Professional Documents
Culture Documents
CRT4636
DEH-5300UB/XNUC
CD RDS RECEIVER
DEH-5300UB /XNUC
DEH-5350UB /XNES1
DEH-5350UB /XNES
This service manual should be used together with the following manual(s):
Model No. Order No. Mech. Module Remarks
CX-3269 CRT4488 S11.1STD-DOUT CD Mech. Module : Circuit Descriptions, Mech. Descriptions, Disassembly
SAFETY INFORMATION
A CAUTION
This service manual is intended for qualified service technicians; it is not meant for the casual do-it-yourselfer.
Qualified technicians have the necessary test equipment and tools, and have been trained to properly and safely repair
complex products such as those covered by this manual.
Improperly performed repairs can adversely affect the safety and reliability of the product and may void the warranty.
If you are not qualified to perform the repair of this product properly and safely, you should not risk trying to do so
and refer the repair to a qualified service technician.
WARNING
This product may contain a chemical known to the State of California to cause cancer, or birth defects or
other reproductive harm.
B Health & Safety Code Section 25249.6 - Proposition 65
CAUTION:
USE OF CONTROLS OR ADJUSTMENTS OR PERFORMANCE OF PROCEDURES OTHER THAN THOSE
SPECIFIED HEREIN MAY RESULT IN HAZARDOUS RADIATION EXPOSURE.
CAUTION
D This product is a class 1 laser product classi-
fied under the Safety of laser products, IEC
60825-1:2007, and contains a class 1M laser
module. To ensure continued safety, do not re-
move any covers or attempt to gain access to
the inside of the product. Refer all servicing to
qualified personnel.
WARNING!
The AEL (accessible emission level )of the laser power output is less than CLASS 1
but the laser component is capable of emitting radiation exceeding the limit for
CLASS 1.
A specially instructed person should do servicing operation of the apparatus.
DEH-5300UB/XNUC
2
1 2 3 4
5 6 7 8
CAUTION
Danger of explosion if battery is incorrectly replaced.
Replaced only with the same or equivalent type recommended by the manufacture.
Discord used batteries according to the manufacture's instructions.
DEH-5300UB/XNUC
5 6 7 8
3
1 2 3 4
Please follow the specified safety methods when modification(addition/change of parts) is required due to interferences such as
B radio/TV interference and foreign noise.
When you solder while repairing, please be sure that there are no cold solder and other debris.
Soldering should be finished with the proper quantity. (Refer to the example)
Please be sure that all screws are fastened, and that there are no loose screws.
Please be sure that all connectors are inserted, and that there are no imperfect insertion.
6 Make sure the wiring cables are set to their original state.
C
Please replace the wiring and cables to the original state after repairs.
In addition, be sure that there are no pinched wires, etc.
7 Make sure screws and soldering scraps do not remain inside the product.
Please check that neither solder debris nor screws remain inside the product.
8 There should be no semi-broken wires, scratches, melting, etc. on the coating of the power cord.
Damaged power cords may lead to fire accidents, so please be sure that there are no damages.
If you find a damaged power cord, please exchange it with a suitable one.
When spark traces or similar marks are found on the power supply plug, please check the connection and advise on secure
D connections and suitable usage. Please exchange the power cord if necessary.
When you perform repairs, please pay attention to static electricity, furniture, household articles, etc. in order to prevent injuries.
Please pay attention to your surroundings and repair safely.
2. Adjustments
To keep the original performance of the products, optimum adjustments and confirmation of characteristics within specification.
Adjustments should be performed in accordance with the procedures/instructions described in this manual.
4. Cleaning
For parts that require cleaning, such as optical pickups, tape deck heads, lenses and mirrors used in projection monitors, proper
cleaning should be performed to restore their performances.
DEH-5300UB/XNUC
4
1 2 3 4
5 6 7 8
CONTENTS
SAFETY INFORMATION .....................................................................................................................................2
1. SERVICE PRECAUTIONS................................................................................................................................6
1.1 SERVICE PRECAUTIONS .........................................................................................................................6 A
1.2 NOTES ON SOLDERING ...........................................................................................................................8
2. SPECIFICATIONS.............................................................................................................................................9
2.1 SPECIFICATIONS ......................................................................................................................................9
2.2 DISC/CONTENT FORMAT .......................................................................................................................10
2.3 PANEL FACILITIES...................................................................................................................................11
2.4 CONNECTION DIAGRAM........................................................................................................................12
3. BASIC ITEMS FOR SERVICE ........................................................................................................................14
3.1 CHECK POINTS AFTER SERVICING .....................................................................................................14
3.2 PCB LOCATIONS .....................................................................................................................................14
3.3 JIGS LIST .................................................................................................................................................15
3.4 CLEANING ...............................................................................................................................................15
4. BLOCK DIAGRAM ..........................................................................................................................................16 B
4.1 BLOCK DIAGRAM....................................................................................................................................16
5. DIAGNOSIS ....................................................................................................................................................18
5.1 OPERATIONAL FLOWCHART .................................................................................................................18
5.2 ERROR CODE LIST.................................................................................................................................19
5.3 CONNECTOR FUNCTION DESCRIPTION .............................................................................................21
6. SERVICE MODE.............................................................................................................................................22
6.1 DISPLAY TEST MODE .............................................................................................................................22
6.2 CD TEST MODE.......................................................................................................................................23
7. DISASSEMBLY ...............................................................................................................................................24
8. EACH SETTING AND ADJUSTMENT ............................................................................................................28
8.1 CD ADJUSTMENT ...................................................................................................................................28
C
8.2 CHECKING THE GRATING AFTER CHANGING THE PICKUP UNIT ....................................................29
8.3 PCL OUTPUT CONFIRMATION...............................................................................................................31
9. EXPLODED VIEWS AND PARTS LIST ..........................................................................................................32
9.1 PACKING ..................................................................................................................................................32
9.2 EXTERIOR ...............................................................................................................................................34
9.3 CD MECHANISM MODULE .....................................................................................................................36
10. SCHEMATIC DIAGRAM................................................................................................................................38
10.1 TUNER AMP UNIT (GUIDE PAGE) ........................................................................................................38
10.2 KEYBOARD UNIT ..................................................................................................................................44
10.3 CD CORE UNIT (S11.1STD-DOUT) ......................................................................................................46
10.4 PANEL UNIT ...........................................................................................................................................48
10.5 WAVEFORMS.........................................................................................................................................49 D
11. PCB CONNECTION DIAGRAM ....................................................................................................................52
11.1 TUNER AMP UNIT .................................................................................................................................52
11.2 KEYBOARD UNIT ..................................................................................................................................56
11.3 CD CORE UNIT (S11.1STD-DOUT) ......................................................................................................58
11.4 PANEL UNIT ...........................................................................................................................................60
12. ELECTRICAL PARTS LIST ...........................................................................................................................61
DEH-5300UB/XNUC
5 6 7 8
5
1 2 3 4
1. SERVICE PRECAUTIONS
1.1 SERVICE PRECAUTIONS
A
1. You should conform to the regulations governing the product (safety, radio and noise, and other
regulations), and should keep the safety during servicing by following the safety instructions
described in this manual.
2. Before disassembling the unit, be sure to turn off the power. Unplugging and plugging the connectors
during power-on mode may damage the ICs inside the unit.
3. To protect the pickup unit from electrostatic discharge during servicing, take an appropriate treatment
(shorting-solder) by referring to "the DISASSEMBLY".
4. After replacing the pickup unit, be sure to check the grating.
5. Be careful in handling ICs. Some ICs such as MOS type are so fragile that they can be damaged by
electrostatic induction.
B 6. area and a heat sink becomes hot areas. Be careful not to burn yourself.
D 7. Software update
The software of this product is stored in IC671.
Please replace IC671 when making the version upgrade of software.
8. How to Handle Infrared Deteching unit for Remote Control of Grille
The infrared deteching unit for remote control of keyboard unit is not fixed with cushion, etc.
When external force is applied on the infrared deteching unit for remote control, the light receiving sensitivity might be
deteriorated since the lead bents and attaching angle of the light receiving part may be varied.
Please do not apply external force onto the infrared deteching unit for remote control. If any external force is applied by
mistake, please confirm whether lead bending may exist or not.
If the lead is bent, please correct the angle between the lead and the light receiving part to be 90 degrees or replace
the infrared deteching unit for remote control (GP1UXC14RK).
E
DEH-5300UB/XNUC
6
1 2 3 4
5 6 7 8
OK NG
C
DEH-5300UB/XNUC
5 6 7 8
7
1 2 3 4
For environmental protection, lead-free solder is used on the printed circuit boards mounted in this unit.
A Be sure to use lead-free solder and a soldering iron that can meet specifications for use with lead-free solders for repairs
accompanied by reworking of soldering.
Compared with conventional eutectic solders, lead-free solders have higher melting points, by approximately 40 C.
Therefore, for lead-free soldering, the tip temperature of a soldering iron must be set to around 373 C in general, although
the temperature depends on the heat capacity of the PC board on which reworking is required and the weight of the tip of
the soldering iron.
Compared with eutectic solders, lead-free solders have higher bond strengths but slower wetting times and higher melting
temperatures (hard to melt/easy to harden).
