB 2pcs 512MB DDR3
eMMC 8GB eMMC
GPU Mali400MP2 OpenGLES2.0 VG1.1

Display Parameters
Parameter Description
Interface RGB
Resolution 1024x600 16:9 Ratio
Touch Type Capacitive 5 points touch
Luminance 400 cd/m2
Viewing Angles Full viewing angles IPS

Peripheral Interfaces
Interface Quantities Description
Power 1 DC 5.5*2.1MM
1 RS-232 multiplex with RS-485,
Serial port 4 RS-232, 1 RS-485(Optional)
connector is IDC10X1-3.5MM
2 USB HOSTs for peripheral
devices,
USB 2 HOST, 1 DEVICE
The USB HOST at the bottom is
shared with 4G module
8R/3W Amplifier, SPK connector
Audio 1 MIC, 2 SPK
is PH2.0MM-4P
TF Slot 1 TF Card slot
SIM Slot 1 Micro SIM slot
10/100Mbps self-adaptive
Ethernet 1
network interface

GPIO 4 Level 5V, 2 inputs, 2 outputs

4G 1 (Optional) 7 Mode full Netcom


8188EU or 8723BU Bluetooth &
WIFI 1 (Optional)
WIFI 2-in-1
8723BU Bluetooth & WIFI 2-in-1
Bluetooth 1 (Optional)
Support Bluetooth 4.0
GPS Global positioning, Quectel
GPS 1 (Optional)
4G module with GPS

STAD070WT-05 Equipment Manual www.stoneitech.com


Release 01/2019 4
All rights reserved by STONE

Technologies

Power Supply
Parameter Min Typical Max Unit
Operating Voltage 9 12 30 V
Operating Current 400 mA

Reliability Test
Min Typical Max Unit
Operating Temperature -10 25 70 ℃
Storage Temperature 0 50 ℃
Operating Humidity 5 95 RH%

Structure
Size Description
External Dimensions 209.49mm*106.00mm*25.10mm

STAD070WT-05 Equipment Manual www.stoneitech.com


Release 01/2019 5
All rights reserved by STONE

Technologies

2 Interface Description
2.1 Serial Ports
STAD070WT-05 is integrated with 4 serial ports. UART0, UART1, UART2,
UART3 are RS-232 level converted. All have been treated with anti-static
treatment.

UART2 and UART3 is an RS-232 and RS-485 hardware multiplex


interface, can be connected to an external RS-485 level device. The serial
ports are all brought out through a connector.

Serial port definition as table below:


Interface Pin Pin Defination Device Node Level Serial Port
1 RXD0
TtyS0 RS232 UART0
2 TXD0
3 RXD1
TtyS1 RS232 UART1
4 TXD1
5 GND
6 RXD2
TtyS2 RS232 UART2
7 TXD2
J10
6 B3
TtyS3 RS485 UART3
7 A3
8 RXD3
TtyS3 RS232 UART3
9 TXD3
8 B2
TtyS2 RS485 UART2
9 A2
10 GND

2.2 USB-HOST Interface


STAD070WT-05 supports 2 USB-HOSTs. The USB-HOST at the bottom
is shared with 4G module, if user needs 4G function, this USB-HOST will
be occupied by 4G module and cannot connect with other USB devices.
It can be connected to USB peripherals such as USB keyboard and
mouse, USB flash drive, and USB interface camera (supporting UVC
protocol).

STAD070WT-05 Equipment Manual www.stoneitech.com


Release 01/2019 6
All rights reserved by STONE

Technologies

2.3 USB-DEVICE Interface


STAD070WT-05 has a USB-DEVICE interface. This interface can only be
used for system programming and ADB debugging.

2.4 GPIO Interface


With 4 GPIOs, 2 of which are inputs and 2 are outputs. Optional 4 inputs.
Interface Pin Pin Defination direction GPIO
1 VCC5V
2 CSI_HSYNC Enter PE2
J9 3 CSI_PCLK Enter PE0
4 CSI_VSYNC Output PE3
5 CSI_MCLK Output PE1
6 GND

2.5 Network Interface


It is a 100M adaptive Ethernet interface that is brought out via RJ45. If you
want to use Android's Ethernet function, you need to plug the network
cable into the ETH interface and then turn on the Ethernet function by
setting. The default Ethernet is DHCP-assigned IP. If you want to
manually configure the IP address, you can configure it in the advanced
settings.

2.6 TF Card Holder


The onboard leads 4-bit data cable to the TF card holder, supports
large-capacity storage. It is designed for hot-swap detection, supports
eMMC protocol 4.3 and SD Memory Card protocol v2.0.

