Professional Documents
Culture Documents
This spare parts catalogue is intended for the personal use of engine
operators and should always be at their disposal. The content of this
manual shall neither be copied nor communicated to a third person.
Wärtsilä Finland Oy
Copyright by Wärtsilä Finland Oy
All rights reserved. No part of this booklet may be reproduced or copied in
any form or by any means (electronic, mechanical, graphic, photocopying,
recording, taping or other information retrieval systems) without the prior
written permission of the copyright owner.
Table of contents
Section Description
100-007D Hydraulic jack for main bearing cap
100-0011M Engine block V32
100-013A Oil strainer for suction pump
100-0021D Cylinder liner with anti-polishing ring
100-0022H Wet sump
100-0030B Cylinder liner fastening equipment
100-0035A Grounding equipment
107-0002D Crankcase cover with relief valve
107-0017G Casing, covers, end plates V32
107-0024I Multi cover, B-bank V32
107-0027I Pump cover V32
107-032B Cover for cylinder head
107-040A Covers between cylinder heads
107-041B Cover for cylinder head
107-057B Side cover V32
107-058A Side cover V32
107-059A Side cover V32
107-061A Side cover V32
107-062B Side cover V32
107-0072C End cover
107-075A Covers between cylinder heads
107-086A Cover for Hot-box end piece
107-0096B Covers 16V32
107-0105A Cover for cylinder head
107-0110A Cover for cylinder head
Page 1 of 8
4.7.2008 Engine Spare Parts Catalogue for SHI 1727 Wärtsilä 32
Section Description
110-0002H Crankshaft V32
110-0004B Vibration damper
111-003A Connecting rod
113-003C Piston
114-0003C Flywheel
Section Description
120-0013J Cylinder head with starting valve
120-0014I Cylinder head without starting valve
120-0015C Cylinder head
120-0025A Cylinder head equipment
121-001B Exhaust valve assembly
121-002B Inlet valve assembly
123-001C Starting valve
125-001C Cylinder head safety valves
125-002B Indicator valve
Section Description
131-0006C Bearing cover for camshaft B-bank
131-0007B Intermediate gears for camshaft drive
Section Description
143-003A Rocker arms and bearing bracket
145-0001G Valve tappet with guide block
Page 2 of 8
4.7.2008 Engine Spare Parts Catalogue for SHI 1727 Wärtsilä 32
Section Description
156-019B Speed pickup for TC
156-056A Vibration measurements points
156-0069C Charge air system
156-0070A Covers for air duct
156-0072E Pulsation damper
156-0075B Turbocharger
156-0106A Drain pipe from receiver
Section Description
161-002C Lifter for injection pump
165-0007C Injection pump
167-001C Injection valve
Section Description
181-004C Lubricating oil pump
181-0005I Lubricating oil pump
182-0005A Prelubricating oil pump
184-004B Oil dipstick
Section Description
191-002K Water pump
196-007B Thermostatic valve for LT water
196-015B Thermostatic valve for HT water
Section Description
200-0026A Exhaust system V32
202-0016C Wastegate system in free end
202-0025B Wastegate pipe
Page 3 of 8
4.7.2008 Engine Spare Parts Catalogue for SHI 1727 Wärtsilä 32
Section Description
211-0001G Starting air distributor
213-0007A Limit switch for stop lever
213-0008A Shut-down mechanism assembly
214-001B Starting blocking device
217-002A Main starting valve
218-007A Air block
Section Description
220-0002A Governor
220-0003A Booster servomotor
223-0002B Booster servomotor
223-0012B Governor drive
223-0015A Booster-motor
224-002A Levers for governor
224-0004D Control shaft, A bank
224-0005F Control shaft, B bank
224-0006D Bearing support for link levers
228-001C Overspeed trip device
228-0010D Air bottle
228-0015E Overspeed trip device
228-016A Overspeed trip device
228-018A Load limiter assembly, hot box
228-0030A Air bottle
Page 4 of 8
4.7.2008 Engine Spare Parts Catalogue for SHI 1727 Wärtsilä 32
Section Description
350-004C Fuel pipes in free end
350-012A Throttle ring for fuel pipes
350-0014C Cover for fuel pipes
350-015A Pressure valve
350-0017B Bracket
350-0051B Fuel pipes
350-053A Fuel system
350-0054B Fuel pipe
350-0074A Fuel pipes in free end
352-008B Lubricating oil pipes in free end
352-013C Oil nozzle for intermediate gears
352-0043D Lubricating oil pipes in free end
352-0054B Lube oil pipes
352-0059A Oil pipe
353-0042A Control air system
354-0014E LT-water pipes in flywheel end
355-046A Cooling water pipes
355-0064A Air vent system, LT water
355-0070A Air vent system from multiducts
355-0072D Air vent system from multiducts
355-0084A Air vent system, HT water
357-016A Air pipes to turning device
357-0022B Starting air pipe
357-0039A Starting air system
358-007A Leak oil pipe, clean, free end
358-0009B Leak oil pipe, dirty, free end
358-010A Leak oil pipe, dirty, flywheel end
358-014A Connection pieces
358-0019C Leak oil system, flywheel end
Section Description
Page 5 of 8
4.7.2008 Engine Spare Parts Catalogue for SHI 1727 Wärtsilä 32
Section Description
470-0002D Filter
471-008A Running-in filter
471-0012A Lubricating oil filter
473-003B Centrifugal filter
474-007A Oil sample valve
474-0013G Lube oil module
474-0014C Fastening for lube oil module
476-0003E Charge air cooler assembly
476-0005C Air cooler
482-004A Sprinkle guards for fuel oil pipes
482-0005D Sprinkle guards for fuel oil pipes
483-0004E Equipment for turning device
483-007A Locking device
483-0008A Turning device
Section Description
504-0028B Temperature sensors
504-0033C Temperature sensor for exhaust gas
504-0059A Sensors for charge air
504-0068B Electrical equipment for air bottle
504-0077A Sensors for charge air
506-015A Load indicator assembly
506-017C Sensors for multicover
506-0068B Sensors for Multicover, A-bank
506-0069A Sensors on pump cover
506-0071A Sensors for starting air system
506-0073A Sensors for control air
Page 6 of 8
4.7.2008 Engine Spare Parts Catalogue for SHI 1727 Wärtsilä 32
Section Description
600-002B Connecting piece for turbocharger/exhaust pipe
604-0041A Accessories for common base plate
604-0052B Lube oil pipes to alternator
800 Tools
Section Description
810-0001A Tools for cylinder liner
810-0002A Tools for main bearings
811-0001A Tools for piston
811-0002A Tools for connecting rod
Page 7 of 8
4.7.2008 Engine Spare Parts Catalogue for SHI 1727 Wärtsilä 32
Page 8 of 8
4.7.2008 Engine Spare Parts Catalogue for SHI 1727 Wärtsilä 32
Alphabetical index
Description Section
Actuator 207-0006A
Air block 218-007A
Air bottle 228-0010D
Air bottle 228-0030A
Air vent system, LT water 355-0064A
Air vent system from multiducts 355-0070A
Air vent system from multiducts 355-0072D
Air vent system, HT water 355-0084A
Air pipes to turning device 357-016A
Air cooler 476-0005C
Adapter and test valve for pressure sensors 507-0090A
Accessories for common base plate 604-0041A
Description Section
Description Section
Page 1 of 8
4.7.2008 Engine Spare Parts Catalogue for SHI 1727 Wärtsilä 32
Page 2 of 8
4.7.2008 Engine Spare Parts Catalogue for SHI 1727 Wärtsilä 32
Description Section
Description Section
Description Section
Flywheel 114-0003C
Flexible hoses and vibration dampers for positioner 207-0008A
Fuel pipes in free end 350-004C
Fuel pipes 350-0051B
Fuel pipe 350-0054B
Fuel pipes in free end 350-0074A
Fuel system 350-053A
Filter 470-0002D
Fastening for lube oil module 474-0014C
Description Section
Page 3 of 8
4.7.2008 Engine Spare Parts Catalogue for SHI 1727 Wärtsilä 32
Description Section
Description Section
Description Section
Page 4 of 8
4.7.2008 Engine Spare Parts Catalogue for SHI 1727 Wärtsilä 32
Description Section
Description Section
Description Section
Page 5 of 8
4.7.2008 Engine Spare Parts Catalogue for SHI 1727 Wärtsilä 32
Description Section
Description Section
Page 6 of 8
4.7.2008 Engine Spare Parts Catalogue for SHI 1727 Wärtsilä 32
Description Section
Turbocharger 156-0075B
Thermostatic valve for LT water 196-007B
Thermostatic valve for HT water 196-015B
Throttle ring for fuel pipes 350-012A
Turning device 483-0008A
Temperature sensors 504-0028B
Temperature sensor for exhaust gas 504-0033C
Terminal box 507-0116B
Terminal box 507-0124B
Tools for cylinder liner 810-0001A
Tools for main bearings 810-0002A
Tools for piston 811-0001A
Tools for connecting rod 811-0002A
Tools for cylinder head 812-0001A
Tools for intermediate gear 813-0001A
Tools for injection equipment 816-0001A
Tools for turbocharger 837-0001B
Description Section
Page 7 of 8
4.7.2008 Engine Spare Parts Catalogue for SHI 1727 Wärtsilä 32
Description Section
Page 8 of 8
WFI-S
Page 1/8
200446
Table of Contents
1. General
2. Table of Contents and Alphabetical Index
3. Spare Parts Sections and Interleaves
3.1 General
3.2 Spare Parts Section
4. Instructions for Ordering Spare Parts
4.1 Mechanical Equipment
4.2 Electrical Equipment
4.3 Original Spare Parts
4.4 Order Spare Parts Online
4.5 Ordering
5. Updating of the Spare Parts Catalogue
WFI-S
Page 2/8
200446
1. General
The Spare Parts Catalogue is individually collated and specific for the installation and
engine number(s) stated in the flyleaf of this catalogue.
