Professional Documents
Culture Documents
CNT 0011491 02
CNT 0011491 02
Nishiguchi/SENAUN
Indicates where sections should Indicates sections that should be glued first,
*Hint: Trace along the folds with a ruler be glued together. then cut out.
and an exhausted pen (no ink) to get a sharper, easier fold.
Indicates where to insert sections. Indicates sections that should be folded once,
Do not glue the sections together. then unfolded.
Assembly Instructions
After folding the part once and gluing the two
Glue
Mountain fold(dotted line) folds together, cut out from the yellow area.
The glue spot(colored dot)
Make a mountain fold.
shows where to apply the glue.
Valley fold(dashed and dotted line) Glue spot(Red dot)
Make a valley fold. Glue parts with the same number together.
Scissors line(solid line) Glue spot(Green dot)
Cut along the line. Glue within the same part.
Cut in line(solid line) Glue spot(Blue dot)
Cut along the line. Glue to the rear of the other part.
Before gluing, crease the paper along mountain fold and valley
Assembly tip fold lines and make sure rounded sections are nice and stiff.
Insert until
the corners meet.
Ships of the world : Akogare : Assembly Instructions © Canon Inc. © M. Nishiguchi/SENAUN
Parts -
Attach parts 32 - 34 (the yards) to the vessel masts.
If the bow will point to the right, attach the yards so that surface Parts -
A is on top. If the bow will face to the left, attach so that surface
B is on top. Glue the yards in place at an angle, as shown in
the illustration, so that the model will resemble a ship sailing
in the wind.
Surface A on top Surface B on top Fold once and glue the folds together, then give
(bow pointed to the right) (bow pointed to the left) the sails a bulging appearance.
If you plan to have the bow face to the right,
curl the sails so that surface A will bulge out.
If the bow will face to the left, curl the sails
so that surface B will bulge out.
After folding parts 44 and 45 (the square sails) in two and gluing them, cut out the yellow
guides. After curling these from top to bottom as shown in the illustration, make them curl
from the center to the outside, to make it appear as if they are catching the wind.
Parts and
Sail
AkOsaka
og
are
W trainin
ith th
e
g vess
coop
e ration
of Sa el
il Osak
a
Sa
Akoil Osaka
gar
With
e trainin
the c
oope g vess
ratio
n of
Sail el
Osak
a
Sail O
Akog saka
are tr
With th aining ve
e coop
eration
of Sail
ssel
Osaka
Finished!