Professional Documents
Culture Documents
TDC-15-S-05 Handling Emergencies and Breakdowns (Version 3 2021)
TDC-15-S-05 Handling Emergencies and Breakdowns (Version 3 2021)
HANDLING EMERGENCIES
and BREAKDOWNS
Subject Code: TDC-15-S-05
Handling Emergencies and Breakdowns
Topic Outline:
TIRE BLOWOUT
➢ Don’t brake.
➢ Look to your target or escape area
and pull over to the side of the road.
➢ Turn on hazard lights and properly
placed Early Warning Device (EWD)
https://philkotse.com/safe-driving/driving-on-a-flat-tire-signs-warnings-tricks-for-pinoy-drivers-4366
EMERGENCY SITUATIONS AND PROCEDURES
LOSS OF BRAKE
➢ Aim to the target or escape area.
➢ Release the accelerator.
➢ Control steering.
➢ Downshift. Do not switch off the engine.
➢ Use parking brake, keep the release Source: google images
ENGINE FIRE
➢ Steer out of traffic, away from
buildings, people, and other cars.
➢ Have all occupants leave the car
immediately and move away.
➢ Do not open the hood.
➢ Turn off the ignition then get out https://giphy.com/explore/mo-fire-rides
quickly.
EMERGENCY SITUATIONS AND PROCEDURES
POOR VISIBILITY
➢ Drive with lights on low beam
➢ Slow down and do not turn on the hazard lights
➢ Signal Turns
➢ Reduce Distractions
➢ Use Clean Wipers
➢ Stop at a safe place and turn on hazard lights Source: google images
• Sit properly.
Riding the Bus
• Place bags and belongings under the seat or lap.
• Keep the aisle clear.
• Keep hands and arms inside the vehicle.
• Not to throw trash/objects inside or outside of the vehicle.
• Behave and be quiet.
• Avoid playing and bullying while inside the service.
• Participate in all bus evacuation procedures.
• Refrain from eating or drinking inside the vehicle.
• Always follow the bus driver’s instructions
SCHOOL BUS SAFETY
School service driver and conductor should train and educate the Students to:
Getting Off the Bus • Remain in the seat until the bus comes to a complete
stop.
• Hold the handrail and take two large steps away from
the bus when leaving. To cross the street in front of
the bus, walk ahead at least ten giant steps (three
meters). Cross only when the driver gives a signal.
Proceed across the street, looking both ways for
oncoming traffic. Cross the street in single file.
• Allow people sitting at the front to leave first. Do not
push.
• Tell an adult if something is dropped near the bus.
• WALK, Don’t run.
Road Crash
ROAD CRASH
PEDESTRIANS
CYCLISTS