Professional Documents
Culture Documents
Composición Characteristics
BURÉS PROFESIONAL, S.A. has created the wood chip Characteristics Unit Value
biofilter product from a mixture of different chip particle
sizes, treating it in the plant to obtain a material that can Moisture (%) 40 - 60
absorb odoriferous compounds and other pollutants from the pH - 4.5 - 5.6
residual air stream. The free-living microorganisms that
proliferate naturally in this organic material use these Particle size (mm) (mm) 10 - 45
compounds as a source of nutrients and energy, via aerobic Porosity (%) 67-71
decomposition.
Organic matter OM (%) 40 - 50
The high-efficiency and long-shelf-life biofilter is created Real density (Kg/m3) 200 - 250
from pine chips made from the following species:
Moisture bulk
density (Kg/m3) 220 - 330
Density UNE-EN12580
SPECIES %
(g/cm3)
Electrical
(dS/m) 0,1-0,5
Pinus nigra 39 0.62 conductivity
Pinus sylvestris 46 0.55 Cationic Exchange
(meq/100gr) 43.6
Capacity (CIC)
Pinus uncinata 6.5 0.07
Water retention (Water at 10 cm
Buena
Pinus pinaster/ capacity a.c.) (%)
1.5 0,08-0,10
Pinus radiata
(Air at 10 cm
Aeration capacity 20 - 30
Other (Picea, Abies, a.c.) (%)
7 -
etc.)
Shelf life (years) 5
TOTAL 100 - Types of COV’S
microorganisms - H2S
that eliminate NH4
The filling materials undergo a pre-treatment process
Total nitrogen (%) 0.5 - 1
(crushing and screening) that increases their surface area
and enables the microorganisms to more effectively colonise Total Phosphorus,
(%) < 50 mg/l
the medium. P2O5
Total Potassium,
(%) < 50 mg/l
K2O
Total Sodium, NaO (%) 0.6
C/N ratio (%) 10.31
Página 1 de 2
gases to be purified and the microorganisms. This results in This product can be used as a filling material, or as a layer of
greater processing efficiency and a lower need for retention a multilayer biofiltration.
time. The average pore radius ranges from 200 to 2,000 nm. Biofiltration is a very versatile technique, able to treat odours
(ammoniac…), toxic compounds and volatile organic
Burés biofiltration materials are extremely stable, with very compounds.
slow physical and microbiological alteration of their The efficiency of the treatment of this elements is higher
properties over time, so there is practically no compaction of than 90-95% for low contaminant concentration
the bedding in the long term. (<1.00ppm).
The biofilters offered by BURÉS PROFESIONAL, S.A. are
EDAR
Appropriate physical and chemical conditions must be Composting plants
created and preserved to allow the microbiotic proliferation Dump areas
on the filling material. The essential parameters are Chemical industry
temperature, pH, moisture and nutrient quantity. Alimentary industry
Water cleansing
Moisture Smoking industry
One of the main challenges of a biofilter care is maintaining Paper industry
the right moisture point. The air is usually moistured before Pharmaceutical industry
entering the system with a water nebulisation system, Furniture industry
moistening chamber, bioscrubber or biological hydrofilter. Painting and recovering application
The moisture depends on the material, but always oscillates Resinous materials treatment
in the 50-70% range. Leather treatment
Página 2 de 2