When compiling this Spare Parts Catalogue the demands for interchangeability
as well as former experiences of adaptability have been considered. Simple
components are normally supplied as complete units. However, details exposed to
wear may be supplied separately.
The customer will get information about prospective modifications and changes in the
specifications when needed through the Service Bulletins. When modifications are
made into the engine by the customer, the nearest Wärtsilä Service Office must
always be informed about the changes in order to update the spare parts database etc.,
see section 5, Updating of the Spare Parts Catalogue.
Regarding spare parts for some of the sub suppliers components, e.g. governor, we
refer to lists in the special instructions enclosed the documentation set. Tools needed
for repair or maintenance of the engine and special equipment are to be found in the
Instruction Manual for this engine.
Wärtsilä is continuously developing the products and reserves all rights to make
technical changes and modifications without any notification in advance.
The Spare Parts Catalogue contains a Table of Contents and an Alphabetical Index.
The Table of Contents the sections are in section number order and in the
Alphabetical Index in section name order.
3.1 General
The Spare Parts Catalogue is divided into 15 chapters according to contents by using
interleaves. Chapters are further divided into “Sections” to offer a detailed view of
parts needed. A section can contain one or several pages, which are numbered 1, 2, 3
etc. The section number is located on the right side of the headline. A section number
is build up of a three digit main group number and a two to four digit running
number, e.g. 100-0002.
For a specific engine the section numbers will not be consecutive.
Note! The format and location of the section number, page number and edition may
vary in older sections between different engine types due to modification of the
layout and content.
WFI-S
Page 3/8
200446
3.2 Spare Parts Section
The upper part of the page is used for the illustration showing a detailed picture of the
parts and the lower part of the page is used for the list of spare parts in the illustration.
The spare parts section can consist of single parts, assembly units and spare parts kits
and/ or sealing sets. If spare parts kits and/ or sealing sets are available, they are
normally enclosed as the last page in a section, please note that normally the parts
within these are not sold separately.
Note! The Remarks/ Notes on the spare parts page indicate if the Part No. can be
ordered separately or is included in a spare parts kit only.
The part numbers can appear on three different levels. The following, indented sub
level indicates that the spare parts is included in the previous part number of higher
level. In other words, when there is a frame (15) around a group of parts, it indicates
that all the parts with the part number inside the frame (Sub level) can be ordered by a
single part number (Highest level). This number will point to the frame, see figure on
page 4.
Alternative constructions (e.g. older version) may be described in the same section
marked with “Alternative design”.
Some sections include references to other sections, e.g. See Section 181- (to which
the section in question is related) where connected parts or assemblies can be found.
The development process may bring improvements causing modifications and
changes to the engine. If the validity of the assembly units as spare parts does not
change there is not necessarily any need for a new spare parts section.
If the number of the pages of a section is uneven, the last page is blank (left hand
page). It includes e.g. the following text “This page is intentionally left blank”.
WFI-S
Page 4/8
200446
The information presented in the spare parts sections are shown in the example
figure below:
13
XXXXXXX XX Spare Parts List 181-0010
8 Edition: A 7
Page: 1(1)
09.06.2004
Regulating valve 10
12 5
9 9
15
6
2
3 Part No. Description
Qty Wt.
[Pcs] [Kg] Part No. Description
Qty Wt.
[Pcs] [Kg]
1. Qty = Quantity
The quantity (in pieces) that are normally needed for the assembly of the parts in the
illustration.
Note! The number of pieces only indicates the necessary quantity for the shown
assembly, not for the entire engine.
Total quantity of a certain part is sometimes given in a table at the end of the section.
Note! These numbers do not represent the quantity delivered as the quantity must be
specified when placing an order.
Thin pipes (Ø 10 mm or thinner) and most of the electric cables may all be found
under the same part number. This is due to the fact that these are delivered unbounded
as metric goods. Even in these cases the quantity is “pcs” in the Spare Parts
Catalogue. We recommend you to mention the length in meters when ordering. The
quantity information can be missing in some sections.
4. Sub level
See position 3 above.
5. Date
Release date of the section edition concerned.
6. Description
General description for the part.
7. Edition
The edition letter (A, B, C, and so on) indicates the state of change.
8. Engine type
Engine type concerned.
10. Page No
A section can contain one or several pages, which are numbered 1, 2, 3 etc.
Example 1(2), the number in parentheses stands for the total number of pages of the
section.
11. Remarks
A number within brackets, i.e. (1), will appear after the description of the part when
there is a special remark for this part and further information is given either at the
bottom of the page or in the “Remarks” area of the section.
13. Section No
Identification number for the section, e.g. 100-0002.
Note! When ordering pipes with flange connection for different systems, some of these
will be delivered as unwelded due to that fact that these are designed to be welded
when being assembled.
The reason is that in this way the bending tensions are minimized and individual
differences in connection to components and/ or other pipes are neutralized which
also makes the assembly work easier.
The quality of parts is essential – only original parts guarantee reliability. All original
parts have passed through extensive laboratory and field tests. Certain parts are
manufactured under the supervision of the classification societies and then supplied
with corresponding certificates. In line with Wärtsilä’s commitment to environmental
issues, we are also among the first to utilise IMO-codification of engine parts to
comply with the modified IMO regulations.
Note! Spare parts orders must be based on the part numbers for the engine(s)
concerned, please refer to the installation specific Spare Parts Catalogues
delivered with the engine(s) concerned.
In order to make possible prompt delivery of spare parts, please always state the spare
parts number and the name of part according to this catalogue as well as the engine
type and the engine number when ordering. These statements are to be found on the
engine name plate.
When ordering special equipment or some other part not included in this catalogue or
in the Instruction Manual, please give the manufacturer’s type designation and the
serial number of the part. In case such an indication is missing, the part should be
described as clearly as possible or, preferably, a sketch should accompany the order.
The name of the consignee and the purchaser and their exact addresses as well as the
method of forwarding should be stated. All orders given by telephone should be
confirmed by email or fax. The parts required should be ordered direct from Wärtsilä
or our nearest agent.
Addresses as well as our telephone numbers are given on the appendix called “Any
time” at the beginning of this catalogue and in our website www.wartsila.com.
When modifications are made to the engine by the customer, the Wärtsilä Service
Network must always be informed about the changes in order to update the spare
parts database. This enables us to deliver the necessary spare parts with minimum
time, effort and to ensure correct deliveries. However, it also enables us to deliver the
Spare Parts Catalogue updates, if needed.
Update delivery includes a covering letter telling you which sections you should add
and/ or replace in the Spare Parts Catalogue(s) concerned. Please note that with the
update delivery you will also get an updated Table of Contents and an Alphabetical
Index. The Table of Contents describes which sections you should have in your
catalogue. The date located on the top left side of the each page indicates the version
of the index.
Wärtsilä 32 Spare Parts List 100-007
Edition: D
Page: 1(3)
Updated: 15.10.2001
Hydraulic jack for main bearing cap
387 004
100 138
100 040
100 141
100 134
100 137
100 136
100 140
100 127
100 082
100 130
100 132
100 129
100 135 100 128
100 126
100 139
100 068
100 131
100 125
100 136
100 131
100 130
100 133
100 140
100 139
100 127
100 126
100 130
100 129
100 142
100 128
100 131
X
100 103 100 222
100 186
100 102
100 185
100 100
100 008
100 187 100 238
100 107 100 184
387 018 100 239
Qty Wt. Qty Wt.
Part No. Description [Pcs] [Kg] Part No. Description [Pcs] [Kg]
100 001 Engine block 1 -
100 007 Main bearing shell, upper * -
100 008 Main bearing shell, lower * -
100 028 Thrust bearing 4 -
100 100 Pin 4 -
100 102 Screw * -
100 103 Screw 6 -
100 107 Main bearing cap 1 -
100 184 Main bearing cap * -
100 185 Screw 8 -
100 186 Guiding washer 4 -
100 187 Sealing push-in cap * -
100 222 Plug (1) 4 -
100 223 Sealing ring (1) 3 -
100 238 Blind flange * -
100 239 Screw * -
387 018 Glue compound 1 -
.
NOTE! (1) Not used in all installations.
NOTE! * See page 5.
