Professional Documents
Culture Documents
Anti Scalent For Cooling Tower
Anti Scalent For Cooling Tower
2. COMPOSITION/INFORMATION ON INGREDIENTS
Combination of organophosphonates, anionic polyelectrolites, polyphosphates stabilized
with chelating agents and polymeric dispersing agents as well as corrosion inhibitors
3. HAZARDS IDENTIFICATION
Emergency Overview
Appearance
Inhalation: Non-hazardous
Environmental effects
On the basis of available information, this material is not expected to produce any
significant adverse environmental effects when recommended use instructions are
followed.
5. FIRE-FIGHTING MEASURES
Flash point Noncombustible
Lower explosion limit Not applicable
Upper explosion limit Not applicable
Thermal decomposition >230.00 °C
Environmental precautions
Non-corrosive, non-combustible, non-hazardous material
Eye protection: safety glasses with side-shields. Eye protection worn must be
compatible with respiratory protection system employed.
Hand protection: The glove(s) listed below may provide protection against permeation.
Gloves of other chemically resistant materials may not provide adequate protection):
Neoprene gloves
NOTE: The physical data presented above are typical values and should not be
construed as a specification.
CERCLAInformation(40CFR302.4):
Releases of this material to air, land, or water are not reportable to the National
Response Center under the Comprehensive Environmental Response, Compensation, and
Liability Act (CERCLA) or to state and local emergency planning committees under the
Superfund Amendments and Reauthorization Act (SARA) Title III Section 304.
Pennsylvania
Any material listed as "Not Hazardous" in the CAS REG NO. column of SECTION 2,
Composition/Information On Ingredients, of this MSDS is a trade secret under the
provisions of the Pennsylvania Worker and Community Right-to-Know Act.
Legend
Notice:
This material safety data sheet must be made available to all persons who, by the
nature of their employment, may handle or come into contact with this material.
Disclaimer:
The percentage weight (% w/w) of ingredients is not to be taken as a specification
guaranteed by Maxwell Additive Pvt. Ltd., but only as an approximate guide to the
content of hazardous ingredients in the material. The information contained herein
does not constitute a guarantee by Maxwell Additive Pvt. Ltd. concerning the
properties of the material.
The information contained in this material safety data sheet is offered in good faith
and is correct to the best of our knowledge, information and belief at the date of its
publication. The information given is designed only as guidance for safe handling, use,
processing, storage, transportation, disposal and release and is offered without
warranty, representation, inducement or licence and Maxwell Additive Pvt. Ltd.
assumes no legal responsibility for reliance upon same. Maxwell Additive Pvt. Ltd.
disclaims any liability for loss, injury or damage incurred in connection with the use
of the material or its associated material safety data sheet.