Professional Documents
Culture Documents
________________________11.
________________________12.
________________________13.
________________________14.
________________________15.
B. Identify the following.
________________16. It is the basic unit in the S.I. measurement.
________________17. It is the numerical value that is being assigned to the size, shape or location of the feature
being described.
________________18. These are figures aligned with the dimension lines so that they may be read from the bottom
or from the right side of the sheet.
________________19. These are figures and notes lettered horizontally on the sheet and read from the bottom of
the drawing.
________________20. It is an equation with a ratio on each side. It is a statement that two ratios are equal.
________________21. Other term for Alphabet of Lines.
________________22. Thick, dark line used to show the outline of the object.
________________23. Lines that are very light and very thin used to construct layout work.
________________24. Thick, dark line used to show the size (span) of an object with a numeric value.
________________25. Short dash lines use to show non visible surfaces that are not visible in orthographic view.
________________26. Long and short dash lines. Usually indicates center of holes, circles and arcs.
________________27. Extra thick line used to show cut-away views or plane of projection where a section view is
taken.
________________28. A thin line used to connect a dimension line with a particular area or point on the drawing.
________________29. Thick wavy line that is used to break the edge of a surface of a part for clarity on a hidden
surface.
________________30. Long, thin lines that is used to show that the middle section of an object has been removed so
it can be drawn on a smaller piece of paper.