100-0011 Spare Parts List Wärtsilä 32
Edition: M
Page: 2(5)
Updated: 17.03.2008
Engine block V32
100 166
387 018
100 104
100 188
100 189
100 286
100 157
100 165
A
B
A
B
100 015
100 027
100 097
100 025
Section B-B
100 194
100 005
Pieces Pieces
Part No 12V32 16V32 18V32 20V32 Part No 12V32 16V32 18V32 20V32
100 005 12 16 18 20 100 102 76 98 112 124
100 007 8 10 11 12 100 104 33 45 51 60
100 008 8 10 11 12 100 166 14 18 20 22
100 010 64 84 94 104 100 184 7 9 10 11
100 013 16 20 22 24 100 187 16 20 22 24
100 015 16 20 22 24 100 238 14 18 20 22
100 017 16 20 22 24 100 239 28 36 40 44
100 024 48 64 72 80
100 025 48 64 72 80
100 027 16 20 22 24
100 097 16 20 22 24
100 002
100 003
A
100 110
100 023
100 115
100 113
387 038
100 087
100 040
A B
100 047
100 039
E 100 039
100 044
E
100 045
100 084
100 087
100 203
100 051 100 091
387 006 100 090
100 217 100 067
100 064
100 036 100 202
100 088
100 084
100 038
100 059 100 039
Pieces
Part No 12V32 16V32 18V32
100 040 26 30 32
100 051 12 12 12
100 067 44 56 62
100 068 16 20 22
100 082 8 10 11
100 087 32 40 44
100 090 9,61m 11.85m 12,97m
100 131 24 30 33
100 202 44 56 62
100 213 16 20 22
100 240 16 20 22
471 123 16 20 20
100 112
100 193
100 237
V-Engine
100 249
100 247
100 247
Alternative location
100 247
100 248
L-Engine
100 247
100 248
100 249
Alternative location
100 247
100 248
107 014
107 016
107 013
377 001
377 002
107 664
107 009
107 014
377 002
107 538
377 001
107 016
107 015
107 112
107 035
107 018
107 027
107 114
107 030
107 518
B-bank
107 043
107 018
107 273
107 027 107 018
107 518
107 013
107 018
See 107-
107 026
107 030
A
107 041
107 115
107 018
107 274
107 041 107 030
Section A-A
107 030 107 041
107 274
107 274
107 390
A
107 377
A
107 385
107 440
107 439
107 370
107 389 107 391
107 374
107 375
107 376 107 447
107 532 107 368 107 387 387 018
Section A-A
107 378
387 001 107 385
350 134 387 026 107 439
107 329
107 431 107 307 107 333 107 325
107 431
107 329 E
A 107 332
C
107 096
D
107 060
473 116 A
D
107 339
107 060
107 322
107 339 B
107 095
F
107 316 F
107 321 107 095
107 323 107 308 107 324 107 325 107 309 107 067
107 333 107 327 107 096
107 305
107 655 473 116 107 306
107 330 107 309
107 343 107 327
107 344
107 655
107 315
107 304
107 320
107 328
107 341
387 025
107 342 107 315
107 418
107 320
107 419
107 315
107 315
107 320
107 320
387 025
107 539 107 316
387 025
107 317 107 540 107 321
107 087
107 318
G
107 335
107 312
107 312
107 068
107 071
Section A - A Section B - B
107 324
107 323
107 095
107 313
107 336
107 317
107 313
107 311
107 094
See page 7
107 316
107 310
107 321 107 438
Section C - C
Section D - D Section E - E
107 060 107 326
107 309
107 319
107 429
107 335
107 430
107 331
Section F - F
Section G - G Item H
107 337
107 338
107 064
107 104
107 177
107 094
107 178
107 177
107 149
A A
Section A-A
107 138
107 143
107 002
107 359
107 362
107 436
107 365
107 360
107 521
or 107 524
A A
107 525
107 145
107 146
Section A-A
107 138
107 143
107 002
See page 3
107 166
107 173
A
107 165
107 486 107 252
See page 4
See 107-
107 162
107 163
107 164
107 162
107 163
107 158
View A
107 160
107 487
107 489
107 160
107 491
107 487
107 490
107 491
107 276
107 157
107 481
107 153
107 495
107 494
107 493
107 165
107 492
See page 3
107 166
107 173
A
107 165
107 486
See page 4 107 132
107 162 See 107-
107 163
107 164
107 162
107 163
107 158
View A
107 160
107 487
107 489
107 160
107 491
107 487
107 490
107 491
107 278
107 157
107 481
107 153
107 495
107 494
107 493
107 165
107 492
See page 3
107 166
107 173
A
107 165
107 486
See page 4 107 247
107 162 See 107-
107 163
107 164
107 162
107 163
107 158
View A
107 160
107 487
107 489
107 160
107 491
107 487
107 490
107 491
107 282
107 157
107 481
107 153
107 495
107 494
107 493
107 165
107 492
See page 3
107 166
107 173
A
107 165
107 486
See page 4 107 242
107 162 See 107-
107 163
107 164
107 162
107 163
107 158
View A
107 160
107 487
107 489
107 160
107 491
107 487
107 490
107 491
107 280
107 157
107 481
107 153
107 495
107 494
107 493
107 165
107 492
See page 3
107 166
107 173
A
107 165
107 486 107 021
See page 4
See 107-
107 162
107 163
107 164
107 162
107 163
107 158
View A
107 160
107 487
107 489
107 160
107 491
107 487
107 490
107 491
107 152
107 157
107 481
107 153
107 495
107 494
107 493
107 165
107 492
107 047
107 414
107 045
107 047
107 516
107 416
107 515
107 704
107 180
387 031
107 179
107 359
107 362
107 361
107 236
107 360
107 243
107 550
107 551
107 236 107 505 107 363 107 132 107 505 107 363
107 243 107 121 107 121 107 121 107 121
107 021
A-Bank
107 365
107 243 107 242
107 595 107 363 107 132 107 505 107 595 107 363
107 121 107 121 107 121 107 121 107 121
107 505
107 364
107 121
107 121
107 001
107 121
107 247
B-Bank
107 145
A A
Section A-A
107 140
107 139
107 141
107 142
107 003
107 138
107 143
107 002
107 596
A A
107 145
Section A-A
107 138
107 143 set 120 015
107 606
107 603
107 606
See 107-
107 605
107 519
A 107 189
B 107 512
107 190
107 218
Alternative design
107 111
B
107 206 107 607
107 227
107 291
Section B-B
View A
107 512
350 602
387 018
12V32
107 285
107 284
107 207
107 208 107 210
107 220
107 187
107 221
See 211-
107 613
16V32
107 198
107 284
107 195
107 196
107 231
107 194 107 197
18V32
C
107 284
107 211
107 208
107 195
107 209
107 231
107 196
107 188
107 194
107 187
107 232
See 211-
107 220
107 221 107 197
20V32
107 292 View C
107 286
107 284 C
107 546
107 544
107 508
A
107 256
A-Bank
B-Bank
107 654
107 246
107 652
107 263
107 698
107 263
107 268 107 549
107 699
107 622
107 701
107 269
107 700 107 701
107 734
107 260
107 272
107 246
Flywheel end
110 022 A
110 032 110 005
110 026
110 033
Alternative design
Section A - A
110 002
110 004
110 021
110 003
Free end
110 014
110 027
110 028
110 018
110 013
Pieces
Part No 12V32 16V32 18V32 20V32
110 002 12 16 18 20
110 003 24 32 36 40
110 004 24 32 36 40
110 005 14 18 20 22
110 018 18 18 12 18
110 021 24 32 36 40
110 027 - - 6 -
110 028 - - 1 -
110 067
110 066
110 013
110 074
111 011
111 006
111 015
111 010
111 005
111 002
111 011
111 012
111 003
111 013
111 010
111 013
111 003
111 004
111 013
111 012
111 002
111 004
111 015
111 013
111 005
111 003
113 001
113 003 113 002
113 012
113 004
113 005
113 006
113 014
113 008
113 015
113 010
113 009
113 011
113 001
113 003
113 012
113 004
113 002
113 005
113 014
113 006
113 010
113 011
113 015
113 009
113 008
114 001
114 002
114 017
A
114 004
114 005
114 003
View A
18 1 2
17 3
16 4
15 5
14 6
13 7
12 8
11 10 9
* 114 002 * 114 004
Engine type Location of
Number of Number of
fitted bolts
fitted bolts normal screws
12V32 1, 4, 7, 10, 13, 16 6 12
16, 18V32 1, 3, 6, 8, 11, 13, 15, 17 8 10
Alternative design
* 114 002 * 114 004
Engine type Location of
Number of Number of
fitted bolts
fitted bolts normal screws
12V32 1, 4, 7, 9, 12, 15, 17 7 11
16V32 1, 3, 5, 7, 9, 11, 13, 15, 17, 18 10 8
18V32 1, 3, 5, 7, 8, 9, 11, 13, 15, 17, 18 11 7
120 003
167 011 120 080
167 060
167 047
167 059 120 001
167 048
167 003
120 032
See 143-
143 001
167 011
167 047
167 048
167 005
167 001
167 003
123 001 167 058
123 003
120 084
See 125-
120 040
120 019
120 039
B A
*
120 043
View A View B
145 023 120 024
120 085
387 017
120 121
120 122
Alternative design
145 014
120 028
120 003
200 067
120 084
107 143
107 002
200 018
120 015
120 052
120 024
120 023
123 010
(2) 167 001 167 004 (4)
120 054
167 049
167 006
121 001 Ex
167 001
121 007 In
120 003
167 011
See 121-
167 060
167 047
167 059
167 048 120 075
167 003
120 032
See 143-
143 001
167 011
167 047
167 048
167 005
167 001
167 003
123 020 167 058
123 003
120 084 set 120 015
125 011
143 010
120 035
See 143-
120 036
120 046
125 010
B A
120 043
View A View B
387 017
120 121
120 122
120 003
200 067
120 084
107 143
107 002
200 018
120 015
120 052
120 024
120 023
123 010
(2) 167 001 167 004 (4)
120 054
See 121-
A See 121-
120 050
120 007
387 026
120 013
120 014
120 050
387 026 120 060
387 026
120 005
120 017
120 025
120 053
387 026
120 021
120 049
120 013
120 050
387 026
120 014
120 050
387 026
387 026
120 053
120 005
387 026
120 017
120 022
120 021
387 026
Qty Wt. Qty Wt.