DEH-5300UB/XNUC
8
1 2 3 4
5 6 7 8
2. SPECIFICATIONS
2.1 SPECIFICATIONS
A
• DEH-5300UB/XNUC
General
Power source.............................14.4 V DC (10.8 V to 15.1 V WMA decoding format .........Ver. 7, 7.1, 8, 9, 10, 11, 12
allowable) (2ch audio)
Grounding system...................Negative type (Windows Media Player)
Maximum current consumption MP3 decoding format ...........MPEG-1 & 2 Audio Layer 3
.....................................................10.0 A WAV signal format ..................Linear PCM & MS ADPCM
Backup current .......................4.0 mA or less (Non-compressed)
Dimensions (W × H × D):
DIN USB
Chassis .....................178 mm × 50 mm × 165 USB standard specification
mm .....................................................USB 2.0 full speed
(7 in. × 2 in. × 6-1/2 in.) Maximum current supply .... 500 mA B
Nose ...........................188 mm × 58 mm × 17 mm USB Class...................................MSC (Mass Storage Class)
(7-3/8 in.× 2-1/4 in.× 5/8 in.) File system..................................FAT12, FAT16, FAT32
D WMA decoding format .........Ver. 7, 7.1, 8, 9, 10, 11, 12
Chassis .....................178 mm × 50 mm × 165 (2ch audio)
mm (Windows Media Player)
(7 in.× 2 in.× 6-1/2 in.) MP3 decoding format ...........MPEG-1 & 2 Audio Layer 3
Nose ...........................170 mm × 46 mm × 17 mm WAV signal format ..................Linear PCM & MS ADPCM
(6-3/4 in.× 1-3/4 in.× 5/8 in.) (Non-compressed)
Weight ..........................................1.3 kg (2.9 lbs)
FM tuner
Audio Frequency range......................87.5 MHz to 108.0 MHz
Maximum power output .......50 W × 4 Usable sensitivity.....................9 dBf (0.8 µV/75 Ω, mono,
Continuous power output ... 22 W × 4 (50 Hz to 15 000 S/N: 30 dB)
Hz, 5 % THD, 4 Ω load, both Signal-to-noise ratio...............72 dB (IHF-A network)
channels driven) C
Load impedance ......................4 Ω (4 Ω to 8 Ω allowable) AM tuner
Preout maximum output level Frequency range......................530 kHz to 1 710 kHz
.....................................................2.0 V Usable sensitivity.....................25 µV (S/N: 20 dB)
Tone controls: Signal-to-noise ratio...............62 dB (IHF-A network)
Bass
Frequency................100 Hz CEA2006 Specifications
Gain ............................±12 dB
Mid
Frequency................1 kHz
Gain ............................±12 dB
Treble
Frequency................10 kHz
Gain ............................±12 dB Power output .............................14 W RMS × 4 Channels (4
Subwoofer (mono): Ω and <
= 1 % THD+N) D
Frequency..........................50/63/80/100/125 Hz S/N ratio .......................................91 dBA (reference: 1 W into
Slope....................................–18 dB/oct 4 Ω)
Gain ......................................+6 dB to –24 dB
Phase ..................................Normal/Reverse Note
Specifications and the design are subject to mod-
CD player
System ..........................................Compact disc audio system ifications without notice.
Usable discs ..............................Compact disc
Signal-to-noise ratio...............94 dB (1 kHz) (IHF-A net-
work)
Number of channels ..............2 (stereo)
DEH-5300UB/XNUC
5 6 7 8
9
1 2 3 4
A
• DEH-5350UB/XNES, XNES1
General
Rated power source...............14.4 V DC WAV signal format ..................Linear PCM & MS ADPCM
(allowable voltage range: (Non-compressed)
12.0 V to 14.4 V DC)
Grounding system...................Negative type USB
Maximum current consumption USB standard specification
.....................................................10.0 A .....................................................USB 2.0 full speed
Backup current .......................4.0 mA or less Maximum current supply .... 500 mA
Dimensions (W × H × D): USB Class...................................MSC (Mass Storage Class)
DIN File system..................................FAT12, FAT16, FAT32
Chassis .....................178 mm × 50 mm × 165 WMA decoding format .........Ver. 7, 7.1, 8, 9, 10, 11, 12
mm (2ch audio)
B Nose ...........................188 mm × 58 mm × 17 mm (Windows Media Player)
D MP3 decoding format ...........MPEG-1 & 2 Audio Layer 3
Chassis .....................178 mm × 50 mm × 165 WAV signal format ..................Linear PCM & MS ADPCM
mm (Non-compressed)
Nose ...........................170 mm × 46 mm × 17 mm
Weight ..........................................1.3 kg FM tuner
Frequency range......................87.5 MHz to 108.0 MHz
Audio Usable sensitivity.....................9 dBf (0.8 µV/75 Ω, mono,
Maximum power output .......50 W × 4 S/N: 30 dB)
Continuous power output ... 22 W × 4 (50 Hz to 15 000 Signal-to-noise ratio...............72 dB (IEC-A network)
Hz, 5 % THD, 4 Ω load, both
channels driven) AM tuner
Load impedance ......................4 Ω (4Ω to 8Ω allowable) Frequency range......................531 kHz to 1 602 kHz (9 kHz)
Preout maximum output level 530 kHz to 1 640 kHz (10
C .....................................................2.0 V kHz)
Tone controls: Usable sensitivity.....................25 µV (S/N: 20 dB)
Bass Signal-to-noise ratio...............62 dB (IEC-A network)
Frequency................100 Hz
Gain ............................±12 dB Infrared remote control
Mid Wavelength.................................940 nm ±50 nm
Frequency................1 kHz Output ...........................................typ; 12 mw/sr per Infrared
Gain ............................±12 dB LED
Treble
Frequency................10 kHz Note
Gain ............................±12 dB Specifications and the design are subject to mod-
Subwoofer (mono):
ifications without notice.
Frequency..........................50/63/80/100/125 Hz
Slope....................................–18 dB/oct
Gain ......................................+6 dB to –24 dB
D
Phase ..................................Normal/Reverse
CD player
System ..........................................Compact disc audio system
Usable discs ..............................Compact disc
Signal-to-noise ratio...............94 dB (1 kHz) (IEC-A net-
work)
Number of channels ..............2 (stereo)
WMA decoding format .........Ver. 7, 7.1, 8, 9, 10, 11, 12
(2ch audio)
(Windows Media Player)
MP3 decoding format ...........MPEG-1 & 2 Audio Layer 3
DEH-5300UB/XNUC
10
1 2 3 4
5 6 7 8
A
Head unit Press to mute. Press again to un-
f MUTE
mute.
1 23 45
g AUDIO Press to select an audio function.
d Display indication
1
Part Part
1 S (SRC/OFF) 8 ///
2 (list) 9 (clock) (DEH-5300UB/XNUC)
/DISP OFF (DEH-5350UB//XNES) C
23 6 8 9
3
MULTI-CONTROL
a 1 to 6 45 7 a b
(M.C.)
Indicator State
AUX input jack (3.5
4 USB port b
mm stereo jack) Tuner: band and frequency
Main dis- Program service name (DEH-5350UB//XNES)
5 Open button c Disc loading slot 1 play sec-
Built-in CD, USB storage de-
tion
6 B (BAND/ESC) d (eject) vice and iPod: elapsed play-
back time and text
(Back/display/
7 information
scroll)
An upper tier of the folder or
2
menu exists.
CAUTION
D
Use an optional Pioneer USB cable (CD-U50E) A lower tier of the folder or menu exists.
This flashes when a song/album
to connect the USB audio player/USB mem- 3
related to the song currently play-
ory as any device connected directly to the ing is selected from the iPod.
unit will protrude out from the unit and may
The list function is being oper-
be dangerous. 4 (list)
ated.
To avoid a malfunction, make sure that no
The artist name is displayed.
metal objects come into contact with the
5 (artist) Artist search refinement of the
terminals when the front panel is open. iPod browsing function is in use.
Do not use unauthorized products.
The disc (album) name is dis-
played.
Remote control 6 (disc)
Album search refinement of the
iPod browsing function is in use.
e E
The track (song) name is dis-
played.
A playable audio file has been se-
7 (song)
lected during operation of the list.
6 f Song search refinement of the
k 8 iPod browsing function is in use.
i (ran-
Random play is on.
The iPod source is selected and
a dom/shuf-
the shuffle or shuffle all function
fle)
is on.
Part Operation F
The sound retriever function is
Press to increase or decrease vo- b (sound re-
e VOLUME on.
lume. triever)
DEH-5300UB/XNUC
5 6 7 8
11
1 2 3 4
A
This unit
1 2 3 4 Front speaker
5 Rear speaker
6 White
7 White/black
8 Gray
4 5 6 9 Gray/black
1 Power cord input a Green
2 Rear output or subwoofer output b Green/black
3 Front output c Violet
4 Antenna input d Violet/black
B
5 Fuse (10 A) e Black (chassis ground)
6 Wired remote input Connect to a clean, paint-free metal location.
Hard-wired remote control adaptor can be f Yellow
connected (sold separately). Connect to the constant 12 V supply terminal.
g Red
Connect to terminal controlled by ignition
Power cord switch (12 V DC).
Perform these connections when not connect- h Blue/white
ing a rear speaker lead to a subwoofer. Connect to system control terminal of the
power amp or auto-antenna relay control
L 1 R terminal (max. 300 mA 12 V DC).
2 3 i Subwoofer (4 Ω)
C 4 j When using a subwoofer of 70 W (2 Ω), be
6 8
F 7 9 sure to connect the subwoofer to the violet
and violet/black leads of this unit. Do not con-
5 nect anything to the green and green/black
a c
R b d leads.
k Not used.
l Subwoofer (4 Ω)× 2
e
f Notes
g
h With a 2 speaker system, do not connect any-
thing to the speaker leads that are not con-
Perform these connections when using a sub- nected to speakers.
D
woofer without the optional amplifier. Change the initial setting of this unit. Refer to
SW CONTROL (rear output and subwoofer set-
L 1 R ting).
2 3 The subwoofer output of this unit is monaural.
4
6 8
F 7 9
Power amp (sold separately)
i a c Perform these connections when using the
SW
b d optional amplifier.
1 3
e j 2
f a c
4
E g k l 5 5
h b d
3
1 2
1 To power cord input 6
2 Left 7 7
3 Right
DEH-5300UB/XNUC
12
1 2 3 4
5 6 7 8
A
Fastening the front panel
If you do not plan to detach the front panel,
the front panel can be fastened with supplied
screws and holders.
