Professional Documents
Culture Documents
Set up
1. Vfo/mr set to vfo
2. Input desired frequency
3. Push menu
4. Call up settings
menu settings
0-SQL 0 to 9
1-step frequency steps
2-TXP low high
3-SAVE default is 3
4-VOX on or off
5-WN wide or narrow
6-ABR off to 1-100
7-TDR on or off
8-BEEP on or off
9-TOT default is 60
10-R-DCS see pl setting
11-R-CTCS see pl setting
12-T-DCS see pl setting
13-T-CTCS see pl setting
14-VOICE set to ENG
15-ANI default
16-DTMFST default
17- S-CODE default
18-SC-REV default
19 -PTT-IO see settings
20-PTT-LT see settings
21-MDF-A set to frequency
22-MDF-B see settings
23- BCL on or off
24-AUTOLK on or off
25-ST-T-D see settings
26-OFFSET see settings
27- MEM-CH assign channel to frequency
28-DEl-CH deleted memory channel assignment
29-WT-LED select light color
30-RX -LED select light color
31-TX-LED select light color
32-All- see settings default is TONE
33-BAND see settings
34-AB on or off
35-STE on or off
36-RP-STE set to default
37-RPT on or off
38-POMMGS set to FULL
39- ROGER BEEP on or off
40-RESET to factory settings
Example program 146.700
1. VFO/MR to VFO
2.
3. Input 146.700 Go to 2 TXP set to Hi or low
4. Go to 13 T-CTCS go to pl setting in this one select 162.2
5. Go to 25 ST to select -
6. Go to offset program 000.600
7. Go to 27 MEM-CH assign channel hit menu to confirm
8. Hit exit
9. VFO/MF set to MF
10.
your all set
This should have your frequency set up with the basic settings. Remember, each
repeater might have different tones and offsets, so adjust accordingly. If you need
help with a specific step or setting, just let me know!