Part No. Description [Pcs] [Kg] Part No. Description [Pcs] [Kg]
120 005 Cylinder head 1 -
120 007 Yoke pin 2 -
120 013 Valve guide 4 -
120 014 Sealing push-in cap 6 -
120 017 O-ring 2 -
120 021 Seat ring for inlet valve 2 -
120 022 Seat ring for outlet valve 2 -
120 049 Sleeve 1 -
120 050 Sealing push-in cap 13 -
120 053 Sealing push-in cap 8 -
121 001 Exhaust valve, compl. 2 -
121 007 Inlet valve, compl. 2 -
387 026 Glue compound 1 -
Wärtsilä 32 Spare Parts List 120-0015
Edition: C
Page: 3(3)
Updated: 22.01.2007
Cylinder head
120 048
387 026
145 001
145 002
167 012
See 167-
121 002
121 015
121 003
121 016
121 013
121 014 121 001
121 005
121 004
121 006
121 003
121 015
121 013
121 014
121 004
121 008
121 015
121 009
121 016
121 013
121 014 121 007
121 011
121 010
121 012
121 009
121 015
121 013
121 014
121 010
123 008
123 001
123 009
123 009
125 010
120 034
120 035
125 001
120 033
125 003
125 004
125 005
120 044
125 001
120 034
120 033
125 004
120 035
125 003
125 005
120 044
125 011
131 078
A B
131 070 131 026
131 063
131 073
131 074
131 063
View A
Section B-B
B
B
131 076
131 065
131 075
131 025
131 026
131 003
131 066
131 006
131 074
131 071 131 027 131 005
387 017
Qty Wt. Qty Wt.
Part No. Description [Pcs] [Kg] Part No. Description [Pcs] [Kg]
Wärtsilä 32 Spare Parts List 143-003
Edition: A
Page: 1(2)
Updated: 10.10.2000
Rocker arms and bearing bracket
143 001
143 003
A
143 002
143 010 Ex
143 014 In
143 007
143 013
143 009 In
Section A-A
143 018
143 006
143 001
143 017
143 016
145 001
145 002
145 020
145 018
145 018
145 024
387 017
145 021
145 022 Section A-A
145 023
145 025
145 008
A
145 040
145 010
145 028 145 027
145 026
387 017
145 006
A 145 009
145 029
145 021
145 023
145 024 145 022
145 025
145 008
145 027
145 026
145 009
145 006
145 029
145 008
145 029
145 030
145 009
145 026
145 006
B-Bank
148 073 148 003 148 068
148 004
148 069
148 023
148 039
148 066
148 001 ccw
148 003 148 006 148 060
148 002 cw
148 023
148 001 cw A-Bank
148 003 148 002 ccw 148 004
148 018
148 073 148 023 148 007 148 061
148 010
148 069
148 013
148 059
148 026
148 003 148 006 148 003 148 060
148 024 148 027
148 023 148 023
A-Bank
148 007
148 073
148 001 cw
148 024
148 069 148 023 148 006
148 061
Qty Wt. Qty Wt.
Part No. Description [Pcs] [Kg] Part No. Description [Pcs] [Kg]
148 001 Camshaft piece (1) * - NOTE! (2) B-Bank 148 002 cw. rot., 148 001
148 002 Camshaft piece (2) * - ccw. rot.
148 003 Snap ring * - NOTE! * See page 5
148 004 Drive gear 2 -
148 006 Screw * 0.2
148 007 Nut * -
148 010 Gear 1 -
148 013 Screw * -
148 018 Screw 4 -
148 023 Guide pin * -
148 024 Starting air cam 1 -
148 026 Extension 1 -
148 027 Extension 1 -
148 059 Screw 1 -
148 060 Nut 2 5.6
148 061 Thrust bearing 1 -
148 069 Weight 2 -
148 073 Screw 12 0.3
.
NOTE! (1) A-Bank 148 001 cw. rot., 148 002
ccw. rot.
Wärtsilä 32 Spare Parts List 148-0014
Edition: A
Page: 3(5)
Updated: 09.06.2005
Camshaft V32
B-Bank
148 073
148 001 ccw
148 002 cw
148 068
148 039 148 004
148 066
148 060
A
148 043 148 041 148 043 148 041
148 033 148 034 148 036 148 035 148 034
B
148 034 148 035 148 036 148 034
18V32
148 044 148 034 148 036 148 035 148 034
A
148 034 148 035 148 036 148 034
ITEM X
SE 518
SE 528
156 382
With silencer
156 647
156 648
156 648
156 649
156 648
156 649
156 648
156 649
Pieces
Part No Silencer Air suction branch Axial air housing
156 647 1 - -
156 648 2 2 1
156 649 1 2 1
156 119
156 120
156 556
156 559
156 128
156 559
156 534
156 538
156 119
156 120
156 541
156 557
156 559
Qty Wt. Qty Wt.
Part No. Description [Pcs] [Kg] Part No. Description [Pcs] [Kg]
156 039 O-ring 2 -
156 119 Screw 16 -
156 120 Washer 16 -
156 158 Bracket 1 -
156 184 O-ring 2 -
156 533 Screw 22 -
156 534 Nut 22 -
156 535 Screw 20 -
156 537 Air duct 1 -
156 538 Screw 8 -
156 541 Cover 1 -
156 553 Cover 1 -
156 557 Screw 43 -
156 558 Screw 62 -
156 559 Washer 49 -
156 815 Screw 26 -
Wärtsilä 32 Spare Parts List 156-0069
Edition: C
Page: 3(6)
Updated: 06.03.2008
Charge air system
156 557
156 559
B
156 625 B
View A
A
Section B-B
156 554
156 559
156 110
156 034
156 026
387 025
156 131
156 560
387 025 A
156 549
Section A-A
156 544
156 550
156 539 156 131
156 131
156 904
156 560
156 546
156 131
156 558
156 904
156 545
387 025
156 708
156 707
156 544
156 705
156 547
156 556
156 130
387 025
156 551
156 580
156 581
156 712
156 713
156 714
156 715
156 728
156 846
156 716
156 028
SE 518
156 638 SE 528
See page 2 See 156-
156 638
156 495
156 615
156 615
156 616
156 899
156 900
156 898
161 016
161 022 161 001
161 009
161 006 350 125
161 002
161 023
161 003
387 020
161 004
161 020
161 014
161 009
161 022
161 008
161 003
161 011
161 004
161 012
161 021
350 125
161 014
161 022
165 058
165 002
165 059
165 083 165 024
165 053 165 084
See page 3
165 088
165 008 165 037
165 025 165 010
165 023
165 063 *
165 017 *
165 064 *
165 055 *
165 074
165 084
165 002
165 024 165 088 165 011 *
165 084
165 058 165 083
165 017 *
165 053
165 059
165 008 165 061 165 054 *
165 064 *
165 057 *
Qty Wt. Qty Wt.
Part No. Description [Pcs] [Kg] Part No. Description [Pcs] [Kg]
165 002 Screw 6 0.1 165 071 Sealing ring 1 -
165 008 Erosion plug 2 0.2 165 074 O-ring 1 -
165 010 Plug 1 - 165 083 Pin 1 -
165 011 Spring plate * 1 - 165 084 Support ring (1) 2 -
165 017 Spring * 1 - 165 085 Plug 1 -
165 023 Pump element 1 - 165 086 Sealing ring 1 -
165 024 Sealing ring 1 - 165 088 Seal (1) 1 -
165 025 Sealing ring 2 - .
165 029 Control sleeve 1 0.6 NOTE! * See page 7
165 067 Pin 1 - NOTE! Spare parts marked (1) cannot be
165 053 Screw 2 - ordered separately.
165 054 Holder * 1 0.5 NOTE! Spare parts marked * cannot be
165 055 Retaining ring * 1 - ordered separately. Only as a set 165
165 057 Screw * 6 - 119.