1 Holder
UC : CND1249, CND1250
ES1, ES : CXX1644, CXX1645
2 Replace the front panel to the unit.
1 Screw
UC : BPZ20P060FTC E
ES1, ES : XXX7020
DEH-5300UB/XNUC
5 6 7 8
13
1 2 3 4
See the table below for the items to be checked regarding audio:
B Keyboard Unit
F
D Panel Unit
DEH-5300UB/XNUC
14
1 2 3 4
5 6 7 8
- Jigs List
A
Name Jig No. Remarks
16P FFC GGD1310 Tuner Amp Unit - CD Core Unit
Test Disc TCD-782 Checking the grating
L.P.F. Checking the grating (Two pieces)
Acetate Tape GYH1026 Capacitor Bond Lock
- Grease List
Name Grease No. Remarks B
Grease GEM1024 CD Mechanism Module
Grease GEM1038 CD Mechanism Module
Grease GEM1043 CD Mechanism Module
Grease GEM1045 CD Mechanism Module
Silicon Glue GEM1017 Capacitor Bond Lock
3.4 CLEANING
DEH-5300UB/XNUC
5 6 7 8
15
1 2 3 4
4. BLOCK DIAGRAM
4.1 BLOCK DIAGRAM
A
A TUNER AMP UNIT
JA401
1 5
ANTENNA FMMIXIN1
DACOUTL 57
16
2,3 PINDIN
18
LNAIN
RF FRONT END IC
IC401
TDA7706
34 112 TUNSCL
I2CSCL DAC
I2CSDA
33 111
TUNSDA IC231
31 107
PCM1753DBQ
RSTN TUNPCE1
91 1
DACSCK BCK
88 2
DACDATA DATA
87 13
DACBDATA MD
85 14 7
B DACBSCK MC VOUTL
JA961 AUDIO_XOUT
84 16
SCK
2 KEYAD 69 89 3
KEYAD DACLRCK LRCK
WIRED 3 KEYD 129 124 15
KEYD DACCS ML
REMOTE 1 GND
RESET
iPod CP
IC551 RES 38 1 IC651
341S2162 S-80827CNMC-B8M
Q551
2
MODE1 VDD3.3V
5
VCC
118 CPPWR
ILMPW
Q873
B.UP ILM+B
12 114
I2C_SCL CP_SCL
I2C_SDA 13 113 CP_SDA
C 4 116 Q872
nRESET CPRST
132
ILMPW
SYST
CO
SYSTEM MICRO
COMPUTER
IC601 REGULATOR IC R5S72
FLASH ROM (1/2) IC912
IC671 R5S7266ZD144FP BA49182-V12
11 128 SWVDD
UC : PEA012A8 6 VDDCONT
ES : PEA011A8 SW5V SW5V 1 141
BSENS BSENS
9
SWVDD SWVDD 2 7 SYSPW
5 SYSPW
SYS+B SYS+B 3
SW5VCNT
7
VDD3.3V VDD
8 +B 4
VDD1.2V VDD12 B.UP
10
+BUP
D PICKUP UNIT
(P10.5)(SERVICE)
C CD CORE UNIT(S11.1 STD-DOUT)
CN101 RF AMP, CD DECODER, MP3&WMA DECODER USB5V REGULATOR
DIGITAL SERVO/DATA • PROCESSOR IC502
VCC 12 12 V+3A VDD BD9008F
CPU, USB HOST CONTROLLER
LD LD- GND 1
15 15 1
LD IC501 B.UP PVIN
Q101
BD2226G 8 EN/ 5 19
VIN SYNC
SYNC
Q102 1 2
MD MD 5 PD 2
5 PD VIN SW
V+3A VDD
REFO 3
VREF REFO 93 18
8 8 REFOUT 54 EN USBCTL
PUEN 5 VOUT 20
USB5V 4
OC USBFLG
AC,BD,E,F
HOLOGRAM
UNIT IC201
PE5756A 54
VBUS
FOM FOM CN701 CN701
3 3
ACTUATOR/
FOP FOP MOTOR DRIVER
FOCUS ACT. 2 2 VDD VDD
VDD 9 8 VDD3.3V
TOP 1 1 TOP
IC301
TRACKING ACT.
BA5839FP
E TOM 4 4 TOM TD,FD
67
VDSENS
LD+
14 14 LD+ SD,MD
MECHA VD
Q751
12 VD VD
VO1+ VD 2 15 B.UP
11 Q752
VO1- 1 16
14
VO2+
13
VO2- 14
VDCONT
SOM 15
SPINDLE VO3+
MOTOR M SOP 16 LDIN
22 41
LOEJ
VO3-
21 40
CNT CLCONT
LCOM 17
LOADING/CARRIAGE VO4+ MUTE 9 39
CONT RESET 29 RESET
8
RESET 120
MOTOR M LCOP 18 9 CDRST
VO4-
S903 S901
DSCSNS HOME
F
DEH-5300UB/XNUC
16
1 2 3 4
5 6 7 8
RCAG 1 REAR
FL 6
RCAG 4 FRONT
Q251 Q252
ELECTRONIC VOLUME/
P251
SOURCE SELECTOR
IC201
PML022A
TUNL 2
IN2_L POUT_L 6
CD_Lch 1
IN1_L
JA901 B
FUSE 10 A
B.UP 18
AUX_Lch 4
IN4+_L
17
B.UP 15
9 FL+ 1
7 11 FL+
FRONT_L FLIn
FL- 7 FL-
3
26 15 12
VST STB 8 RLIn 5 RL+
REAR_L RL+ 5
VCK
30 14
CLK
AMP
31 13 IC301 RL-
3 RL-
7
VDT DATA PAL007E
MUTE
Q351 POWER
(1/2)
22 BREM CONNECTOR
MUTE B.REM 25 14
Q351
(2/2)
21
MUTE
ASENS
Q931 C
143 ACC
ASENS 13
SYSTEM MICRO
COMPUTER
D B
IC601
(2/2) PANEL UNIT KEYBOARD UNIT
R5S7266ZD144FP
JA1836
FRONT_AUX
AUXG 1
128 SWVDD CN802 CN2 CN1 CN1851
AUXR 3
141 AUXL AUXL AUXL AUXL 2
BSENS AUX L
19 4 11 11
7 SYSPW 142 SOURCE SOURCE SOURCE SOURCE SOURCE 4
SSENS 22 1 10 10
S1819
140 DSENS
DSENS
B.UP
SRC
S691
MULTI-CONTROL
S1846
D
131 ROT0 ROT0 ROT0 ROT0 2 5 KDT2
ROT0 6 17 8 8
130 ROT1 ROT1 ROT1 ROT1 1 4 KST1
ROT1 4 19 6 6
3
2
SW5V SWVDD SWVDD
8F SWVDD 3 20 9 9 SW5V
14
VDCONT
Q892
125
FLPILM ILLUMI ILLUMI ILLUMI
ILM+B ILM+B ILM+B
RED GREEN WHITE
ILM+B 5 18 7 7
120 D1862,D1863,D1864, D1877,D1878,D1879,
CDRST EJECT D1865,D1866,D1867, D1880,D1881,D1882,
S1
D1868,D1869,D1870, D1883,D1884,D1885, D1861
4 EJECT EJECT
EJECT 11 12 D1871,D1872,D1873, D1886,D1887,D1888,
D1874,D1875,D1876 D1889,D1890,D1891
Q1896
135 ILMCLR2 ILMCLR2 ILMCLR2 ILMCLR2 (2/2)
ILMCLR2 15 8 3 3
Q1896
(1/2)
ILMCLR1
133 ILMCLR1
13 10
ILMCLR1 ILMCLR1
5 5
ILMCLR1 CN1856 F
USB5V USB5V USB5V USB5V
USB5V 12 11 15 15 2
52 DM DM DM DM DM
DM 14 9 17 17 3 USB
53 DP DP DP DP DP
DP 16 7 19 19 4
DEH-5300UB/XNUC
5 6 7 8
17
1 2 3 4
5. DIAGNOSIS
5.1 OPERATIONAL FLOWCHART
A
Power ON
Vcc = 1.2 V
Pin 5
PVcc = 3.3 V
Pin 1
B BSENS
Pin 141
BSENS = L
ASENS
Pin 143
ASENS = L
C
DSENS
Pin 140
DSENS = L
Starts
communication
with Grille
D microcomputer.
300 ms
SWVDD <- H
Pin 128
300 ms
Source ON
SYSPW <- H
Pin 7
F
Completes power-on operation.
(After that, proceed to each source operation)
DEH-5300UB/XNUC
18
1 2 3 4
5 6 7 8
ERROR CODES A
If a CD memory device is inoperable, or operation of such media is stopped by an error, the error mode is established and a
cause of the error is displayed by an error code. Indication of error codes is intended to reduce the number of calls from
customers and facilitate failure analysis and repair work in servicing.
NOTES
• Indications of error codes are available only during disc operations, because CD operations are
unavailable if a mechanical error is generated.
• If the TOC cannot be read, this is not processed as an error, and operation continues accordingly.
• If you design a new head unit, be sure to use one of the display formats indicated in “Display example of
the main unit.”
• The 2 high-order digits of an error code denote the main • How to restore from each error is shown below.
classification, shown below. 0x, 1x and 3x: ACC-OFF then ON, CD-OFF then ON,
0x: Servo-related errors Disc ejection
1x: Servo-related errors 5X: ACC-OFF then ON, Disc ejection, Disc reloading
3x: Servo-related errors
5x: Mechanism-related errors F
DEH-5300UB/XNUC
5 6 7 8
19
1 2 3 4
DEH-5300UB/XNUC
20
1 2 3 4
5 6 7 8
DEH-5300UB/XNUC
5 6 7 8
21
1 2 3 4
6. SERVICE MODE
6.1 DISPLAY TEST MODE
A The information such as the system microcomputer version is checked.
[Operation key]
Operation key Processing Remarks
Enter display test mode (2)
1+3 Switch to next test mode
[Test items]
Start display test mode (2). Key Illumination Icon
(Press “ 1 ” + “ 3 ” keys simultaneously to start resetting.) * Initial
Off All off condition
S $ $ $ $ # # #
$ PD number For PEA010A, "010A" is displayed
# System For Ver.7.01, "701" is displayed
microcomputer
version On (an initial value or
All off
setting value of default
menu)
DEH-5300UB/XNUC
22
1 2 3 4
5 6 7 8
- Flow Chart
[4] + [6] -> BUP + ACC ON [CD] or [SOURCE] [Key]
Test Mode IN Source ON
Contents
TRK MIN
Display
[BAND] [2]
Power On RF AMP *1
(T.Offset is adjusted) Gain switching
TRK MIN SEC TRK MIN SEC
00 00 00 GG GG GG
[BAND] [2]
Power Off Tracking Open
Operation
*1) TYP t + 6 dB t + 12 dB [Key] Test Mode
TRK MIN SEC TRK
06MIN06SEC06 TRK
12MIN12SEC12 [BAND] Power On/Off
[<] CRG + / TR Jump +
(Direction of the external surface)
*2) Focus Close t S. Curve t F EQ measurement setting [>] CRG - / TR Jump - D
TRK
00MIN00SEC00 TRK
01MIN01SEC01 TRK
02MIN02SEC02 (Direction of the internal surface)
(TRK99MIN99SEC99) [1] T. CLS & AGC & Applicable servomechanism /
AGC,AGC display setting
[2] RF Gain switching / Offset adjustment display /
*3) F.Offset Display t T.Offset Display t Switch to the T.Balance adjustment / T. Open
order of the original display
[3] F. Close,S. Curve / Rough Servo and RF AGC /
F,T,RF AGC
*4) 100TR Jump [6] F. Mode switching / Tracking Close
After the [EJECT] key is pressed keys other than the [EJECT] key should not be pressed, until disc ejection is complete.
