Professional Documents
Culture Documents
3. Hazards Identification:
www.alokmasterbatches.com
2 26-06-2023 Material Safety Data Sheet
Technical measures Stop the fire spreading. Call the fire brigade
immediately. Evacuate non-essential personnel.
Protective clothing, goggles and self-contained
breathing equipment should be made available for
foremen.
Extinguishing media -Suitable Stop the fire spreading. Call the fire brigade
immediately. Evacuate non-essential personnel.
Protective clothing, goggles and self-contained
breathing equipment should be made available for
foremen.
Not to be used Do not use water jets (stick jets) in the early
stages of extinguishing fire since they could help
to spread the flames.
Protective equipment for firefighters Wear suitable breathing equipment, in case of risk
of exposure to vapor or fumes.
6. Accidental release measure
See also chapters 8 and 13 after spillage Granules spilled on the floor can cause a risk of
/ leakage- on slipping on smooth surface. Recover the spilled
product by sweeping or suction, put it in
containers to facilitate its disposal.
soil Dispose safely in accordance with local or
national regulations. Prevent the spilled material
from spreading.
In water If the material has been discharged into a stream
or a sewer , inform the authorities of the possible
presence of floating materials. Clean up the water
surface by creaming off debris from the top.
Refer to a specialist for waste disposal in a safe
manner in accordance with local or national
regulations.
Technical protective measures Handling Storage All pneumatic transport equipment must be
electrically earthed. Store at ambient temperature
and at atmospheric pressure in original packaging
(plastic or cardboard boxes) or in silo made
appropriate material aluminium, stainless steel,)
Do not store near highly flammable materials,
store away from heating source, avoid static
electricity build up with connection to earth. Store
in dry, well –ventilated area. Avoid dust
accumulation by use of filters in the pneumatic
transport equipment
www.alokmasterbatches.com
3 26-06-2023 Material Safety Data Sheet
Symptoms related to use inhalation Low risk for temperatures below 40oC
If heated more than the heat stability (TDS), the
product may form vapours or fumes which may
cause irritation of respiratory tract and cause
coughing and sensation of shortness of breath.
Dust may cause irritation on respiratory system.
www.alokmasterbatches.com
4 26-06-2023 Material Safety Data Sheet
Revised: 01.04.2020
This data sheet conforms to standards defined by directives 91/155 & 93/112/EEC
IMPORTANT:
The information in this Data Sheet applies only to the products designated herein and produced or supplied by us it is
based on our experience and on the data available to us at the time of its issue and is accurate to the best of our
knowledge. The customer is strongly advised to observe and ensure that its employees and customers observe all
direction contained herein. However, no warranty is made or implied that the information is accurate or complete and
no liability will be accepted whatsoever arising out of the use of the information or the products designated herein .
Where third party products are used in conjunction with or instead of products produced or supplied, customers should
themselves obtain all necessary technical, health and safety information about such product from the third party.
ALOK MASTERBATCHES PVT.LTD
S-14, SIPCOT Industrial Complex, Phase-3
Mukundarayapuram, Ranipet-632405, Vellore Dist. Tamilnadu
Phones- 7094400118
e-mail:qaattd@alokindustries.com
www.alokmasterbatches.com