165 058 Screw 8 -
165 059 Pump cover 1 -
165 061 Retaining ring 1 -
165 062 O-ring 1 -
165 063 Snap ring * 1 -
165 064 O-ring * 1 -
165 065 Flange 1 -
165 066 Push rod 1 -
Wärtsilä 32 Spare Parts List 165-0007
Edition: C
Page: 3(8)
Updated: 14.02.2005
Injection pump
165 053
165 084
165 062
165 025
165 023
165 010
165 085
165 061
165 086
165 075
165 059 165 001
165 013
165 076
165 037
165 077
165 072
165 073
350 125
165 059
165 078
165 068
165 075
228 011
165 119
350 125
165 062
165 064
358 023 165 024
165 025
165 008 165 084
350 134
165 088
165 071
358 022
165 080
167 007
167 049
167 006
167 008
167 011
167 046
167 005
167 047
167 048
167 020
167 049
167 006
167 046
167 020
167 008
167 047
167 048
167 050
167 018
167 057
167 052
167 053
167 051
167 014
167 046
167 013
167 057
167 050
167 051
167 053
167 013
167 052
167 017
167 021
182 015
181 001
See 181-
182 016
182 017
609 001
182 018
See 182-
182 003
182 005
181 013
181 039
181 040
Alternative design
181 040
A 181 013 181 242
181 047 Counter-clockwise
Alternative design
181 041
181 042
Section A-A
181 044
181 045
181 047
181 046
181 048
181 245
181 246 181 012
181 007
181 037
181 009
181 010
181 008
181 011
181 003
181 006
181 005
181 036
181 044
181 045
181 042
181 046
181 047
181 007 181 036
181 008
181 006
Section B-B
181 041
181 044
181 045
181 048
181 046 181 042
181 038
182 003
181 009
182 029
Section A-A
182 020
182 023
182 051
182 027
182 026
182 025
B
B
Qty Wt. Qty Wt.
Part No. Description [Pcs] [Kg] Part No. Description [Pcs] [Kg]
182 020 Key 1 -
182 023 Seal 1 -
182 025 Gear shaft 1 -
182 026 Drive gear shaft 1 -
182 027 O-ring 1 -
182 038 Bearing bush 4 -
182 051 Housing 1 -
182 052 Bracket 1 -
182 063 Distance sleeve 1 -
182 146 Distance sleeve 1 -
Wärtsilä 32 Spare Parts List 182-0005
Edition: A
Page: 3(5)
Updated: 14.03.2007
Prelubricating oil pump
182 022
C
182 064
Section B-B C
182 041
182 045
182 053
182 054
182 040
Section C-C
182 066
182 062
352137
182 027 182 054
182 003
184 016
184 018
184 017
184 006
184 005
191 018
191 017
191 015
191 002
191 017
191 052
191 043 191 055
191 093
191 044
191 053
191 019
*)
191 013
191 042
191 006
191 080
387 020
191 005 191 054
191 093
191 013
191 009 191 003 191 019 *) 191 007 191 012 191 052 191 054
191 003
191 008
107 064
191 051
191 007
A
196 276 196 287
196 013
196 018
196 279
196 001
196 042
196 043
196 281
SECTION A - A
107 098
196 015
196 014
196 016
196 021
196 017
196 015 107 098 196 021 196 013 196 018
A
196 276
196 286
196 415
196 416
196 279
196 282
196 042
196 043
196 417
387 030
A
Section A - A
196 321
107 098
387 017
196 044
196 014
196 016
196 021
196 017
196 321 107 098 196 021 196 415 196 416
196 044
200 009
200 011
200 029
200 077 200 078
200 076 200 003
B 200 111
200 112
200 112
A
200 113
200 080
200 084
200 085
200 336
View A
200 055 200 054
200 017
200 020
set 120 015 200 018
200 022
View B
Pieces Pieces
Part No 12V32 16V32 18V32 Part No 12V32 16V32 18V32
200 003 12 16 18 200 023 48 64 72
200 009 144 192 216 200 025 12 16 18
200 011 144 192 216 200 028 12 16 18
200 013 12 16 18 200 029 24 32 36
200 014 10 14 16 200 054 10 14 16
200 015 10 14 16 200 055 20 28 32
200 017 48 64 72 200 056 22 30 34
200 018 12 16 18 200 057 40 56 64
200 019 36 48 54 200 067 24 32 36
200 020 84 112 126 200 079 10 14 16
200 021 48 64 72 200 092 12 16 18
200 022 24 32 36 200 336 40 56 64
202 052
202 147
202 055
202 017
202 155 202 153
202 004
202 157 202 155
View A
202 004
202 181
202 062
202 152 202 015
202 053
202 014
202 009
202 149
202 150
202 006 202 173 202 175 202 176
202 176 202 178
202 174 202 177
202 177 202 179
205 246
205 212
205 214
202 004
205 115
205 116 See 202-
205 221
205 223
205 233
A View A
205 225
205 227
205 221 205 062
205 243
205 223 205 224
205 246
205 214 205 217
205 062 205 225
205 115 205 221
205 216 205 224 205 227
205 225 205 060
205 220
205 116
205 080
205 226
205 070
205 219
205 237
205 079
205 238
205 198
205 236
205 192
205 243
205 081
205 246
205 215
205 308
205 235 205 239 205 234 205 225 205 225
205 244 205 228
Qty Wt. Qty Wt.
Part No. Description [Pcs] [Kg] Part No. Description [Pcs] [Kg]
205 049 Upper protecting panel 1 - 205 239 Upper protecting panel 1 -
205 070 Cover profile 2 - 205 243 Washer 26 -
205 079 Screw 4 - 205 244 Screw 4 -
205 080 Upper protecting panel 1 - 205 246 Screw 18 -
205 081 Lower protecting panel 1 - 205 308 Screw 2 -
205 115 Screw 20 -
205 116 Washer 31 -
205 121 Upper protecting panel 1 -
205 192 Cover profile 1 -
205 198 Pin 4 -
205 215 Lower protecting panel 1 -
205 218 Upper protecting panel 1 -
205 219 Upper protecting panel 1 -
205 220 Upper protecting panel 1 -
205 225 Washer 13 -
205 226 Screw 16 -
205 228 Screw 3 -
205 234 Lower protecting panel 2 -
205 235 Insulating box 1 -
205 236 Insulating box 1 -
205 237 Upper protecting panel 1 -
205 238 Upper protecting panel 1 -
Wärtsilä 32 Spare Parts List 205-0106
Edition: B
Page: 1(3)
Updated: 13.06.2007
Insulation box
205 022 205 001 205 022 205 026 205 022 205 026
205 016
205 073
207 947*
207 948*
207 946*
207 930
207 953*
207 952*
207 951*
207 957*
207 963*
207 959*
207 949*
200 334
207 961*
207 950*
207 958*
207 960*
207 962*
207 939*
207 942*
207 943*
207 944*
207 940*
207 940*
207 945*
207 941*
207 938*
207 937*
207 936*
207 934**
207 935*
207 964**
207 933*
207 947*
207 929 207 930
207 948*
207 946*
207 960*
207 934**
207 940*
207 935*
207 945*
207 941*
207 938* 207 932
207 937*
207 936* 207 933*
207 944*
207 939*
207 800
207 992
207 904*
207 904*
207 908*
207 910*
207 1099*
207 1087*
207 1100* 207 1088*
207 1101*
207 1089*
207 1102*
207 1090*
207 1103*
207 1092*
207 1104*
207 1096* 207 1091*
207 1105* 207 1088* 207 1111
207 1094*
207 1095*
207 1093*
207 1108*
207 1109*
207 1110*
207 1102*
207 1093*
207 1098*
207 1106
207 1093* 207 1101* 207 1096* 207 1098* 207 1097*
207 1094*
207 1090* 207 1089* 207 1087* 207 1105* 207 1092* 207 1104* 207 1103*
207 1091*
207 1088*
207 1112
207 1113
207 1051
211 004
211 003
211 002
211 014
211 010
211 012
211 009
211 016
211 006 107 187
211 008
211 017
211 007
211 001
211 002
211 010
211 004
211 014 211 012
211 003
211 016
211 009
Pieces
Part No 6L32/12V32 7L32 8L32/16V32 9L32/18V32
211 001 6/12 7 8 9
211 006 6/12 7 8 9
211 007 6/12 7 8 9
211 008 6/12 7 8 9
211 017 6/12 7 8 9
L-engine
GS 171
V-engine
213 003
213 025
213 009
213 022
213 009
213 022 GS 171
213 003
213 025
213 002
213 001
213 013
213 011
A
213 018
213 014
213 020
213 002
213 013
213 008
213 011 213 035
213 018
213 006
213 007
213 015
213 012 213 007
213 016 213 021
213 035
213 020
213 014
213 002
213 030
213 029
213 030
213 026
213 032
213 031
213 029
214 007
214 004
214 001
214 006
357 050
ALTERNATIVE DESIGN
214 007
217 044
See page 3
217 014
217 028
217 025
217 027
217 003
217 014
217 028
217 044
217 029
217 024
217 010
217 004
217 003
217 027
217 002
217 013
217 040
217 041
217 019 217 038
217 036
217 035
217 044
217 042
217 033
217 021
217 039 217 034
217 031
217 042 217 021 217 040 217 031 217 039 217 019 217 038
A
217 041
217 013
A 217 034 217 036
SECTION A-A
217 023
217 012
217 046
217 039
218 134
A-bank
A B
218 130
218 132
A
View A 218 135
218 131
set 120 015 218 136
B-bank
357 133
218 139
218 141
357 132
218 133
218 140
218 150
357 021 357 229
357 130
357 131
Pieces
Part No 12V32 16V32 18V32
218 131 6 8 9
218 132 6 8 9
218 133 8 10 11
218 135 12 16 18
218 136 12 16 18
218 140 - 1 1
218 141 16 20 22
218 142 8 10 11
218 147 8 10 11
218 148 5 7 8
218 149 5 7 8
357 021 4 8 8
357 130 4 8 8
357 131 1 2 2
357 132 - 1 1
220 001
220 442
220 206
220 445
220 072
220 443
220 068
220 213
220 440
220 394
220 456
220 457
220 458
220 458
220 457
220 455
220 467
220 465
220 466
220 464
223 027
220 502
223 025
223 026
223 024
223 029
*)
*)
223 027
223 028
*)
223 009
223 023
223 007
223 017
223 004
223 003
223 114
223 003
B
223 002
223 005
A 223 103
223 115
B
Qty Wt. Qty Wt.
