Professional Documents
Culture Documents
Customer: Comptronic AB
APPROVED BY APPROVED BY
GCI Components Limited
------------------------------------ ----------------------------------
1/9
CONTENTS
1 Purpose
2 Maximum Rating
3 Dimensions & Construction
4 Electrical Characteristics
5 Method of Measurement
6 Quality Control
7 Packing
8 Related Explanation
9 Appendix
2/9
1 Purpose
This document contains the detail specifications (electrical and mechanical), inspection
standard and the reliability standard for the purpose of the customer’s approval.
2 Maximum Rating
See Table 1.
Table 1
3.1 Dimensions
3/9
3.2 Inspection standard
See Table 2.
Table 2
Inspection By Means
No. Item Specification Remark
Of
Adhesive should be
made sufficiently and there
3.2.6 Adhesive Eye
should be no outflow of
adhesive.
4 Electrical Characteristics
4.1 Electrical-acoustic Characteristics
See Table 3.
Table 3
No. Item Specification
114dB±4db at 10cm/3000Hz/
4.1.1 Sound Press Level (SPL)
18.0Vp-p Square Wave
4.1.2 Operating Frequency 3.0 ±0.3 kHz
4/9
4.2 Frequency Response Curve
5 Method of Measurement
5.1 Measuring Condition
Normal measuring condition is used unless the standard condition is required. See Table 4.
Table 4
5/9
5.2 SPL Measure Method
6 Quality Control
6.1 Outgoing Inspection
Use GB 2828-87 (or MIL-STD-105) as the AQL sampling plans. See Table 5.
Table 5
Appearance II 1.5
No Sound II 0.25
Capacitance II 0.65
6/9
6.2 Life Test
Normal Condition:
After the test, all of the electric performance must meet the requirement of table 3.
The sample should be arranged into three groups and kept in normal condition for 2hrs
Table 6-1
Sample
No Item Test Condition Requirement
Size
7/9
Table 6-2
ITEM Test Condition Requirement Sample
No
Size
All of the
performance
must meet the
+40±2℃& 90%~95% RH
1 HUMIDITY requirements on 5pcs
for 96 hrs
table 2 and table
3 after
experiment.
Table 6-3
ITEM Test Condition Requirement Sample
No
Size
All of the
With the gravity of 100g at axial of performance
STRIKE
2 X/Y/Z for 6 times per direction. must meet the
5pcs each
requirements on
Drop a buzzer naturally from the table 2 and table
height of 700mm onto the surface of 3 after
DROP 10mm thick wooden board. Two experiment.
3 directions; that is, upper and side of
the buzzer are to be applied for this
drop test. 5times for each side.
8/9
7 Packing
Attaching Photo: N/A
Detail:
8 Related Explanation
N/A
9 Appendix
N/A
9/9