Professional Documents
Culture Documents
May also mark the desired length and cut ) set points. In case of the liquid temperature
paddle *1/2"NPT 2. The paddle must be parallel to the sectional would vary with the specific gravity changes
area of a pipe and the mounting screw is 1" during processing, please contact us for
NPT. assistance.
3. The FLOW mark on the screw hexagon must 3. The flow switch is designed for shock and
Switch on in case of liquid flowing in pipes be parallel to the pipe and the ground. vibration resistance. However, shock and
4. Before installing the unit to T pipe, be sure vibration should be minimized as low as possible.
spring To apply tape seal to the screw then tighten 4. Excessive contamination in fluid might inhibit
up. Paddle operation, occasional wipe-down would
magnet be necessary.
1 It is not recommended to use the 1" NPT plastic 5. Electrical entry and mounting require sealing
reed switch pipe.(Please refer to below for installation) from moisture.
6. Please don't modify the outlook of product.
eccentric
paddle
(32Max)
Veto y Cia.L t d .
San Eugenio 567 Ñuñoa Santiago, Chile
Tel:223554400
: