Professional Documents
Culture Documents
Control panel
Door button
Press here to open door. The door can only
be opened if the power is on.
Instrument
Washer Disinfector
Status indicators
Pre-wash
WASH
Wash
RINSE
Rinse
DISINFECT
Disinfection
COMPLETE
!
Start button
Press once to start the program or to pause an
ongoing program.
Push the basket into the washing chamber and check that it touches the
coupling at the back of the washing chamber.
Close the door; then push the start button to activate a washing program.
! The door is locked throughout the program sequence. Do not try to
force the door open!
When the program is done, the door opens - approx. 30mm , thereby
allowing vapours to escape and the items to dry (the heat from the items
will make the water evaporate).
Note! Be careful if you remove the items just after the program has
! ended. If the program includes disinfection, the items will be hot!
Operating disturbances In case of error in the program sequence, the program will stop and the
display will show the error.
Press the start button to acknowledge receipt of the error message. Drain
the water out of the Washer; the door can now be opened.
The items are not disinfected correct the error and restart the
Washer!
! Regarding error types and remedial action, cf. the Instruction Manual.
Washing programs
IWD 1 and IWD 2 offer up to 6 different programs. Programs 1 to 4 are the
wash program options. Programs 5 and 6 are test and demonstration
programs that may not be used as wash programs. Programs 3 and 4 comply
with EN15883 recommendations regarding disinfection.
Program change Use the following procedure for program change: Load Instruments
1. Display must show message shown in this frame. Press START
Open door by pressing door button.
5. Press the door button to save the change and leave the menu.
When a program has been selected, this program will be used until the
procedure is repeated and another choice made.
We recommend using program 3 as the default program.