When the key [2] or [3] is pressed during the Focus Search, the power supply should be immediately turned off (otherwise the lens sticks
to Wall, causing the actuator to be damaged).
100TR Jump, the mechanism shall be set to the Tracking Close mode when the key is released.
F
When the power is turned on/off the gain of the RFAMP is reset to 0 dB. At the same time all the self-adjusting values shall return to the
default setting.
Do not do Tracking Servo Close before doing Focus Servo Close. (Because the overcurrent flows)
DEH-5300UB/XNUC
5 6 7 8
23
1 2 3 4
7. DISASSEMBLY
While the photograph shown is slightly different from this model in shape, the disassembly procedure is the same.
A
- Removing the Panel Assy (Fig.1)
2 2
3
D
Fig.3
E Lift off the Tuner Amp Assy from the Heat sink side.
5
Disconnect the FFC
6
and then remove the CD Mechanism Module.
6
5
F
DEH-5300UB/XNUC
24
1 2 3 4
5 6 7 8
3
1 Remove the two screws. 1 1
Fig.5
Fig.6
DEH-5300UB/XNUC
5 6 7 8
25
1 2 3 4
DEH-5300UB/XNUC
26
1 2 3 4
5 6 7 8
C
The spring is below a resin
flange and is built inside the
B A sheet metal bending.
Fig 3 Fig 4
DEH-5300UB/XNUC
5 6 7 8
27
1 2 3 4
DEH-5300UB/XNUC
28
1 2 3 4
5 6 7 8
Note :
The grating angle of the PU unit cannot be adjusted after the PU unit is changed. The PU unit in the CD mechanism
module is adjusted on the production line to match the CD mechanism module and is thus the best adjusted PU
unit for the CD mechanism module. Changing the PU unit is thus best considered as a last resort. However, if the
PU unit must be changed, the grating should be checked using the procedure below.
Purpose :
To check that the grating is within an acceptable range when the PU unit is changed.
Symptoms of Mal-adjustment : B
If the grating is off by a large amount symptoms such as being unable to close tracking, being unable to perform
track search operations, or taking a long time for track searching.
Method :
Measuring Equipment Oscilloscope, Two L.P.F.
Measuring Points E, F, REFO1
Disc TCD-782
Mode TEST MODE
CD CORE UNIT
E
F C
REFO1
L.P.F.
Xch Ych
E 100 kohm
Oscilloscope
VREF 390 pF
F 100 kohm
VREF 390 pF
L.P.F. D
Checking Procedure
1. In test mode, load the disc and switch the 3 V regulator on.
2. Using the right and left buttons, move the PU unit to the innermost track.
3. Press key 3 to close focus, the display should read "91". Press key 2 to implement the tracking
balance adjustment the display should now read "81". Press key 3. The display will change,
returning to "81" on the fourth press.
4. As shown in the diagram above, monitor the LPF outputs using the oscilloscope and check that the phase E
difference is within 75 . Refer to the photographs supplied to determine the phase angle.
5. If the phase difference is determined to be greater than 75 try changing the PU unit to see if there is any
improvement. If, after trying this a number of times, the grating angle does not become less than 75 then the
mechanism should be judged to be at fault.
Note
Because of eccentricity in the disc and a slight misalignment of the clamping center the grating waveform may be
seen to "wobble" ( the phase difference changes as the disc rotates). The angle specified above indicates the
average angle.
Hint
Reloading the disc changes the clamp position and may decrease the "wobble".
DEH-5300UB/XNUC
5 6 7 8
29
1 2 3 4
0 degrees 30 degrees
45 degrees 60 degrees
75 degrees 90 degrees
DEH-5300UB/XNUC
30
1 2 3 4
5 6 7 8
- PCL output
With the TESTIN (22 pin) status of IC601 to be “H”, it is shifted to PCL Output Test mode after reset started.
Check that square wave of 600.0 kHz + 25 Hz is output from PCL (8 Pin) of IC601.
If clock signal is out of this range, this resonator (X602) must be changed for a new one.
DEH-5300UB/XNUC
5 6 7 8
31
1 2 3 4
9.1 PACKING
DEH-5300UB/XNUC
32
1 2 3 4
5 6 7 8
B
(2) CONTRAST TABLE
DEH-5300UB/XNUC, DEH-5350UB/XNES1 and DEH-5350UB/XNES are constructed the same except for the fol-
lowing:
Mark No. Description DEH-5300UB/XNUC DEH-5350UB/XNES1 DEH-5350UB/XNES
1 Polyethylene Bag CEG1173 QEG3001 QEG3001
* 4 Accessory Assy QEA3012 QEA3009 QEA3009
5 Screw BPZ20P060FTC Not used Not used
7 Holder CND1249 Not used Not used
8 Holder CND1250 Not used Not used
C
10 Screw Assy YEA5072 YEA5082 YEA5082
12 Screw CRZ50P090FTC Not used Not used
14 Unit Box QHG3084 QHG3086 QHG3085
15 Contain Box QHL3084 QHL3086 QHL3085
17 Case Assy Not used QXA3129 QXA3129
DEH-5300UB/XNUC
5 6 7 8
33
1 2 3 4
9.2 EXTERIOR
D
B
A
B
:GEM1013
DEH-5300UB/XNUC
34
1 2 3 4
5 6 7 8
DEH-5300UB/XNUC
5 6 7 8
35
1 2 3 4
A
B
(C) (C)
(A)
C (C)
(A)
D B C (A)
(D) (A)
D
C
(D)
(C)
D
(B)
(D)
(A)
(A) (A)
(C)
(C)
C
(A) : GEM1045
(B) : GEM1038
(C) : GEM1024
F (C)
(D) : GEM1043
DEH-5300UB/XNUC
36
1 2 3 4
5 6 7 8
21 Bracket CND4553
22 Arm CND4555
23 Bracket CND5709
24 Bracket CND5710
25 Lever CND5398
26 Sheet CNN2280
27 Rack CNV8342
28 Guide CNW1171
29 Roller CNW1172
D
30 Arm CNW2157
31 Arm CNW1174
32 Roller CNW1175
33 Lever CNW1176
34 Arm CNW1177
35 Arm CNW1178
36 Gear CNW1180
37 Gear CNW1181
38 ..... E
39 Gear CNW1183
40 Rack CNW1184
41 Gear CNW1185
42 Gear CNW1186
43 Gear CNW1187
44 Gear CNW1188
45 Clamper CNW1190
46 Arm CNW1192
F
47 Holder CNW1193
48 Holder CNW1194
49 Damper CNW1197
DEH-5300UB/XNUC
5 6 7 8
37
1 2 3 4
13 /CDSTBY
14 /CDSRQ
RESET
PGND
1000p/50
DATA
LRCK
BCLK
WAIT
GND
11 SKIP
GND
VDD
C708
SDA
CN701
12 SCL
VD
VD
VKN1192-A 1u/10
C709
16
15
10
9
8
7
6
5
4
3
2
1
NM C234
C710 CCG1192-A
MECHA VD 7.4V (DCH1201-A)
CDSRQ
DGND1
PGND
NM
DAC
RESET
DATA
LRCK
VDD4
CDSTBY
BCLK
SDA
SCL
WAIT
SKIP
R716
VD2 VD1 PGND C235
220
Q751 DGND
2SD2396(K)
A-a A-b Guide page R717
NM
R701
CCG1192-A 10U/10
47k GND 100k
NM
NM
R751
Q752 R753 R754 R702
47k
0.1u/10
150
150
150
*2 C2 3 4 E2
16
SCK 15
ML 14
13
12
11
10
820 NM 100k
9
RKZ8.2KG(B2)
(DCH1201-A)
C751
7 ZEROR/ZEROA
B1 2 5 B2
VCOM
MC
MD
ZEROL/NA
AGND
5 4
C752
C753
A B,C
R752
C704
10k
E1 1 6 C1 6 3
R713
R714
R715
C754
D751
IC231
C443 NM 0.01u RN4983 NM