2.7 Audio Interface


STAD070WT-05 has a microphone and two left channel speaker. the MIC

STAD070WT-05 Equipment Manual www.stoneitech.com


Release 01/2019 7
All rights reserved by STONE

Technologies
The SPK interface is an 8R/3W amplifier circuit.

interface definition:
Interface Pin Pin Defination
J25(SPK) 1 +OUT_L
2 -OUT_L
3 +OUT_R
4 -OUT_R
J24(MIC) 1 MIC1_N
2 MIC1_P

2.8 WIFI and Bluetooth Module


If you only want to use the WIFI function, you can use RTL8188EUS as
the WIFI module. If you also want to use the Bluetooth function, you can
choose the Bluetooth WIFI 2-in-1 RTL8723BU module. The 8723BU can
support the Bluetooth 4.0 protocol, which supports the function of
transferring files to and from devices such as mobile phones after pairing.

2.9 4G Module (Optional)


The mother board supports the 4G module of the MINI-PCIE interface. If
you need to use the 4G function, you only need to insert the module into
the mother board, then put the SIM card into the card slot to use the 4G
function.

The mother board card slot supports only the Micro SIM card.
The 4G module supports
TD-LTE/FDD-LTE/TD-SCDMA/WCDMA/EVDO/CDMA1X/GSM mode,
please refer to chart below and confirm with your network operator first.

Note: The SIM card is slanted to the outside.

Supported Band Frequency

TD-LTE B34/B38/B39/B40/B41

FDD-LTE B1/B3/B5/B8

TD-SCDMA B34/B39

WCDMA B1/B8

CDMA1X BC0

STAD070WT-05 Equipment Manual www.stoneitech.com


Release 01/2019 8
All rights reserved by STONE

Technologies

GSM 900/1800MHz

2.10 GPS Module (Optional)


The STAD070WT-05 is equipped with a GPS-enabled 4G module to
support fast and accurate positioning. If you need this function, you need
to put the GPS antenna in the open space. When you turn on the
Android positioning function, you can get the latitude and longitude
coordinates of the device at this time.

STAD070WT-05 Equipment Manual www.stoneitech.com


Release 01/2019 9
All rights reserved by STONE

Technologies

3 Accessories
3.1 Antenna Selection

Rod antenna FPC antenna 3 meters sucker antenna

3.2 Speaker
Speaker Configuration Details

STAD070WT-05 Equipment Manual www.stoneitech.com


Release 01/2019 10
All rights reserved by STONE

Technologies

Speaker 8R5W 100*45 Speaker 8R5W 100*45 Speaker 4R3W


Stereo Speaker PH2.0-4P Stereo Speaker PH2.0-2P TS7033BOX-01-L350
PH1.25-2P/ Speaker 2040
Cable length 80 cm Cable length 80 cm 4R2W Rectangle Full-band
Mono Speaker
External,Optional External,Optional
Cable length 20 cm

External/Internal,Optional

4 Physical Dimensions

STAD070WT-05 Equipment Manual www.stoneitech.com


Release 01/2019 11
All rights reserved by STONE

Technologies

5
Interna

tional

Certifi

cation

CE Certificate FCC Certificate

STAD070WT-05 Equipment Manual www.stoneitech.com


Release 01/2019 12
All rights reserved by STONE

Technologies

ROHS Certificate ISO9001:2008

6 Naming Rule
This chapter contains the naming rule:

As sample STAD070WC-01

STAD070WT-05 Equipment Manual www.stoneitech.com


Release 01/2019 13
All rights reserved by STONE

Technologies

Code Explain

ST Company Code
AD Android

070 TFT Panel Dimension: 7 inch

W W=Wide Voltage
C=With Capacitive Touch Screen
C T=Tempered GlassTouch Screen
R=Infrared Touch Screen
0 0= Standard Configuration 1= High Configuration

1 1=Without Case 5=Metal Case

Intelligent Customer Online Services


Intelligent Customer Support offers comprehensive additional information of
Intelligent Products through its Online services as follows:

- Official website: https://www.stoneitech.com/

http://www.stone-hmi.com/

- Alibaba platform: http://shuangying-ocean.en.alibaba.com/

http://stonetech.en.alibaba.com/

- Telephone: 0086-10-84351669

- E-mail: info@stone-hmi.com

Other support
In need of technical queries, please contact STONE representatives in the subsidiaries
and branches responsible for your area.

STAD070WT-05 Equipment Manual www.stoneitech.com


Release 01/2019 14

You might also like