Professional Documents
Culture Documents
2. For Q1, calculate the safe load capacity of pile if water table is now located at 2m below the
ground level.
3. A 15m long, 400mm diameter was driven in a homogeneous clay with unconfined compressive
strength of 75kPa. Calculate the ultimate load capacity of the pile.
4. A pile of 400mm diameter and 18.5m long passes through two layers of clay and is embedded in
a third layer (see Fig. 1). Calculate the safe load capacity of the pile (if FOS =2.5).
5. A 40 x 40 cm reinforced concrete pile 20 m long is driven through loose sand and then into
dense gravel to a final set of 3 mm/blow, using a 30 kN single-acting hammer with a stroke of
1.5 m. Determine the ultimate driving resistance of the pile if it is fitted with a helmet, plastic
dolly and 50 mm packing on the top of the pile. The weight of the helmet and dolly is 4 kN. The
other details are: weight of pile = 74 kN; weight of hammer = 30 kN; pile hammer efficiency =
0.80 (i.e. effective fall of hammer is 80% of the fall of normally proportioned winch-operated
drop hammer); and coefficient of restitution e = 0.40. Use the Modified Hiley formula.
[Hint : The sum of the elastic compression C is C = c1 +c2 +c3 = 19.6 mm]
6. For pile load test data shown below, plot the load-settlement curve and estimate the allowable
load of the pile as per IS code 2911 Part 3(2013), if diameter is 300mm diameter and length is
10m.