VOUTR
VOUTL
DGND
7 2 C705
DATA
LRCK
C451 3p NM VDCONT
BCK
VCC
Detailed page
NC
A-a A-b 8 1 NM
220
220
100
220
100
C452 1000p NM R704 C706
1k
4.7k
1
2
3
4
5
6
8
C455 10p NM GND
FM(30%) -15dB±2.5: -15.0 dBs NM
NM
L420 NM VDSENS
NM
NM
68n
R712
AM(30%) -15dB±2.5: -15.0 dBs
R707
R708
R709
R710
R711
R718
B
R719
R703
R720
TUNR D GND
C425 4700p/25 100k C702
TUNL
TUNER C424
4700p/25
C701
NM
NM
L701
0.01u/16
AGND
JA401
1000p/50
0.01u/16
C239
C232
CTF1786-A
CTF1786-A
C233
C703
9p/50
C428
C429
CKX1098-A
L407
L408
9p/50
AGND NM
TUNGND 36.48MHz
CDDATAIN
CDLRCKIN
X401 GND
CDSCKIN
2 1
VDCONT
CDSTBY
CD_SDA
CD_SCL
CDWAIT
4 X2 3
NM
DATA
LRCK
CDSKIP
GND
0.1u/10
CDSRQ
CDRST
NM
SCK
BCK
GND2
C431 0.1u/10
MD
MC
3 DGND
ML
C437
IMSA-6802-01Y900
0.1u/10
R429 NM
P401
C417
C432
KN401
C435
1 2
1u/10
C419
MD
MC
BCK
SCK
CSS1806-A
LRCK
DATA
NM
CDSCKIN
CDSKIP
CDLRCKIN
CDDATAIN
(CSS1805-A-T)
L413 NM
62 0.22u/16
R409
C448 L414
NM
NM
0.1u/10
RFGND
63 C416
55 C426
NM
R421 0 L419 SW5V
NM
64
61
60
59
58
57
56
GND-REF 54
OSCOUT 53
VCC-REF 52
VDDPLL1V2 51
50
49
L416
VDD3.3V
TVDAC
TCFM
GND-PLL
VCC-ADC_DAC
R401
R402
DACOUTR
NM
VCC-PLL
PLLTEST
GND-ADC_DAC
DACOUTL
VREFDEC
VDDIO1V2
1 48
220
750
OSCIN
TEST C441
2 47 CCG1205-A B.UP
3 VDD_CORE (CCG1218-A)
KP2311E
46
KP2311E
D401
D402
C442
FMPINDRV RFGND C446 GND1V2 L671
4 FMPINDDEC
L404
FMMIXDEC GPIO0
45 NM FLASH ROM SI IC671
CTF1786-A
C401 0.27u
5 C413 NM 44
FMMIXIN2 GPIO1 SCK SI VSS
C409 0.01u/16
C403
C449
C406
C414
NM
L401
6 3
6p/50
7 42
0.15u
CE
9 40 8 1 1 3
CK_SEL TDA7706 GPIO5
NM 10 39 A : PEA012A8 1 3
NM
NM
NM
RFGND GND
R672
GNDVCO GPIO6 B,C : PEA011A8
47k
L402 LFREF
10p/50
C617
11 GPIO7 38 2 2
LFREF R671 47k
GPIO8
C611
C613
CTF1786-A
C615
C407 C410 LF1 12 GND3V3 37
8
C404
0.1u/10
R619
R419 10k
R420 10k
0.1u/10 0.01u/16 13 I2CSCL 36 GND
AGND VCCVCO I2CSDA
C411 0.01u/16 C440
VREG3V3
14 35
VCCREG1V2
NM
1
RDSINT
TCAM2
GNDSLINK
0.1u/10
AMMIXIN1
AMMIXIN2
RFGND
LNAOUT2
LNADEC2
L403 15 34 0.1u/10
RSTN
GNDLNA
C412
NM
LNADEC
LNAOUT
100
100
100
REG1V2
NM
220
LNAIN2
0.1u/10
0.1u/10
C609
PINDDEC DGND
LNAIN
CCG1192-A
R416
C605
C607
R634
C619
0.1u/10
0.1u/10
CTF1786-A
NM
NM
C620
R618
33
VDIG
16
0.1u/10
(DCH1201-A)
C405
0.1u/10
C456
PINDIN
NM
RFGND
CTF1786-A
R609
R611
R613
R614
R617
C612
R616
L415
C445
TMS
TCK
C453
TDI
NM
R427 R417
17
18
19
20
21
22
23
24
25
26
27
28
29
30
31
32
R418
NM NM
0.1u/10
GND
R415
C422
R414
C420
97 NC
C443 L405 L406 C415
NM
NM
AGND
(DCH1201-A)
108
107
106
105
104
103
102
101
100
CCG1192-A
C454
99
98
96
95
94
93
92
91
90
89
88
87
86
85
84
83
82
81
80
79
78
77
76
CTF1389 22uH 0.01u/16
C418
R430
NM
NM
C439 NM
C438 NM
1M
L420
1000p/50
L418 NM GND
C436
C447
TMS
RSPCK
TUNPCE1
TCK
VCC6
VCC5
VCC4
TUNPDO
DACSCK
PVCC8
PVCC7
PVCC6
TUNPCE2
VSS9
VSS8
VSS7
DACBSCK
NM
47uH
109
MOSI
MISO
DACLRCK
CD_SDA
TUNPDI
DACBDATA
DACDATA
CD_SDA
AUDIO_X1
AUDIO_X2
/SSL
RF
AUDIO_XOUT
CDLRCKIN
RDS_INT
NM
CDSCKIN
CDSKIP
C444
680
CADATAIN
NM
GND
33
R413
C433
R405
1M
82p
0.01u/16 R408
*2
C423 L409
R406 470
DGND 111
NM
L417
L411 NM 114
C430
C455
RF CP_SCL
C452
C434
NM
CP_SCL
RFGND GND
R428 0 *2 115
NC
CPRST 116
GND CPRST
Q551 *2 C601 117
L551 LSA1576UB(QRS) DGND VDD3.3V PVCC9
LCTC4R7K1608-T CPPW 0.1u/10 118
CPPWR
NM R558 4.7k CPPW 119
VSS10
SYSTEM MICRO
C551
R551
0.1u/10
R562
47k
CDRST 120
R552 10k R559 100 NM CP_SCL CDRST
CDSRQ 121
R553 10k R560 100 CP_SDA CDSRQ
CDSTBY 122
R561 CDSTBY
CDWAIT 123
CDWAIT
NM R605 124
11 12 13 14 15 ML DACCS
IC551 125 IC601
FLPILM NM
341S2162 FLPILM
VSS
NC8
R5S7266ZD144FP
I2C_SCL/SPI_SIMO
I2C_SDA/SPI_SOMI
VCC MODE0/SPI_CLK
RB551V-30
10 16 126
PVCC10
D601
R601
100k
R603
C602 0.1u/10
10k
9 17 127
MODE1/SPI_nSS
ROT0 131
ROT0
D ILMPW 132
4
3
1
5
ILMPW
ILMCLR1 133 ILMCLR1
C552 R556 2.7k CPRST C603 134
0.1u/10 R557 4.7k PVCC11
ILMCLR2 0.1u/10 135 ILMCLR2
ipod CP 136
GND D502 VSS12
USB&USB5V
R602
47k
137
CEJQ221M16-P25
RGBDT
NM
CRG03 RGBDT
C507
C505
138 NC
C509 IC502 RGBDT 139 NC
L501 1u/16 1 8 140 DSENS
USB5V CTH1475-A PVIN VIN
(CTH1420-A-TLB) GND 2 7 GND 141
BSENS BSENS
SW GND
DPDT/TESTDO
51k NM
KYDT/TESTDI
3 6
NC/TESTCLK
SSENS 142
RB160L-40
FB RT SYNC SSENS
D501
RAM_MON 12 RAM_MON
R503 R502
C503
4 5
220u/6.3
47k
USBCTL
18k
/RDSLK
INV EN/SYNC
ANTPW
PCL 7 SYSPW
PVCC2
PVCC3
PVCC4
PVCC1
EJECT
TESIN
TELIN
MUTE
VCC1
VCC2
VCC3
VSS1
VSS2
VSS3
SYNC
144
C502
NM
ROM
1
4
3
2
R501
VDT
NC
VCK
VST
8 PCL
470
10 NC
NC
R604
BD9008F GND
47k
6.8k
C508
22p/50
0.015u/16
GND
1
2
3
4
9
5
11
13
14
15
16
17
18
19
20
21
22
23
24
25
26
27
28
29
30
31
32
33
ROM
C506
5
6
7
8
TESTIN
GND
TELIN1
C614 R610
2.2k
R504
0.1u/10
10k
TESTCK
R615 100k
0.1u/10
0.1u/10
C604
C606
R607
R608
C608
C610
C621
0.1u/10
0.1u/10
0.1u/10
0.1u/10
NM
47k
R612
C616
47k
47k
R508
C618
10k
IC501
GND 1
VIN VOUT
5 VBUS DSENS
R606
47k
2 FLG DSENS1
GND
3 4 FLG
EN /OC
C501 1u/10
USBCTL
2.2k
R691
DSENS
BD2226G USBCTL
1u/10
C504
DSENS
2
E
CSN1039-A
S691
1
VDCONT
GND
USBCTL
GND
ANTPW
SYSPW
TELIN
MUTE
SYNC
DPDT
KYDT
VCK
VDT
FLG
VST
CN802
RGBDT
R817
R803
CKS3836-A
2.2k
CN801 SOURCE 22
SRC2 SRC 100k R811 S
NM R823 FLPILM 2.2k
DSENS FLAPILM 21
20 2.2k CSEN R816 2.2k
AUXL2 C
1000p/50
AUXL CSENS 20
C818
ILMC1
NM
NMKYDT2
UCOM 601 - 650 TELIN 941 - 950 KYDT
8 USBGND 9 KYDT2 KYDT R806 2.2k
RESET 651 - 670 A.ANT 951 - 960 RGBDT/USBGND KYDT 8
7
R808
ROT0_2 USBGND 7
8.2k
ROT0
FLASH ROM 671 - 690 W.REM 961 - 970 6 ROT0_2 ROT0 R812 2.2k
C801
ILMB
NM
D808
ILM+B ROT0 6
NM
5 ILMB ILM
DSENS 691 - 700 ROT1 ROT1_2 ILM+B 5
4 ROT1_2 ROT1
SWVD2 R813 2.2k
CD MECHA 701 - 750 SW5V
3
ROT1 4
SWVD2 SWVD
ILMGND
MECHA VD 751 - 800 2 SW5V 3
ILMG
D809 DZ2S068C
D806 DZ2S068C
C810 220p/50
D807 DZ2S068C
D810 DZ2S068C
220p/50
D804 DZ2S068C
D803 DZ2S068C
D805 DZ2S068C
D802 DZ2S068C
D801 DZ2S068C
DGND ILMGND 2
C811 220p/50
0.1u/16
0.1u/16
0.1u/16
1
NM
C805 0.1u/16
C812 1u/16
DGND C803
GND DGND 1
F C802 NM
R851
C851
NM
4.7k
C820
C809
NM
C807
C806
C808
GND
the importance of the safety factor of the part. GRILL DGND USBGND ILM GND
GND
Therefore, when replacing, be sure to use parts of
A identical designation.