Part No. Description [Pcs] [Kg] Part No. Description [Pcs] [Kg]
220 001 Governor 1 -
223 001 Governor drive 1 -
223 002 Bearing housing 1 -
223 003 Bearing bush 2 -
223 004 Shaft 1 -
223 005 O-ring 1 -
223 006 Screw 4 -
223 007 Pair of friction rings 2 -
223 008 Coupling 1 -
223 009 Washer 1 -
223 011 Screw 1 -
223 015 Bracket 1 -
223 016 Screw 8 -
223 017 Screw 8 -
223 023 Retaining ring 1 -
223 103 Cylindrical pin 1 -
223 112 Gasket 1 -
223 115 Screw 4 -
223 116 Pin 1 -
223 120 Washer 8 -
223 121 Angle union 1 -
223-0012 Spare Parts List Wärtsilä 32
Edition: B
Page: 2(3)
Updated: 05.06.2008
Governor drive
223 001
223 011
223 009
223 103
223 114
223 115
387 025
223 018
223 021
223 022
223 019
223 020
223 119
387 006
223 108
See page 2
387 006
223 025
223 104
223 026
223 122
223 118
223 028
223 117
223 029
223 027
223 117
223 028
224 041
224 032
224 033
224 064
224 038
224 037 224 065
224 034
224 035 224 061
224 035
224 061
224 065
224 041
224 038
224 037 224 062
224 034
224 032
224 065
224 003 224 004 224 005 224 009 224 057 224 069
224 059 224 058
224 022 224 052
224 010 224 060
224 031 224 012
A
B 224 053
224 022
224 067
224 001 224 002 224 050 224 068 224 066 224 054 224 022
SECTION A - A SECTION B - B
224 018
224 054
224 051
224 011
224 049
224 021
224 022
Pieces Pieces
Part No 12V32 16V32 18V32 Part No 12V32 16V32 18V32
224 001 6 8 9 224 020 6 8 9
224 002 6 8 9 224 021 12 16 18
224 003 18 24 27 224 022 9 11 13
224 004 6 8 9 224 048 6 8 9
224 005 6 8 9 224 049 6 8 9
224 010 7 9 10 224 050 14 18 20
224 018 6 8 9 224 051 6 8 9
224 019 6 8 9 224 055 14 18 20
224 060 224 022 224 069 224 004 224 002
224 093
224 003
224 071
A 224 072
224 070
224 060
213 020 A
See 213-
224 053 224 067 224 066 224 054 224 010 224 001 224 005 224 050
SECTION A - A
224 019 224 018 224 055 224 049 224 048 224 020
224 051
224 021
224 022
Pieces
Part No 12V32 16V32 18V32 20V32
224 001 6 8 9 10
224 002 6 8 9 10
224 003 18 24 27 30
224 004 6 8 9 10
224 005 6 8 9 10
224 010 7 9 10 11
224 018 6 8 9 10
224 019 6 8 9 10
224 020 6 8 9 10
224 021 12 16 18 20
224 022 8 10 11 12
224 048 6 8 9 10
224 049 6 8 9 10
224 050 14 18 20 22
224 051 6 8 9 10
224 055 14 18 20 22
224 075
224 081
224 077
224 078
224 074
224 075
224 085 224 091 224 087 224 086 224 090
228 005
228 010
See 228-
228 008
228 009
228 056
228 084 228 034
228 026
228 104
228 025
A
228 052
228 029
228 027
228 028
B
228 029
228 032
228 077
228 076
228 078
228 084
228 034
228 078
228 032
View A View B
228 074
228 075
228 100
387 006
387 025
357 058
357 065
A
357 076
228 005
228 010
See 228-
228 103
228 111
228 112 357 193
357 189
357 188
View A
357 071
357 058
357 065
357 075
357 023
357 013
357 069
357 074
357 068
228 010
View A 228 011 228 012 228 013 228 002 228 015
228 014
228 005
228 011 228 013 228 012 228 002 228 015
228 053
View A
228 044
228 082
228 083
228 042
228 043
228 041
228 029
228 026
228 025
228 056
228 040
228 080
228 079
228 081 228 032
228 024
228 037
228 026
228 016 228 029
228 025
228 080 228 027
228 029
228 032
228 079 228 081
View C
Section A-A
228 061
228 049
387 006
228 050
228 049
228 050
350 602
View A
350 261
350 263
350 603
350 262
350 917
350 245
350 244
350 243
350 727
350 732
350 723
350 731
350 730
350 724
350 733
350 048
350 724
350 727
350 729
350 732
350 731
350 730
350 232
350 125
350 133
350 743 350 132
350 123 350 135 350 129
387 018
C
350 850
350 863
350 851
B A
350 859
350 860
350 857
350 856
350 854
SECTION D-D
350 835
350 932
350 859 VIEW C 350 852
350 848
350 860
D
350 860
350 858
350 861 350 850
350 862 350 851
350 863 350 859
F
350 849 350 860
350 851 350 846
350 835 SECTION F-F
350 852
350 847
350 845 350 848
350 944
350 945
A-Bank
165 001
A
350 126 350 125 See 165-
350 123
B-Bank
165 001
See 165-
350 126
350 122
350 124
350 123
350 232
See 350-
View A
350 125
100 105
350 124
350 137
350 604
350 138
350 126
350 134
350 133
350 132
350 127
350 137
350 134
350 138
350 133
350 132
350 129
Pieces
Part No 12V32 16V32 18V32
100 105 48 64 72
161 001 12 16 18
165 001 12 16 18
350 122 33 45 51
350 124 48 64 72
350 125 50 66 74
350 126 11 15 17
350 926
350 256
350 257
350 258
350 254
350 259
350 260
350 053
350 016
350 055
352 134
352 135
352 136
352 218
352 130
352 005
352 007
352 156 352 005
352 007
352 491
352 224
352 005
352 007
352 007
352 491 352 224
352 004 352 228
352 005
352 005
352 007
352 007
352 223
352 156
352 224
352 223
352 225
352 224
352 472
352 483
352 466 352 289
352 484
352 468 352 026
352 469
352 470
352 479
352 023
352 471 352 480
352 482
352 473
352 338
352 339
352 252
352 253
352 514
352 338
352 513
352 339
352 400
352 339
352 186 352 401
352 185 A
352 196
Section A-A
352 192
352 183
352 188
352 193
352 338
352 339
352 527
353 065
353 077
353 075
353 074
353 068 353 065
A 353 098 353 077
View A
353 066
353 068 353 123
353 026
353 038
353 061
353 061
353 064
353 079
Detail X
353 094 353 095
353 048
353 053
353 052
353 046
CV 519
353 047
353 044
353 061
353 053 353 116
353 048
353 054
353 059
353 029
353 076
353 077
354 088
354 055
354 051
354 087
354 086
354 085
354 090 354 084 354 106
354 091 354 093 354 107
354 092 354 088 354 080
354 095
354 079
354 081
354 083
354 082
Qty Wt. Qty Wt.
Part No. Description [Pcs] [Kg] Part No. Description [Pcs] [Kg]
354 051 Pipe 1 -
354 055 Screw 12 -
354 079 Bend 1 -
354 080 O-ring 1 -
354 081 Plug 1 -
354 082 Sealing ring 1 -
354 083 Screw 4 -
354 084 Screw 4 -
354 085 Pipe clamp 1 -
354 086 Screw 3 -
354 087 Pipe 1 -
354 088 O-ring 3 -
354 090 Support ring 4 -
354 091 O-ring 2 -
354 092 Guide ring 2 -
354 093 Connection piece 1 -
354 095 Screw 3 -
354 106 Screw 1 -
354 107 Nut 1 -
Spare Parts List Wärtsilä 32
355 432
355 427
355 436 355 425
355 426
355 428
355 431
355 435
355 428
355 431
355 435
355 336
355 337
355 362
355 339
355 424
355 340
A-BANK B-BANK
Free end
View A
Pieces
Part No 12V32 16V32 18V32 20V32
355 026 8 12 14 16
355 035 8 12 14 16
355 246
355 395
355 572
355 244
355 573
355 531
355 249
355 252
355 395
355 249
355 252
355 394
355 244
355 531 A
View A
355 342
355 233
355 236
355 237
355 238
355 235
355 366
355 578
355 579
355 364
355 575
355 576
355 577
355 365
355 533
357 048
357 049
357 052
Free End
357 001
357 008
357 009
357 092
357 093
357 094
357 095
View A
357 021
357 190
357 191
357 091
357 044
357 066 357 064 357 070
357 028
357 290
CV153-2
357 036
357 296 357 021
357 021
357 295 357 038
357 016 357 192
357 017 *
357 021
357 026 357 022
357 036
Qty Wt. Qty Wt.
Part No. Description [Pcs] [Kg] Part No. Description [Pcs] [Kg]
357 016 Pipe 1 - 357 296 Pipe 1 -
357 017 Main starting valve * 1 - CV153-2 Solenoid valve, stop 1 -
357 021 Nut 12 - .
