Professional Documents
Culture Documents
Radius AAA Configuration v1.0
Radius AAA Configuration v1.0
Version 1.0
Status
Date 23-Jan-24
Security
Reference 745238126.docx
Copyright © Mavenir 2024. All rights reserved. This document is protected by international copyright law and may not be
reprinted, reproduced, copied or utilised in whole or in part by any means including electronic, mechanical, or other means
without the prior written consent of Mavenir.
Radius Configuration Tune up
Whilst reasonable care has been taken by Mavenir to ensure the information contained herein is reasonably accurate, Mavenir
shall not, under any circumstances be liable for any loss or damage (direct or consequential) suffered by any party as a result
of the contents of this publication or the reliance of any party thereon or any inaccuracy or omission therein. The information in
this document is therefore provided on an “as is” basis without warranty and is subject to change without further notice and
cannot be construed as a commitment by Mavenir.
The products mentioned in this document are identified by the names, trademarks, service marks and logos of their respective
companies or organisations and may not be used in any advertising or publicity or in any other way whatsoever without the
prior written consent of those companies or organisations and Mavenir.
E & OE
Table of Contents
1. Introduction.........................................................................................................5
1.1. Scope..................................................................................................................................... 5
1.2. Intended Audience................................................................................................................. 5
1.3. Prerequisites.......................................................................................................................... 5
2. R&D suggested radius configuration...............................................................6
Document control
Owner: Ranjit Tarade Title: Sr Deployment Engineer
Approved by: Nazmul Alam Title: Technical Lead
Approved by: Title:
Other Information:
1. Introduction
1.1. Scope
This document provides the necessary technical detail of radius configuration modification done on
vSAEGW during radius failover to test case performed at ELI site installed at the FMG.
1.3. Prerequisites
Before the configuration is attempted the following activities should be completed:
Basic call flow is working after radius failover.
Ensure radius peer status state (connected/dis-connected) change during AAA failover.
Network
Element vSAEGW
Context Radius parameters (Auth/Acct) tune up for failover scenarios
radius accounting server 10.231.146.213 port 1813 secret-key M@v3n1R!% acct-on enable acct-off disable 1
radius accounting server 10.231.146.214 port 1813 secret-key M@v3n1R!% acct-on enable acct-off disable 2
Authentication Parameter:
radius authentication max-retries 1 <if an access request gets timed out from server, it will
retry max 1 times >
radius authentication max-outstanding 255 <This is max queue size or number of messages
which can be queued max >
radius authentication response-timeout 2 < CDF sends an access request to selected radius
server and start a timer of 2 sec and wait for response, if no response is received within 2
sec, it will be considered as timeout >
radius authentication deadtime 60 <If there is no response received in defined time for any
of request from selected server, server will marked as dead for configured dead timer(60
min). During this 60 min, no request will go to this dead marked server. Upon dead timer
expiry, server state will be marked as active again>