ENGINE CONTROL SYSTEM (4JK1/4JJ1-TRANSTRON System) 6E-273
DTC U0167 (Flash Code 177) Circuit Description Action Taken When the DTC Sets The ECM communicates with the immobilizer control • The ECM will not illuminate the MIL or SVS lamp. unit (ICU) to execute immobilizer function. The ECM Refer to DTC Type Definitions for Action Taken sends request signal to the ICU. The ECM receives When the DTC Sets - Type D. response signal from the ICU. Both communication signals are carried out via a controller area network Condition for Clearing the DTC (CAN) communication bus. If the ECM does not detect • Refer to DTC Type Definitions for Condition for a response signal from the ICU, this DTC will set. Clearing the DTC - Type D.
Condition for Setting the DTC Diagnostic Aids
• The ECM does not receive an immobilizer • If an intermittent condition is suspected, refer to response signal from the ICU. Intermittent Conditions in this section. • Electromagnetic interference may affect intermittent condition. • Any communication fault with the ICU may set this DTC.
Circuit/ System Testing DTC U0167
Step Action Value(s) Yes No
Did you perform the Diagnostic System Check - Go to Diagnostic 1 Engine Controls? — System Check - Go to Step 2 Engine Controls 1. Install a scan tool. 2. Turn OFF the ignition for 30 seconds. 2 3. Turn ON the ignition, with the engine OFF. — 4. Monitor the DTC Information with a scan tool.
Is DTC U0001 also set? Go to DTC U0001 Go to Step 3
Attempt to communicate with the immobilizer Go to Diagnostic control unit (ICU) via the Immobilizer Data table. System Check - 3 — Immobilizer Does the scan tool communicate with the ICU? Go to Step 4 Controls Monitor the immobilizer DTC Information with a scan tool. 4 — Go to Applicable Does the immobilizer DTCs fail this ignition which DTC in Immobilizer begin with B or U? Section Go to Step 5 Important: Replacement ECM must be programmed and learned. 5 Replace the ECM. Refer to ECM Replacement. —
Did you complete the replacement? Go to Step 6 —
1. Clear the DTCs with a scan tool. 2. Turn OFF the ignition for 30 seconds. 6 — 3. Turn ON the ignition, with the engine OFF.
Did the DTC fail this ignition? Go to Step 2 Go to Step 7
Observe the DTC Information with a scan tool. 7 — Are there any DTCs that you have not diagnosed? Go to DTC List System OK