357 022 Screw 4 - NOTE! * See 217-
357 023 Pipe union 2 -
357 026 Pipe union 1 -
357 028 Valve 1 -
357 033 Clamp 2 -
357 036 Gasket 3 -
357 038 Screw 4 -
357 039 Screw 4 -
357 041 Flame arrester 1 -
357 042 Flange 1 -
357 044 Retaining ring 1 -
357 064 O-ring 1 -
357 066 Pipe union 3 -
357 070 Pipe union 1 -
357 072 Reduction union 2 -
357 192 Screw 4 -
357 289 Bracket 1 -
357 290 Screw 4 -
357 295 Pipe union 2 -
357-0039 Spare Parts List Wärtsilä 32
Edition: A
Page: 2(2)
Updated: 29.08.2007
Starting air system
357 081 357 029 357 043 357 023 357 036
357 291 357 037 357 072 357 056
357 182
357 066
357 014
357 067
357 034
357 391
357 027 357 045
357 392 357 393 357 073 357 063
B-BANK A-BANK
358 040
358 041
B-BANK A-BANK
358 578
358 578
358 035
358 035
358 036
358 035
358 013
358 034
View B View A
A B
358 009
358 009
358 056
358 038
358 044
A
358 021
358 020
358 023
358 024
358 017
358 028 358 065
358 066
358 064 358 068
358 067
358 022
358 005
VIEW A
358 025
358 027
358 005
358 019
358 026
358 592
358 592
358 591
358 080
372 289
372 154
372 157
372 155
372 231
372 157
372 286
372 115
372 115
372 369
372 027
372 300
372 291 372 302
372 584
372 295
372 371
372 372
X
372 544 372 301
372 350
372 352 372 370 372 301
372 056
372 373
372 374
Detail X 372 375 372 578
372 575
372 126
372 376
372 016
372 377
372 052
372 162
372 375
372 018
372 127
372 028
372 129
372 127
372 301
372 028
372 574
469 023
469 024
469 022
470 363
470 359
470 358
470 351
470 352
470 360
470 361
470 347
470 348
470 349
470 357
470 350
470 362
470 367
470 365
470 366
470 368
470 369
470 370
470 371
100 131
471 117
471 120
471 563
471 113
471 564
471 119
471 116 471 124
471 115
471 113
471 123
471 112
471 568
471 057
See page 4
471 127
471 056
See page 4
471 092
471 583
471 088
471 108 471 060 471 081 471 584
471 086 471 568 471 066 471 067 471 090
471 081
471 588
471 088 471 108 471 092 471 585 471 577 471 101 471 103 471 586
471 090 471 060 471 127 471 577 471 585
471 067
471 092 471 091 471 584 471 596
A
Section A-A
471 089 471 087 471 107
B
471 070
471 071
A
471 094
Section B-B
471 073
471 099
471 109
471 595
471 594
471 107
471 126
471 127
471 555
471 582
473 077
473 072
473 066
473 033
473 063
473 073 473 067
473 074 473 078
473 035
473 069
473 082
473 075
473 001
473 076
473 062
473 082
473 086
473 081
473 085 473 083
473 084
352 378
352 304
352 379
352 380
352 305
352 381
471 056
See 471-
474 045 474 116 474 003
474 170
474 194
474 195 474 185
474 168
474 123
474 052
474 142
474 164
474 140
474 144
474 141 474 144 474 144
474 136
474 016
474 186
474 158
474 159
474 146
474 114
474 123
474 115
474 098
474 016
474 167
474 161
474 007
474 149
474 161
474 147
474 148
474 150
474 153
474 161
474 166
474 165
474 012
474 175
474 174
474 176 474 176
474 178 474 177 474 177
387 025
474 179 474 187
474 180 474 181
474 183
474 188
B
C
Section C-C C
A
476 015
476 048
476 046
476 049
476 047
476 018
476 023
476 026
476 017
476 027
476 024
476 025
476 033
D
476 022
476 028 D
Qty Wt. Qty Wt.
Part No. Description [Pcs] [Kg] Part No. Description [Pcs] [Kg]
156 161 O-ring 4 -
476 017 Plug 4 -
476 018 Sealing ring 4 -
476 019 O-ring 4 -
476 020 Cover 1 -
476 021 Cover 1 -
476 022 O-ring 2 -
476 023 O-ring 4 -
476 024 Flange 4 -
476 025 Screw 16 -
476 026 Plug 4 -
476 027 Sealing ring 4 -
476 028 Screw 64 -
476 033 Washer 16 -
476 046 Plug (1) 2 -
476 047 Sealing ring (1) 2 -
476 048 Plug 2 -
476 049 Sealing ring 2 -
387 020 Glue compound 1 -
.
NOTE! (1) Not used in all installations
Wärtsilä 32 Spare Parts List 476-0003
Edition: E
Page: 3(3)
Updated: 29.11.2007
Charge air cooler assembly
Section D-D
476 018
476 029
482 001
482 002
482 003
482 022
482 023
482 024
482 025
482 027
482 021
482 022
482 023
482 050
482 029
482 028
483 075
483 079
483 088
483 008
483 009
5 4 3 2 1 0 1 2 3 45
100
50
483 053 483 072
483 073
483 071
483 006
483 007
483 118
483 117
483 119
483 120
483 116
483 118
483 121
483 116
483 117
483 050
483 014
483 025
483 051
483 015
483 016
483 046 483 052
483 047 483 010
483 012 483 050 483 048
483 037 483 062
483 051
483 011
483 050
483 025
483 016
483 062
483 034
483 015 483 057 483 046
483 047
483 034 483 037
483 064
483 012
483 050
483 026
483 062
483 025
483 048
483 050
483 008
483 049
483 014
483 043
483 029
483 052
483 020
483 060
483 028
483 032
483 044
483 045
483 053
214 007
483 041
214 001
GS 792
See 214-
483 030
x
View x
483 031
483 054
483 033
483 024
483 036 483 063
483 063
483 053
483 041
483 024 483 054 483 030
483 036
483 010
483 048
483 033
483 044 483 045
Qty Wt. Qty Wt.
Part No. Description [Pcs] [Kg] Part No. Description [Pcs] [Kg]
483010 Cover 1 -
483020 Gear wheel 1 12.6
483021 Bearing housing 1 1.5
483024 Washer 1 -
483028 Arm 1 -
483030 Cover 1 2.4
483031 Bush 1 -
483032 Locking device 1 -
483033 Ball bearing 2 1.4
483035 Ball bearing 1 0.4
483036 Shaft seal 2 -
483041 Retainer ring 1 -
483044 Adjusting ring 2 -
483045 Adjusting ring 2 -
483048 Screw 21 -
483053 Screw 9 -
483054 Nut 1 0.1
483060 Hand knob 1 -
483063 Flat key 1 -
GS792 Limit switch 1 -
483-0008 Spare Parts List Wärtsilä 32
Edition: A
Page: 6(7)
Updated: 26.04.2004
Turning device
483 055
483 056
483 044
483 045
483 058
483 036 483 065
483 019
483 022
483 040
483 124
483 042
483 038
483 039
483 033
483 017 483 027
483 018
483 122
483 048
483 123
504 014
See page 2
504 015
504 150
504 149
Alternative 3
Alternative 2
Alternative 1
504 014
504 181
TE 517
PT 601-2 PT 601
504 135
Alternative Design
TE 601
PT 601-3 504 134
PT 601
504 132
507 053
See 507-
CV 153
ST 173
387 006
ST 174
387 006
Alternative 1
PT 601-4
504 132
507 053
See 507-
Alternative 1
PT 601-4
504 132
507 053
PT 601-4 Alternative 2
504 132
507 053
See 507-
See 507-
506 115
506 116
506 109
506 110
506 108
506 112
506 114
506 112
506 111
506 113
506 109
506 110
LS 103B
506 100
506 998
TE101
506 080
506 1186
LS103A
506 080
(1) PT101-2
506 055
507 053 507 053
See 507- See 507-
PT101
506 055
TE401
506 048 PT401-2
507 053
506 1010 507 053 506 049
See 507-
See 507-
PT401
506 049
PT301-2
507 053
See 507-
PT301
357 057
507 053
See 507-
506 1177
506 1175
506 1176
506 1178
506 1174
506 1187
PT311
506 1179
PT311-2
506 032
506 1001
506 033
506 976
506 070
506 126
506 127
506 125
506 999
506 071
View A
A-bank
TEZ 402
506 1020 TE 402
506 1021
506 1022
506 1023
TEZ 403
B-bank
506 1020
506 1207
506 1021
506 1022
TE 403
506 1023
506 1020
506 1207
506 163
506 164
506 165
506 166
506 167
506 162 506 168
506 964
506 966
507 053
See 507-
506 055
TE 432
506 1013
506 1014
506 1016
506 1017
506 1018
506 1230
506 1231
387 017
506 199
506 1201
PT 281
506 1198
506 1230
506 1231
387 017
506 199
506 1201
506 1200
PT 271
506 1198
A-bank
TEZ 402-1
506 1020
506 1021
506 1207
506 1273
B-bank
TEZ 403-1
506 1020
506 1021
506 1207
506 1273
507 053
507 054
507 054
507 056
507 057
507 055 *
387 006
507 058
B C A
Section A-A
B C A
507 087
507 1142
387 017
507 086
507 087
387 017
Section B-B
507 086
507 087
387 017
507 085
Section C-C
507 086
507 087
387 017
Pieces
Part No 12V32 16V32 18V32 20V32
507 085 8 10 11 12
507 086 59 73 80 87
507 087 68 86 95 104
507 1142 16 20 22 24
SE 167
SE 173
SE 168
507 113
507 114
507 1004
L-engine
507 1171
507 1167
V-engine
507 1171
507 1172
507 1166
507 1167
507 1155
See page 4
507 1278
507 1151
507 1158
507 1159
507 1160
507 1161
507 1277 507 1165
507 1152
507 1156
Qty Wt. Qty Wt.