DEH-5300UB/XNUC
38
1 2 3 4
5 6 7 8
A-b
C210 1u/10
C208
C206
1u/10
1u/10 A TUNER AMP UNIT
ROR
TUR
C234
CCG1192-A
(DCH1201-A)
3.2V
24
23
22
21
20
19
18
17
16
15
14
13
DAC
POUT_R
REAR_R
IN4-_R
IN4+_R
FRONT_R
IN1_R
IN2_R
IN3_R
C235
NC2
DATA
STB
CLK
PML022A
LPF
7 FRONT_L
NM
IC201
6 POUT_L
8 REAR_L
R232
E-VOL
4 IN4+_L
5 IN4-_L
11 VREF
1 IN1_L
2 IN2_L
3 IN3_L
12 GND
10 VCC
9 NC1
820 FM(30%) -15dB±2.5: -5.9 dBs
AM(30%) -15dB±2.5: -5.9 dBs A : DEH-5300UB/XNUC
16
SCK 15
ML 14
MC 13
12
11
10
1800p/50
C238
9
AUX:+10.3 dBs
B : DEH-5350UB/XNES1
7 ZEROR/ZEROA
VCOM
MD
ZEROL/NA
AGND
PCM1753DBQ
ROL
TUL
IC231
C209 1u/10
C : DEH-5350UB/XNES
VOUTR
VOUTL
DGND
DATA
LRCK
BCK
C207 1u/10
VCC
NC
AGND
1800p/50
C237
R207
8
7
6
5
NM
C204
R201
R231
1k
10p/50 CCG1192-A DCH1201-A 10u/10
B
CCG1192-A
0.22u/6.3
0.22u/6.3
C212
C211
(DCH1201-A)
820 R205
CCG1201-A
D GND
2
3
4
1
C213
C201
C202
C215
10p/50
10p/50
CCG1201-A 4.7u/10
NM
C203
L231 NM
R206
NM RN4983 RT3T22M
(DCH1201-A)
NM
CCG1192-A
1000p/50
0.01u/16
C239
C232
C231
C214
NM
RN1910 UMH3N,RT3N66M
C233
GND
NM GND
GND FM(30%) -15dB±2.5: -5.9 dBs
RCA AM(30%) -15dB±2.5: -5.9 dBs
DATA
LRCK
SCK
BCK
RL FL
AUXG
AUXR
TUNR
AUXL
TUNL
ML
AUX:+10.3 dBs
CD/USB:+10.2 dBs RR FR
VDT PLch C251 R251
MD
MC
SCK
DATA
100p/50
R255
C255
AUX:+2.2 dBs
22k
SYS+B
>
C2
E1
B1
CD/USB:+5.1 dBs
1
2
3
SW5V 3A
RN1910
RCAG
Q251
P251
1 2 PRE OUT
VDD3.3V CEK1286-A PL
C1
6
5
4
B2
E2
R259
100p/50
R256
C256
JA251
22k
B.UP NM
C252 PR
PRch CCG1201-A R252 GND CKB1099
3
820 REAR
FL 2
RR
C253 R253 1
FR
RL
FLch
FL
6
CCG1201-A 820
16.934MHz FR 5 FRONT
4
100p/50
R257
C257
X601
22k
C2
E1
B1
CSS1603-A
1
2
3
RN1910
1 3
Q252
1 3 L601
VDD3.3V
NM
NM
C1
6
5
4
B2
E2
10p/50
C617
100p/50
2 2
R258
C258
C261
NM
R639
22k
1000p/50
C260
C259
C615
C634
C636
NM
NM
NM
8
7
6
5
NM
R619
R621
47k
R630 R631
CCG1201-A 820
A NM 47K
NM
2
3
4
1
GND
DDCONGND
NM
100
47K 15K
NM
B,C
220
GND IC301
C
C619
0.1u/10
0.1u/10
C620
R618
KEYAD
ASEBRK
PAL007E
AMP
R613
R614
R617
R616
TRST
TAB
TMS
TDO
1
TCK
L602
TDI
R303
10k
VDD1.2V
2 P-GND2
NM
R640 3 RL-
Q301
RB751S-40
C635
C637
NM
R301
NM
NM STBY STBY
D602
R628
*1 4
10k
E2 4 3 C2
88
87
86
85
84
83
82
81
80
79
78
77
76
75
74
TRST 73
NM R302
5 RL+
B2 5 2 B1
TMS
TDO
C622
TCK
VCC4
PVCC6
72
VSS7
DACBSCK
NM
R331
R333
TDI
DACBDATA
NM
NM
DACDATA
AUDIO_X1
AUDIO_X2
AUDIO_XOUT
ASEBRKAK/ASEBRK
CDSKIP
R630
AVCC 6 VCC
47k
71 0.1u/10 C1 6 1 E1
NC NM
R304
7 FL-
47k
70 C630 GND
R332
R334
NM
NM
69
47k
C314
10p/50
KEYAD 10u/16 9 FL+
68 C316 GND
AVSS C301 C305 10 SVR
67 AGND VDSENS GND NM
0.47u/10 0.47u/10 11 FLIn
VDSENS 66
C303 C307 RLIn
NC 12
65 GND 0.47u/10 0.47u/10
C317
CSENS
1p/50
CSENS 13 AGND
MODEL C304 C308 GND
64
MODELAD RRIn
NM
0.47u/10 14
R638
0.47u/10 GND
63 C302 C306
USBUVSS 15 FRIn
ICRO 62 C623 0.47u/10 0.47u/10 C310 C311 AC-GND
NM
NM
NM
NM
USBUVCC 16 AC-GND
0.1u/10 GND
C331
C332
C333
C334
VDD1.2V
VDD3.3V
61 CCG1205-A CCG1205-A
FR+
SYS+B
SW5V
C315
B.UP
60 C624
10p/50
USBAVCC USBA GND C309 0.1u/16 18 P-GND3
59 0.1u/10
USBAPVCC 19 FR-
58 C625 0.1u/10 GND C901
USBAPVSS 20 VCC
57 R626 CCH1732-A
REFRIN MU1 21 RR+
56 R351 R353 GND
5.6k F%
R632
MUTE
C638
1u/10
USBDVSS 22
10k
C351
53 100 D302
10k
DP B.REM
DP C2 3 25
4 E2
C318
C319
52
C321
C320
DM MUTE
DM
CRG03
B1 2 5 B2 D301
C312
51
GND
0.1u/16
USBDPVSS
10p/50
10p/50
10p/50
10p/50
50 C627 E1 1 6 C1
ASEMD RN4983
USBDPVCC
ASEMD
49 R622 0.1u/10 C632
12p/50
D
USB_X2
48 47k
GND MUTE GND
47 R627
PW CONNECT
33
USB_X1 GND
2
(CSS1813-A-T)
46 NM
VSS6
YSS5005-A
12MHz
X602
45 C628 IC912
PVCC5
44 0.1u/10
IC REGULATOR BA49182-V12 JA901
VSS5 BSENS CKM1586-A
R623 BSENS BSENS L901
43
1
4
42 1.5k 18
EXTAL
41 12p/50
2
3
SW5VCNT
GND1
GND2
2 1
CTH1432-A
17
YEK5001 >
MD_BOOT0 +B D901 BUP1 (10A)
40 R624 47k +B 16 GND
MD_CLK0 4 1SR154-400
SYSB
VDD3.3V
DPDT/TESTDO
39 15 B.UP
NC/TESTCLK
PVCC4
47k ACC
PLLVCC 37
TESIN
VDD
MUTE
VCC3
13 ACC
VSS3
VSS4
7
VDT
VCK
VST
NMI
1k 1.2V
NC
AANT
NC
C631
VDD12
NM
8 12 A.ANT
SWVDD GND
C629 SWVDD 11 ILM
21
22
23
24
25
26
27
28
29
30
31
32
33
34
35
36
BUP2 9
0.1u/10 +BUP 10
TESTIN
VDDCNT 10
SWVDD5 TELIN
VDDCONT 9 TEL
11 RR2
GND 8 RR-
12 RL2
0.1u/10
RESET
R620
47k
1SR154-400 7 RL-
TESTCK
RST 6 RR+
1 5
0.1u/10
C621
0.1u/10
NM
RL1
C616
R911
OUT NC2
C920 R912
D912 5 RL+
1
1
R615
C618
2 FR2
VDD
CCG1201-A
1SR154-400 4 FR-
CCG1201-A
CCG1201-A
CCG1201-A
CCG1201-A
1000u/16
3 4 FL2
1000p/50
C922
1000p/50
C926
1000p/50
1000p/50
0.1u/16
C921
VSS NC1
C923
C913
C914
C915
C916
C912
C917
C911
C918
C924
C927
D651
NM
NM
NM
C919
3 FL-
NM
NM
C925
NM
FR1
NM S-80827CNMC-B8M 2 FR+
GND R651 FL1
1 FL+
100k
RFGND
1u/10
C651
C652
NM
CD/USB:+36.2 dBs E
LSC4081UB(QRS)
B.UP
22k HZU7L(A1) 1k
MUTE
DPDT
KYDT
4.7k
R932
R933
C931
0.1u/16
VCK
VDT
47k
VST
FLPILM
FLPILM
GND
R811 SSENS
2.2k
Q891
CSENS LSA1576UB(QRS) R893
3.3k Q873
00 AUXL LSA1576UB(QRS)
A.ANT
R892
47k
Q952
10k
11 2 2
R810 NM 2SB1731 LSA1576UB(QRS)
D941
DP C951
NM R943 L941
8.2 Q892 R871
L802 R809 NM D951 R952 2.2u
CTF1713-A DM R874 IC951 CRG03 1/16W R941 15k
44 3 3 LTC114EUB
CRG03
8.2 1SS301
D952
10 1
47k
10k 1k
1/10W
R951
R873
Q951
5.6k
Q953 4.7k
NM
GND
LTC114EUB
B2 5 GND5 GND2
Q872 2 B1 7 4
R807 2.2k IC801 ILMPW VDD3.3V 3.3 ±0.15 V
C1 6 GND4 GND3
DPDT2 LTC114EUB 1 E1 6 5
1 5 NM VDD1.2 1.25 ±0.05 V
INB Vcc IN VDD
R806 2.2k ANTPW SWVDD 5.0 ±0.25 V
C952
KYDT DPDT 2
NM
INA
ILMPW NM SYS+B 8.4 ±0.3 V
R808
3 4 ANTPW
8.2k
0.1u/10
ROT0
GND ILM+B 13.9 V
TC7SET08FUS1 NM
R813 2.2k ROT1
GND KEYD2
R961
KEYD JA961
KEYD CKS4124-A
1 NOTE :
KEYAD2 1k 3
C811 220p/50
KEYAD
KEYAD R962 2 Symbol indicates a resistor.
NM 1k
No differentiation is made between chip resistors and F
C962
C961
L851
R851
C851
C852
NM
NM
0.1u/16
4.7k
0.1u/16
discrete resistors.
Symbol indicates a capacitor.
GND
GND
SWVDD W.REM GND No differentiation is made between chip capacitors and
discrete capacitors.
