Professional Documents
Culture Documents
SCFT 5g Xcal User Guide Rjil v03
SCFT 5g Xcal User Guide Rjil v03
User Manual
Rev: 01
Ver: 03
12 S ep 2022
1.1 Starting X-CA L Remote
Steps to start XCA L
Following steps are asked for the first time only after installing the application.
Following steps needs to be verified for the log files to be stored in * . drm and * . aof format. Incase the options highlighted below are unchecked then need to
follow the steps given in fig. 3.1.f
When setting Roll-out mode through the server, there are measurement modes. Modes are SCFT, CLOT and Golden CLOT, etc as per required test mode.
A utocall Measurement Mode by sector at a specific site, and the measurement modes are divided by Stationary and mobility. Here describes Stationary .
Fig : 4.1.i Fig : 4.1.j Fig : 4.1.k Fig : 4.1.l Fig : 4.1.m
For Log uploading, Select User will get redirected to Long Press for selection of User can check the Log • User can verify the
Log Upload. Log File Manager Log file and Click on Upload. upload status. A fter uploaded file.
completion click on Done. • Logs will be moved to
uploaded folder.
4.1. 1. Network Setting for EPS -FB Scenario testing
Fig : 4.2.h
Fig : 4.2.e Fig : 4.2.f Fig : 4.2.g Fig :4.2.h InProgress and Complete is
Display selected Scenario value Check Scenario information on the Test by Scenario set from the • Once the DTR is activated according to the
and change by tapping main screen. beginning of A utocall. complete this screen conditions for completing
pops up. the set path measurement
• Tap on OK at the end of A utocall.
Only InProgress is
activated if condition is not
satisfied.
4.2 SCFT - (Mobility)…Contd.
Steps to upload the logs of SCFT.
Below are the steps for uploading the logs of SCFT
Fig : 4.2.i Fig : 4.2.j Fig : 4.2.k Fig : 4.2.l Fig : 4.2.m
For Log uploading, Select User will get redirected to Long Press for selection of User can check the Log • User can verify the
Log Upload. Log File Manager Log file and Click on Upload. upload status. A fter uploaded file.
completion click on Done. • Logs will be moved to
uploaded folder.
Thank you!