Professional Documents
Culture Documents
Update Log-4 - 4PRO
Update Log-4 - 4PRO
53
If your NEPTUNE 4/4PRO firmware version is lower than 1.1.2.53, it is recommended
to update the fix pack first to avoid compatibility issues and errors. Please
refer to
the "Firmware Update Instructions" for the fix pack usage steps.
Tip:Using the fix pack will automatically delete the contents in the task list
If you are used to uploading print files on the web side for printing, please note:
To ensure that the system has enough memory to update the fix pack, this update
will automatically delete the contents of the task list in the local memory.
If necessary, please back up in advance.
2. Optimization: Ensured that the web interface has permission to save Z-offset.
6.(Applicable to main control board K1 V1.1) Added support for controlling soc gpio
sled1 and sled2 via the web interface.
Simply add the macros in the printer.cfg file, as shown below: (Note: the macros
have been added to the printer.cfg file, uncomment to use)
[gcode_macro FLASHLIGHT_SWITCH]
description: Switch Hotend LEDs
gcode:
RUN_SHELL_COMMAND CMD=FLASHLIGHT
[gcode_shell_command FLASHLIGHT]
command: sh /home/mks/sled2.sh
timeout: 5.
[gcode_macro MODLELIGHT_SWITCH]
description: Switch Logo LEDs
gcode:
RUN_SHELL_COMMAND CMD=MODLELIGHT
[gcode_shell_command MODLELIGHT]
command: sh /home/mks/sled1.sh
timeout: 5.