NM : No Mount
A
DEH-5300UB/XNUC
5 6 7 8
39
F
E
B
A
D
C
40
A-a A-b
A-b
C210 1u/10
C208 1u/10
C206 1u/10 A TUNER AMP UNIT
1
1
TUR
ROR
C234
CG1192-A
CH1201-A)
24
23
22
21
20
19
18
17
16
15
14
13
3.2V
C235
NC2
STB
CLK
IN1_R
IN2_R
IN3_R
DATA
IN4-_R
NM
IN4+_R
R232 LPF
POUT_R
REAR_R
FRONT_R
IC201
E-VOL
PML022A
820 FM(30%) -15dB±2.5: -5.9 dBs
AM(30%) -15dB±2.5: -5.9 dBs A : DEH-5300UB/XNUC
1 IN1_L
2 IN2_L
3 IN3_L
4 IN4+_L
5 IN4-_L
6 POUT_L
7 FRONT_L
8 REAR_L
9 NC1
10 VCC
11 VREF
12 GND
AUX:+10.3 dBs
C238
C205 1u/10 CD/USB:+10.2 dBs B : DEH-5350UB/XNES1
1800p/50
ROL
VCOM 9
AGND
TUL
C209 1u/10
C207 1u/10
C : DEH-5350UB/XNES
OU
VOUTR
PCM1753DBQ
AGND
L201
8
main sub
C237
8
7
6
5
NM CCG1205-A CCG1218-A 2.2u/10
NM
C204
R207
1800p/50
R231
1k
10p/50 CCG1192-A DCH1201-A 10u/10
R201
820 R205
2
3
4
C212
C211
L231 CCG1201-A 4.7u/10
NM
NM
C213
C201
C202
C215
R206
C203
10p/50
0.22u/6.3
0.22u/6.3
10p/50
NM RN4983 RT3T22M
CCG1192-A
NM
CCG1201-A
(DCH1201-A)
C214 RN1910 UMH3N,RT3N66M
NM
GND
C232
C231
C233
NM GND
2
2
0.01u/16
GND FM(30%) -15dB±2.5: -5.9 dBs
CCG1192-A
(DCH1201-A)
RCA AM(30%) -15dB±2.5: -5.9 dBs RL FL
AUX:+10.3 dBs
AUXG
AUXR
AUXL
TUNR
TUNL
CD/USB:+10.2 dBs RR FR
VDT PLch C251 R251
R255
C255
1
E1
2
B1
3
C2
SW5V 3A RCAG
P251
1 2 PRE OUT
Q251
RN1910
VDD3.3V CEK1286-A
6
5
4
PL
C1
B2
E2
R259
B.UP NM
22k
JA251
R256
C256
C252 PR
100p/50
FL
FR
RL
RR
DEH-5300UB/XNUC
6
CCG1201-A 820
FR 5 FRONT
4
1
E1
2
B1
3
C2
22k
R257
C257
100p/50
L601
VDD3.3V
Q252
RN1910
6
5
4
3
3
NM
C1
B2
E2
R639
NM
8
7
6
5
22k
R258
C258
C261
NM
NM
NM
NM
C260
C259
C634
C636
100p/50
47k
47k
R619
R621
CCG1201-A 820
2
3
4
1
A NM 47K DDCONGND
GND
B,C 47K 15K GND IC301
KEYAD
PAL007E
L602
AMP 1 TAB
TRST
ASEBRK
TCK
TMS
TDI
TDO
VDD1.2V
10k
2 P-GND2
R303
NM
R640 3 RL-
Q301
NM R301 STBY STBY
NM
NM
4
C635
C637
NM E2 4 3 C2 R302
78
77
76
75
74
73
*1
10k
D602
R628
5 RL+
72 C622 B2 5 2 B1 NM
RB751S-40
AVCC 6 VCC
TCK
TMS
TDI
TDO
NM
NM
C1 6 1 E1
TRST
R331
R333
47k
71 0.1u/10
R630
NC NM 7 FL-
C630 GND
47k
70
U O_
R304
0.1u/10
R332
R334
69
10u/16 FL+
47k
KEYAD 9
R631
C316 GND
C314
68
10p/50
ASEBRKAK/ASEBRK
0.47u/10 0.47u/10 11 FLIn
VDSENS 66
C303 C307 RLIn
NC 12
65 GND 0.47u/10 0.47u/10
CSENS AGND
CSENS C304 13
MODEL C308 GND
C317
64
4
1p/50
4
NM
63 C302 C306 GND
R638
USBUVSS 15 FRIn
62 C623 0.47u/10 0.47u/10 C310 C311 AC-GND
USBUVCC 16 AC-GND
NM
NM
NM
NM
60 C624 GND
USBAVCC USBA GND
SW5V
C309 0.1u/16 18 P-GND3
VDD1.2V
B.UP
VDD3.3V
SYS+B
C315
59 0.1u/10
10p/50
USBAPVCC 19 FR-
58 C625 0.1u/10 GND C901
USBAPVSS 20 VCC
57 R626 CCH1732-A
REFRIN MU1 21 RR+
56 R351 R353 GND
5.6k F% MUTE
USBDVSS 22
C626
10k
55 10k 220
R632
C638
1u/10
USBDVCC 23 RR-
54 0.1u/10 R633 VBUS
VBUS CRG03 24 P-GND4
53 100 Q351 D302
DP B.REM
10k
DP 25
R352
C351
52 C2 3 4 E2
DM MUTE
CCG1192-A
DM
C318
C319
C321
C320
B1 2 5 B2
01
12
51
(DCH1201-A)
G03
GND
USBAVSS (CCG1218-A) (CCG1218-A) 17 FR+
C3
C3
C3
C3
60 C624 GND
USBAVCC C309 0.1u/16 18 P-GND3
SW5V
USBA GND
VDD1.
B.UP
VDD3.
SYS+B
C315
59 0.1u/10
10p/50
USBAPVCC 19 FR-
58 C625 0.1u/10 GND C901
USBAPVSS 20 VCC
57 R626 CCH1732-A
REFRIN MU1 21 RR+
56 R351 R353 GND
5.6k F% MUTE
USBDVSS 22
C626
10k
55 10k 220
R632
C638
1u/10
USBDVCC 23 RR-
54 0.1u/10 R633 VBUS
VBUS CRG03 24 P-GND4
53 100 Q351 D302
DP B.REM
10k
DP 25
R352
C351
52 C2 3 4 E2
DM MUTE
CCG1192-A
DM
C318
C319
C321
C320
51 B1 2 5 B2
(DCH1201-A)
USBDPVSS GND
D301
C312
E1 1 6 C1
CRG03
50 C627
USBDPVCC ASEMD RN4983
0.1u/16
10p/50
10p/50
10p/50
10p/50
49 R622 0.1u/10 C632
ASEMD
48 47k 12p/50
USB_X2 GND MUTE GND
47
2
R627
5
5
USB_X1 GND
33
2
PW CONNECT
46 NM
VSS6
45 C628 IC912
PVCC5
X602
44 0.1u/10
IC REGULATOR BA49182-V12 JA901
VSS5 BSENS CKM1586-A
12MHz
BSENS L901
YSS5005-A
43 R623 BSENS
4
1
(CSS1813-A-T)
XTAL SYSPW 1 600uH FUSE
R637 NM SYSPW 14.4V
4
1
42 1.5k C633 SYSPW 18
EXTAL 2 GND1 2 1
GND2 CTH1432-A YEK5001
41 12p/50 SW5VCNT 17 >
MD_BOOT0 +B 3 D901 (10A)
BUP1
40 R624 47k +B 16 GND
MD_CLK0 4 1SR154-400
NM USB GND SYSB
39 R625 SYS+B 15 B.UP
PLLVSS SW5V 5 D902 BREM
38 R636 SW5V 14 BREM
RES 6
VDD3.3V
47k R629 VDD1 1SR154-400 ACC
PLLVCC 37 VDD 13 ACC
1k 1.2V 7
AANT
NC
VDD12
PVCC4
VSS4
NMI
VDT
NC
12 A.ANT
NM
8 GND
SWVDD
C631
C629 SWVDD 11 ILM
31
32
33
34
35
36
BUP2 9
0.1u/10 +BUP 10
VDDCNT 10
SWVDD5 TELIN
VDDCONT 9 TEL
11 RR2
GND 8 RR-
12 RL2
RESET 1SR154-400 7 RL-
IC651
47k
D911 RR1
R620
RST 6 RR+
1 5 RL1
OUT NC2
1
1
D912 5 RL+
C621
2
R911
FR2
0.1u/10
VDD 1SR154-400 4 FR-
3 4 FL2
6
6
NM
NM
NM
C922
NM
NM
C926
FR1
NM
C921
C923
C913
C914
C915
C916
C912
C917
C911
C918
C924
C920 R912
C927
C919
C925
NM FR+
0.1u/16
S-80827CNMC-B8M 2
1000u/16
1000p/50
GND
1000p/50
CCG1201-A
FL1
1000p/50
1000p/50
R651
CCG1201-A
CCG1201-A
CCG1201-A
CCG1201-A
1 FL+
100k
RFGND
GND
NM
FM(30%) -15dB±2.5:+20.1 dBs
C651
1u/10
C652
AM(30%) -15dB±2.5:+20.1 dBs
ASENS
AUX:+36.3 dBs
ASENS CD/USB:+36.2 dBs
GND ASEN2 ASEN1
R931 D931 R934
SWVDD
B.UP
Q931
22k HZU7L(A1) 1k
4.7k
47k
VDT
R932
R933
C931
FLPILM
0.1u/16
LSC4081UB(QRS)
GND
R811 SSENS
FLPILM
2.2k
Q891
CSENS LSA1576UB(QRS) R893
DEH-5300UB/XNUC
3.3k Q873
AUXL LSA1576UB(QRS)
A.ANT
47k
AUXR R942
R892
TELIN
AUXG TELIN 22k
Q871 Q952 Q941
7
7
NM 2SB1731 LSA1576UB(QRS)
10k
R810 DP C951 D941
R891
NM R943 L941
8.2 Q892 R871
R809 NM D951 R952 2.2u
DM R874 IC951 CRG03 1/16W R941 15k
8.2 LTC114EUB 1SS301
10 1 10k 1k
10k
47k
DIAG OUT
D952
CRG03
Q951 9 2
R951
NM
1/10W
GND
C871
R873
5.6k
E2 4 GND6 GND1
3 C2
0.1u/16
ILMCLR1 8 3 NM
GND5 GND2 GND SW5V 5.0 ±0.20 V
R872
Q872 B2 5 2 B1 7 4
ILMPW
C872
IC801 GND4 GND3 VDD3.3V 3.3 ±0.15 V
Q953 4.7k
LTC114EUB C1 6 1 E1
DPDT2 1 5 NM 6 5 VDD1.2 1.25 ±0.05 V
INB Vcc IN VDD
ANTPW
LTC114EUB
3 4 ILMPW ANTPW
GND OUTY ILM GND MECHA VD 7.4V 7.4 V
ROT0
0.1u/10
C817
TC7SET08FUS1 GND ILM+B 13.9 V
NM
ROT1
GND KEYD2 KEYD
KEYD
R961 JA961
CKS4124-A
1 NOTE :
KEYAD2 1k KEYAD 3
KEYAD R962 2 Symbol indicates a resistor.
NM 1k
L851 No differentiation is made between chip resistors and
NM
NM
C962
C961
C851
C852
discrete resistors.
0.1u/16
0.1u/16
8
8
SWVDD W.REM GND No differentiation is made between chip capacitors and
GND
discrete capacitors.
