Professional Documents
Culture Documents
ns
water applications where long life, high flow rate and low change-out frequency are required.
It’s true-graded density filter matrix captures particles throughout the entire filter depth.
Longer life and lower change out rate guaranteed. Thus lowest cost.
tio
Special Application
Seawater RO pre-filtration
lu
Oil & Gas injection water
So Feature and Benefit
Specification
em
Materials of Construction:
· MS® MicroPure HG Series filters are made of 100% polypropylene materials
Address: 1108 Spring View Lane Plano, TX 75075 Toll free: 1-866-528-4572 Fax: 1-732-412-4040
MS ® FILTER
for Seawater RO Pre-Filtration and Oil & Gas Injection Water
1. Dirt Holding Capacity of MS, M and G Company 2. Flow Rate of MS and G Company
35 3.5
G/A brand
ns
30 3
G/B brand
25 2.5 MS/MicroPure
HG
20 2
tio
15 1.5
10 1
5 0.5
0 0
lu
G/A brand M/A brand MS/MicroPure HG 0 10 20 30 40 50 60 70 80
Filters Flow rate (lpm), water at 20℃ (5μm, 10")
So
Conclusion: MS Filters has better pressure drop then G brand filters, and greater dirt holding capacity than G and M companies, thus
lower energy cost and longer life.
Unit conversion:1bar=100kPa=14.5psi
Flow rate is for a 25.4cm(10inch)cartridge. For liquids other than water,
multiply differential pressure by fluid viscosity (cP)
Recommended Operating Conditions:
From the pictures above, under same conditions, the · Maximum Temperature: 160℉ (70℃)
e
dirt holding capacity of 5µm melt blow filter in MS is · Maximum Pressure: 46psi (3.2bar) @ 85℉ (30℃)
2-3 times greater than G and M companies’ brand, 12psi (0.8bar) @ 160℉ (70℃)
and the flow rate is higher than G Company’s A brand · Recommended change-out pressure:
an
Ordering Information
CRMPP HG
em
End Adapter
Nominal Length Removal Rating Seal Material
M
Configuration
Address: 1108 Spring View Lane Plano, TX 75075 Toll free: 1-866-528-4572 Fax: 1-732-412-4040