Professional Documents
Culture Documents
Pages - Results Rigola Baie Etaj 1
Pages - Results Rigola Baie Etaj 1
Created on:
29.2.2024
Viega Advantix Vario
Input data
900
1100 1100
Number of drains: 3
Cutting plan
846
4
992
408
1
5 6
2 3
1052 1183 1183 1052
843 843
List of materials
Notes
Only the Vario shower channels and the long standing grates may be shortened during installation. The remaining drain components (end piece,
connector, corner connector, short standing grate) may not be shortened.
If 2 or 3 drains are connected using a collective connection line, the sizing must be DN 70 in acc. with DIN 1986-100 Paragraph 14.1.3.3 and
Table 7, when the expected drainage capacity exceeds 0.8 l/s. The max. drainage capacity of a DN 70 drainpipe is 2.2 l/s.
When shortening the Vario shower channel, the length of 150 mm - from the middle of the drainage to the end of the channel profile - is the
minimum length.
The material/ cutting plan will be calculated automatically based on the data you enter, The software does not replace professional planning. It
merely offers an indication. More importantly, the software cannot take any on-site specific characteristics into account. For this reason, no liability
is accepted for the accuracy or completeness of this material/cutting list.
All of the drainage capacities mentioned are achieved at a water seal height of 10 mm. If it is intended to use the shower drain or the shower
channel at the place of installation with deviating water seal heights, other drainage capacities will be achieved.