Professional Documents
Culture Documents
March 2026-1
March 2026-1
KIMBERLEY THS
Eksaminator: G. Louw Moderator: D. Fourie
GRADE 11
GRAAD 11
TECHNOLOGY MOTOR
TEGNOLOGIE MOTOR
MARCH 2026
MAART 2026
Marks: 50
Punte: 50
Time: 1 Hour
Tyd: 1 Uur
1
INSTRUCTION AND INFORMATION
50
2
QUESTION 1
MULTIPLE-CHOICE QUESTIONS
Various possible options are provided as answers to the following questions. Choose the correct answer and write
only the letter .
1.2 Which of the following is not a safety precaution when using a drill press?
A. Choose the correct sharpened drill for the type of work and material to be drilled
B. Drilling can take place at any speed
C. Never leave the machine to run unattended
D. Clamp the workpiece securely to the table and do not hold it by hand (1)
1.3 Which of the following sizes is the correct drill size to cut thread for a M10 x 1 bolt?
A. 9.0 mm
B. 8.9 mm
C. 9.2 mm
D. 9.5 mm (1)
1.4 Complete the sentence. A hydraulic press depends on __________ principle to operate.
A. Ohms
B. Newtons
C. Pascal's
D. Mac Phersons (1)
1.5 Which of the following equipment cannot measure inside or outside diameters?
A. Outside micrometer
B. Dial indicator
C. Inside micrometer
D. Vernier calliper (1)
A. No danger of valves falling into the engine and damaging the engine
B. The diameters of the valve heads are limited
C. Few components in the valve mechanism
D. Valve mechanism is less complicated (1)
3
1.8 Which of the following is not a disadvantage of cam belts?
QUESTION 2
SAFETY(GENERIC)
2.1 Name TWO points that are part of the Labour Relations Act. (2)
2.2 Name TWO safety precautions that have to be followed when using gas welding equipment. (2)
2.3 Give TWO safety precautions when using a drill press. (2)
2.4 Name TWO safety precautions when using a hydraulic press (2)
[8]
QUESTION 3
TOOLS(GENERIC)
3.1 Name the parts of the pedestal grinder, labelled A-H, in the figure below. (8)
[8]
4
QUESTION 4
TOOLS(SPECIFIC)
4.2 Give the dimensions shown in the figures below and write them down as numbered below. (3)
1.3 Reading :
4.3 Give the dimensions shown in the figures below and write them down in their respective
spaces provided.
1.4 Reading :
[8]
QUESTION 5
ENGINES (SPECIFIC)
5
5.3 Give TWO advantages of electromagnetic or solenoid injectors. (2)
a. Valve overlap
b. Valve lead
c. Valve lag (8)
5.6 In the figure of the pistons, labelled A - B, which is for direct injection and indirect injection? (2)
[18]
TOTAL 50