You are on page 1of 3

27/01/23, 10:58 Formula Stundent East registration QUIZ 2023

Logged in as "E-Team Squadra Corse" (List: A - ev) Logout

1) There is some oil on the track, which flag is the correct one for the car which caused it?
A) Red and yellow striped
B) Black
C) Black with orange dot
D) Yellow

2) If the car is 143 kg, the wheels are used, and the ambient temperature is 28.2°C. On the brake test,
where on the track do you need to start braking?
A) after the given brake line
B) immediately, when you reached 40 km/h
C) before the given brake line
D) on the given brake line and stop in 10 meters

3) If risk event 'A' happen, the consequences will be 5000 EUR. The event has a 20% chance of occurring.
What does 1000 EUR represent in this case?
A) Expected Monetary Value
B) Risk Value
C) Contingency budget
D) Risk Estimate

4) Your vehicle's maximum TS voltage is 500 V. You disconnect the TS cable which connects the TSAC to the
motor controller housing at the TSAC side only (the TS cable is still connected to the motor controller
housing). After that, you turn on the LVS only and supply 70 V to the TS cable (which is connected to the
motor controller) with a laboratory power supply. How shall your TSAL behave?
A) The TSAL has to turn off completely.
B) The TSAL has to flash in red only with 50% duty cycle.
C) The TSAL has to light continuously in green.
D) The TSAL has to flash in green and orange with 50% duty cycle.

5) The parameters of a battery cell are the followings:


Maximum Cell Voltage: 4.2V
Nominal Cell Voltage: 3.7V
Minimum Cell Voltage: 3.2V
Nominal Capacity: 20Ah
Weight: 450g

What is the maximum number of these cells that can be used in one TS Accumulator Segment according to
the Rules?
A) 22
B) 19
C) 26
D) 28

6) Which of the following is true about fire extinguishers regarding EV teams for FS EAST 2023?
A) Each EV team must have an additional fire extinguisher available, therefore a minimum total of 3.
B) One of the fire extinguishers must always accompany the TSAC when outside of the car.
C) One of the fire extinguishers must be a gel-based (Class A) fire extinguisher.
D) FS EAST will provide a gel-based lithium battery-specific fire extinguisher for all EV teams.

7) What is the total area of the internal cross-section template and cockpit opening template in mm²,
rounded to the whole number, with the space for steering included?
A) 282500 mm²
B) 109646 mm²

https://quiz.fseast.eu 1/3
27/01/23, 10:58 Formula Stundent East registration QUIZ 2023
C) 392146 mm²
D) 164469 mm²

8) Direct current is present in a straight copper wire, with a cross-section of 2.5 [mm2] and a conductivity of
57 [MS/m]. The measured voltage between two points of the wire is 200 [mV], and the distance between the
two points is 40 [cm]. What is the current density in the wire?
A) 28.5 [A/mm2]
B) 14.25 [A/mm2]
C) 114 [A/mm2]
D) 57.0 [A/mm2]

9) What's the maximum cross-sectional area of the sidebox("aerodynamic elements between the wheels")
from the side view of the car, while the car is standing, if the wheelbase is 1,550 mm, and we have 16"
(OD)tires? Give your answer in m²!
A) 0.497m²
B) 0.375m²
C) 0.467m²
D) 0.934m²

10) To which level has the pre-charge circuit to pre-charge the intermediate circuit?
A) It is not specified by the rules but it is a good engineering practice to pre-charge at least to 50% of the actual
TS accumulator voltage.
B) To the actual TS accumulator voltage.
C) To 95% of the maximum TS accumulator voltage.
D) To 95% of the actual TS accumulator voltage.

11) When was the 1st Formula One Grand Prix held at the Hungaroring and who won the race?
A) 1986., Nelson Piquet
B) 1988., Ayrton Senna
C) 1985., Ayrton Senna
D) 1985., Nelson Piquet

12) Where can you find the following racetrack?

A) Chile

https://quiz.fseast.eu 2/3
27/01/23, 10:58 Formula Stundent East registration QUIZ 2023
B) Brazil
C) USA
D) Australia

13) What is the minimum distance between the driver and a radiator in the cooling system, if its surface
temperature is 80 ˚C?
A) 25.4 mm
B) 33 mm
C) 25 mm
D) 33.1 mm

14) According to VDI 2221 regarding the design of a product which of the following steps has to
be completed first?
A) Elemental solutions
B) Concept evaluation
C) Requirements
D) Function structure

15) Your „Build ECU” task should start on 25 January 2023 and should end on 01 March 2023. Today is 27
January 2023 (end of the day), and you have completed 5% of the planned work. Your team allocated
325000 USD for this task. In your project plan, you planned to work every day. The amount of work on every
weekday is the same, but you planned to work twice as much on the weekends. You have spent 30000 USD.
What is the SPI of this task?
A) 1.3
B) 1.41
C) 0.77
D) 0.09

Submit answers

https://quiz.fseast.eu 3/3

You might also like