Part No. Description [Pcs] [Kg] Part No. Description [Pcs] [Kg]
507 172 Pipe union 2 -
507 1151 Pipe clamp 1 0.4
507 1152 Adapter 1 0.1
507 1153 Adapter 1 -
507 1154 Pressure gauge 1 0.4
507 1156 Union 2 -
507 1158 Screw 4 -
507 1159 Nut 4 -
507 1160 Screw 4 -
507 1161 Washer 4 -
507 1163 Sealing ring 2 -
507 1164 Pipe (1) 1 0.2
507 1165 Distance sleeve 4 -
507 1277 Cable (2) 1 0.2
507 1278 Pipe clamp 1 0.4
PDT243 Pressure diff. sensor 1 0.5
.
NOTE! (1) L= 2000mm
NOTE! (2) L= 3000mm
507-0081 Spare Parts List Wärtsilä 32
Edition: B
Page: 4(4)
Updated: 23.05.2005
Pressure difference indicator
V-engine
507 1160 507 1158 507 1156 507 1152 PTD 243 507 1277
507 1161 507 1151 507 1159
507 1165
507 1164
507 1278
507 1164
507 758
507 1052
507 1058
507 1063
507 1054
507 1061
507 1053
507 173
507 176
PT 201
507 182
507 097
507 053
507 181
See 507-
PT 201-2
507 097
507 053
See 507-
507 1147 TE 201
A
PTZ 201
507 1148 507 099
507 097
507 1149 507 1149
View A
TE482
507 099
507 1146
507 1321
507 173
507 176
PT 201
507 097
507 053
See 507-
PT 201-2
507 097
507 053
See 507-
TE 201
507 1147 PTZ 201
507 099
A
View A
TE482
507 099
507 1146
507 187
507 189 507 190 507 192 507 193 507 191 507 191 * 507 188
507 062
507 060
507 100
507 074 507 077
507 080
507 120
507 183
387 025
507 067
507 068
507 064
507 065
507 060
507 062
Qty Wt. Qty Wt.
Part No. Description [Pcs] [Kg] Part No. Description [Pcs] [Kg]
507 060 Fixing piece 16 -
507 062 Screw 32 -
507 064 Screw * -
507 065 Washer * -
507 067 O-ring * -
507 068 O-ring * -
507 074 Gasket 1 -
507 077 Gasket 1 -
507 080 Screw 20 -
507 100 Cover 1 -
507 120 Damper 20 -
507 183 Distance ring 20 -
387 025 Glue compound 1 -
.
NOTE! *) See page 2.
507-0148 Spare Parts List Wärtsilä 32
Edition: A
Page: 2(2)
Updated: 12.09.2007
Side cover lower part, A-side
Pieces
Part No 16V32 18V32 20V32
507 064 34 38 42
507 065 34 38 42
507 067 16 18 20
507 068 10 11 12
507 062
507 060
507 059
507 077 507 074
507 080
507 120
507 183
387 025
507 067
507 068
507 064
507 065
507 060
507 062
Qty Wt. Qty Wt.
Part No. Description [Pcs] [Kg] Part No. Description [Pcs] [Kg]
507 059 Cover 1 -
507 060 Fixing piece 16 -
507 062 Screw 32 -
507 064 Screw * -
507 065 Washer * -
507 067 O-ring * -
507 068 O-ring * -
507 074 Gasket 1 -
507 077 Gasket 1 -
507 080 Screw 12 -
507 120 Damper 12 -
507 183 Distance ring 12 -
387 025 Glue compound 1 -
.
NOTE! *) See page 2.
507-0149 Spare Parts List Wärtsilä 32
Edition: A
Page: 2(2)
Updated: 12.09.2007
Side cover lower part, B-side
Pieces
Part No 16V32 18V32 20V32
507 064 34 38 42
507 065 34 38 42
507 067 16 18 20
507 068 10 11 12
504 128
PS 410
PT 401
PT 101
PT 401-2
PT 101-2
507 184
507 1193
507 1195
507 062
View A
507 060
508 025
508 026
LS 108A
507 080
507 120
507 060 507 183
507 062
TE 101
504 185
PT 101-2
PT 101
PS 410
PT 401-2
TE 401
504 185
PT 401
PT 301
504 128
PT 311
GS 171
GS 792
507 1292
213 023
507 185
507 184
507 1193
507 1195 504 128
507 1197
507 1199 507 184
507 062
507 060
508 025
508 026
LS 108B
507 080
507 120
507 060 507 183
507 062
SE 167
507 1325
507 1349
SE 168
508 006
508 033
508 016
508 006
508 033
508 005
508 006
508 002
508 049
514 024
514 025
514 003
514 008
514 004
514 007
514 026
514 021
514 009
514 010
514 013
514 013
514 020
514 014
516 522
516 020
516 391
516 393
516 521
516 226 516 520 516 501 516 503 516 496 516 503 516 520
516 520
516 504
516 503
516 507
516 387
516 226 516 496
516 503 516 498
516 497
516 520
516 125 516 561 516 503 516 128
516 226
516 519 516 503 516 503 516 220
516 039 516 503
516 560
Qty Wt. Qty Wt.
Part No. Description [Pcs] [Kg] Part No. Description [Pcs] [Kg]
516 039 Converter 1 - NOTE! (2) L= 1450mm
516 125 Relay 8 - NOTE! (3) L= 2000mm
516 128 End plate 2 -
516 220 Terminal strip 5 -
516 226 Terminal strip rail (1) 1 -
516 387 Engine safety module 1 -
516 495 Power distribution 1 -
module
516 496 Plug 6-pin 6 -
516 497 Plug 12-pin 34 -
516 498 Plug 8-pin 8 -
516 501 Terminal strip 50 -
516 503 End clamp 16 -
516 504 Receptacle, DIN-rail 156 -
mounting
516 507 Ground receptacle 26 -
516 519 Cable tray (2) 1 -
516 520 Cable tray (3) 1 -
516 560 Terminal strip 5 -
516 561 Amplifier 1 -
.
NOTE! (1) L= 1750mm
Wärtsilä 32 Spare Parts List 516-0080
Edition: A
Page: 3(4)
Updated: 09.09.2007
Connecting box
516 509
516 513
516 512
516 516
516 510
516 514
516 615
PTZ 201
516 617
516 551
PT311-2
516 552
516 554
600 004
600 002
600 005
600 001
600 012
600 002
600 003
600 005
600 013
600 004
600 002
600 005
Pieces D / d (mm)
Part No Ø 600/400 Ø 700/500
600 004 32 40
600 005 32 40
600 012 20 24
600 015 20 24
604 523
604 524
604 092
604 514
604 511
604 515
604 512
604 091
604 632 604 640
604 514
604 633 604 760
604 515
604 634 604 761
604 763
604 081
604 513
604 087
604 515
604 513
604 516
604 515
604 759
604 516
604 761
604 762
604 082
604 513
604 515 604 509
604 338
604 053
604 657 604 047
604 756 604 352
604 337
604 758 604 451
604 658
604 654 604 771
604 053
604 053
604 754
604 348
604 755
604 350
604 757
604 937
604 454
604 353
604 338
604 054
604 402
604 053
800 007
800 009
800 008
800 005
800 004
800 002
800 106
800 011
800 001
802 000
800 013
800 012
800 101
800 102
800 099
800 100
800 098
800 016
800 108
Section A-A
B 800 210
800 087
800 020
800 088
A 800 085
B 800 086
A 800 083
800 083
800 084
800 084
800 080 800 081
800 081
800 082
800 193 800 082
800 083
800 084
800 097
Section B-B
800 089
800 029
800 075
800 174
800 126
800 031
800 030
800 028
800 024
800 187
800 188
800 189
800 190
800 186 800 034
800 191
800 185
800 192
800 039
800 127
800 128
800 129
800 070
800 071
800 078
800 079
800 198
800 114
800 112
800 125
800 147
861 101
800 154
800 155 800 112
800 152
800 153
861 004
861 101
800 046
800 096
861 101
800 047
861 003
861 004
800 051
800 041
800 044
861 055
861 023
861 025
800 041
837 055
800 062 800 074
837 063
800 063
800 122
800 176
848 021
800 066 800 067
848 022
848 023
800 064
848 029 848 024
848 028
848 027
800 141
848 026 848 025
806 032
800 094
800 065
800 063
861 101
387 004
834 005
834 006
834 007
834 009
834 008
800 059
800 058
800 060
860 065
860 072
860 075
860 076
860 060
B
860 069
860 070
860 057
860 068
387 003
860 067
860 066 860 056 860 062
860 054
800 060
860 074
860 080
Size Pcs
11*2.5 2
6.5*1.6 1
860 151
800 053
800 056
800 200
861 148
800 056
861 196
800 200