Professional Documents
Culture Documents
We provide several different levels obstructed, air that bypasses the filter
of service. This table shows you what may carry dirt directly into the
is included in each level. evaporator coil and impair the coil's
Service level heat-absorbing capacity. Replacing a
Annual dirty, clogged filter with a clean one
boiler can lower your air conditioner's
service energy consumption by 5% to 15%.
Boiler For central air conditioners, filters
and are generally located somewhere
One
Plumbin
g Some types of filters are reusable;
Five
2 /conversion/tmp/activity_task_scratch/735216764.docx
Aun Raza,pk262,22O044 Wednesday, 06 March 2024
the condenser coil and notice if dirt is check for and seal duct leakage in
collecting on its fins. central systems
measure airflow through the
You should minimize dirt and debris
evaporator coil
near the condenser unit. Your dryer verify the correct electric control
vents, falling leaves, and lawn sequence and make sure that the
mower are all potential sources of heating system and cooling
dirt and debris. Cleaning the area system cannot operate
around the coil, removing any debris, simultaneously
inspect electric terminals, clean
and trimming foliage back at least 2
and tighten connections, and
feet (0.6 meters) allow for adequate apply a non-conductive coating if
airflow around the condenser. necessary
COIL FINS oil motors and check belts for
tightness and wear
The aluminium fins on evaporator check the accuracy of the
and condenser coils are easily bent thermostat.
and can block airflow through the
coil. Air conditioning wholesalers DO NOT WAIT FOR PROBLEMS
sell a tool called a "fin comb" that TO OCCUR.
will comb these fins back into nearly
original condition. We have the country covered by
CONDENSATE DRAINS qualified engineers and are in the
process of training new ones. This
Occasionally pass a stiff wire chart shows how we cover the
through the unit's drain channels. regions:
Clogged drain channels prevent a
unit from reducing humidity, and the Regional Coverage
resulting excess moisture may 12
10
e Number of Engineers
3 /conversion/tmp/activity_task_scratch/735216764.docx