Professional Documents
Culture Documents
双向调试Bidirectional Parameter Calibration
双向调试Bidirectional Parameter Calibration
第六步:断开 X 轴电源,缓慢移动车架直到滚轮从玻璃片上移动过去,检查玻璃片受到了撞
击后,将 5 片改为 4 片。如果没有受到撞击,那么将 5 片改为 6 片。
正确的玻璃数量的标准为:受到撞击后,减少一片后的数量为最终的数量。例如 5 片受到撞
击那么 4 为最终的数量。
Step 6: Disconnect the X-axis power supply, slowly move the frame until the roller moves over the
glass sheet, check that the glass sheet has been impacted, and change 5 pieces to 4 pieces. If
there is no impact, then replace 5 pieces with 6 pieces.
The standard for the correct amount of glass is: after the impact, the number of reduced pieces is
the final amount. For example, if 5 pieces are hit then 4 is the final number.
第七步:重新加载打印作业,设置 ID 为 2,进行打印,运动 2pass 后立刻暂停。每个通道运
动 4 次为 4pass。
Step 7: Reload the print job, set ID to 2, print, and pause immediately after moving 2pass. Each
channel moves 4 times for 4 passes.
第八步 :用放大镜检查,一共有 5 条线,每条线的点大小不一致,观察每条线如果错开需
要调节参数
Step 8: Check with a magnifying glass, there are 5 lines, the point size of each line is inconsistent,
observe each line if the staggered need to adjust the parameters
第九步:调节参数直到达到要求
Step 9: Adjust parameters until desired
第十步:检查拼接,打印三通道后暂停观察情况
Step 10: Check the splicing and pause to observe the situation after printing three channels