NM : No Mount
A-a A-b
A-b
41
E
A
D
C
F
B
F
E
B
A
D
C
42
A-a A-b
CD/USB:+5.1 dBs A-b
C CN701
A-a
CD C707
1000p/50
C708
VD
VD
GND
SDA
VDD
GND
DATA
BCLK
LRCK
PGND
WAIT
RESET
CN701 1u/10
VKN1192-A
1
1
C709
9
8
7
6
5
4
3
2
1
16
15
14 /CDSRQ
13 /CDSTBY
12 SCL
11 SKIP
10
NM C234
C710 CCG1192-A
MECHA VD 7.4V (DCH1201-A)
NM
DAC
VD2 PGND
SCL
SDA
C235
DATA
LRCK
PGND
VD1
VDD4
BCLK
Q751
WAIT
CDSRQ
RESET
DGND1
SKIP
DGND
220
R716
2SD2396(K)
CDSTBY
NM LPF
R701 R717 R232
47k GND 100k 820
Q752 R753 R754 R702
NM
NM
47k
R751
150
150
150
C2 3 4 E2
16
15
14
13
12
11
10
9
*2 820 NM 100k
0.1u/10
B1 2 5 B2 5 4
C238
ML
MC
MD
C751
C704
SCK
B,C
1800p/50
A E1 1 6 C1 6 3
C752
C753
VCOM
AGND
10k
R752
C443 NM 0.01u RN4983 NM
2
R713
R714
R715
CCG1192-A 10U/10
7 C705
C754
D751
(DCH1201-A)
ZEROL/NA
IC231
C451 3p NM VDCONT
RKZ8.2KG(B2)
8 1 NM
BCK
DATA
LRCK
DGND
NC
VOUTL
VOUTR
VCC
PCM1753DBQ
220
220
100
220
100
4.7k
1
2
3
4
5
6
7 ZEROR/ZEROA
8
1k
C455 10p NM GND
C237
NM
68n
NM
NM
1800p/50
R712
R707
R708
R709
R710
R711
TUNR R703 820
R718
D GND
R719
R720
C425 4700p/25
TUNL 100k C702 L231
TUNER C701
C424 NM NM
4700p/25
0.01u/16
NM
AGND
L701
JA401 C703
NM
C239
C232
C231
CKX1098-A
C233
AGND NM
2
2
TUNGND
9p/50
L407
L408
C428
C429
36.48MHz
1000p/50
0.01u/16
9p/50
GND
CCG1192-A
X401
(DCH1201-A)
2 1
4
CTF1786-A
GND
CTF1786-A
X2 3
NM
GND2
NM
3 DGND
MD
MC
ML
SCK
BCK
DATA
LRCK
R429 NM
0.1u/10
C437
VDCONT
CDSRQ
CDSTBY
CD_SCL
CDSKIP
CD_SDA
CDRST
CDDATAIN
CDSCKIN
CDLRCKIN
CDWAIT
1 2
P401
KN401
C417
GND1 L412
C432
0.1u/10
C435
M2R6TP_GND X1
1u/10
C419
CSS1806-A NM
MD
MC
(CSS1805-A-T)
C431 0.1u/10
BCK
SCK
L413 NM
LRCK
DATA
C448 L414 NM
CDSKIP
NM
RFGND
CDSCKIN
IMSA-6802-01Y900
R409
CDLRCKIN
CDDATAIN
NM
C426
R421 0 L419 SW5V SW5V
NM
64
63 C416
62 0.22u/16
61
60
59
58
57
56
55
54 0.1u/10
53
52
51
50
49
L416
VDD3.3V VDD3.3V
1 48 NM
220
750
TEST C441
R401
R402
TCFM
2 47 CCG1205-A
TVDAC
B.UP B.UP
OSCIN
OSCOUT
GND-PLL
VCC-PLL
VDD_CORE
PLLTEST
GND-REF
3 (CCG1218-A)
DACOUTR
DACOUTL
VREFDEC
VCC-REF
46
VDDIO1V2
C442
VDDPLL1V2
FMPINDRV RFGND C446 GND1V2 L671
IC671
D401
D402
4 FMPINDDEC 45 SI
VCC-ADC_DAC
NM FLASH ROM CTF1786-A
GND-ADC_DAC
L404
FMMIXDEC GPIO0
KP2311E
C401 0.27u
KP2311E
5 C413 NM 44 SCK
FMMIXIN2 GPIO1 SI VSS
33p/50
DEH-5300UB/XNUC
0.01u/16 6 FMMIXIN1 43 KN601 5 4
GNDRF GPIO2 SCK WP# SO
C414 7 42 M2R6TP_GND 6 3
NM
TCAM GPIO3 HOLD# SO 16.934MHz
L401
C402
C403
C449
C406
6p/50
1u/10 7 2
0.15u
8 41 X601
0.01u/16
0.01u/16
RF VCCRF IC401 GPIO4 VDD CE# CSS1603-A
C409 0.01u/16
GND C450 9 40 8 1 1 3
CE
3
3
L402 LFREF
47k
11 GPIO7 38
R672
CTF1786-A
8
7
6
5
VDD3V3
C615
C404
47k
VCCVCO
47k
AGND I2CSDA
R619
R621
0.1u/10
C411 0.01u/16 14 35 C440
2
3
4
TCAM2
NM
RFGND 0.1u/10
R419 10k
R420 10k
L403 C412 15 34
NM
100
100
100
NM
220
VREG3V3
RSTN
RDSINT
16 33
NM
NM
(DCH1201-A)
C609
R416
C605
C607
R634
C619
RFGND PINDIN
C620
R618
GNDLNA
LNAIN
LNADEC
LNAOUT
LNAIN2
LNAOUT2
LNADEC2
AMMIXIN1
AMMIXIN2
GNDSLINK
VDIG
VCCREG1V2
REG1V2
0.1u/10
0.1u/10
NM
C405
0.1u/10
0.1u/10
C445
C456
0.1u/10
R609
R611
0.1u/10
R613
R614
R617
R427 R417
L415
C612
R616
TRST
ASEBRK
TCK
TMS
TDI
TDO
17
18
19
20
21
22
23
24
25
26
27
28
29
30
31
32
NM
GND 0.022u/16 L410
C453
RFGND 1k NM
CTF1786-A
C408 NM
*2 R403 1.5k
NM GND
C443 L405 L406 C415 NM
R418
AGND
NM
NM
R415
C422
R414
C420
0.1u/10
CTF1389 22uH C454
0.1u/10
108
107
106
105
104
103
102
101
100
99
98
97 NC
96
95
94
93
92
91
90
89
88
86
85
84
83
82
81
80
79
78
77
76
75
74
0.01u/16
NM
NM
L420
1M
L418 NM GND
C418
R430
NM
AVCC
TCK
TMS
TDI
TDO
GND
C436
C447
33
680
NM
47uH
VCC6
VSS9
VCC5
VSS8
VCC4
VSS7
TRST 73
/SSL
71
MOSI
MISO
C438 NM
CD_SCL 110
C439 NM
CCG1192-A
CD_SCL
C444
(DCH1201-A)
1M
PVCC6
RSPCK
PVCC8
PVCC7
NC
1000p/50
R413
C433
R405
TUNPDI
DACSCK
TUNPDO
CDSKIP
82p
70
TUNPCE1
DGND
TUNPCE2
*2 111
C427
C451
RDS_INT
DACBSCK
DACLRCK
CDSCKIN
DACDATA
AUDIO_X1
AUDIO_X2
CADATAIN
NM
R410 R412 TUNSDA 69
112
L417
AUDIO_XOUT
TUNSCL KEYAD
8.2 8.2
R406 470
CP_SDA 113
C423 L409
CP_SDA AVSS
0.01u/16 R408
L411 NM 114 67
RF CP_SCL
ASEBRKAK/ASEBRK
GND CP_SCL
NM
RFGND R428 0
C430
C455
*2 VDSENS 66
C452
C434
115
0.47u/10
NC NC
CPRST 116 65
GND CPRST CSENS
Q551 *2 C601 117 64
4
4
47k
C551
R551
R552 10k R559 100 NM CP_SCL CDRST USBAVSS
60
0.1u/10
CDSRQ 121
R553 10k R560 100 CP_SDA CDSRQ USBAVCC
CDSTBY 122 59
R561 CDSTBY USBAPVCC
CDWAIT 123 58
CDWAIT USBAPVSS
NM R605 124 57
11 12 13 14 15 ML DACCS REFRIN
IC551 125 IC601 56
FLPILM NM
341S2162 FLPILM R5S7266ZD144FP USBDVSS
10 16 126 55
VSS
NC8
PVCC10 USBDVCC
C602 0.1u/10 127 54
9 17
10k
VSS11 VBUS
100k
NC7
D601
R601
R603
NC6 NC9 53
NC10 18 SWVDD5 128
RB551V-30
MODE0/SPI_CLK
51
2C_SCL/SPI_SIMO
SET
ROT1 130
2C_SDA/SPI_SOMI
6 20
DE1/SPI_nSS
ROT1
4
C
R
R552 10k R559 100 NM CP_SCL CDRST USBAVSS
60
0.1u
CDSRQ 121
R553 10k R560 100 CP_SDA CDSRQ USBAVCC
CDSTBY 122 59
R561 CDSTBY USBAPVCC
CDWAIT 123 58
CDWAIT USBAPVSS
NM R605 124 57
11 12 13 14 15 ML DACCS REFRIN
IC551 125 IC601 56
FLPILM NM
341S2162 FLPILM R5S7266ZD144FP USBDVSS
10 16 126 55
VSS
NC8
PVCC10 USBDVCC
C602 0.1u/10 127 54
9 17
10k
VSS11 VBUS
100k
NC7
D601
R601
R603
NC6 NC9 53
NC10 18 SWVDD5 128
RB551V-30
8 NC5 NC11 SWVDD DP
NC4 NC12
7 NC3 19 KEYD 129 52
NC13 KEYD DM
20 ROT1 130 51
I2C_SCL/SPI_SIMO
6
I2C_SDA/SPI_SOMI
ROT1 USBDPVSS
ROT0 131 50
VCC MODE0/SPI_CLK
nRESET
NC2
MODE1/SPI_nSS
NC1
ROT0 USBDPVCC AS
49
4
3
132
5
ILMPW
2
ILMPW ASEMD
ILMCLR1 133 48
C552 R556 2.7k ILMCLR1 USB_X2
CPRST C603 47
5
134
5
0.1u/10 R557 4.7k PVCC11 USB_X1
ILMCLR2 0.1u/10 135 46
ILMCLR2 VSS6
ipod CP 136 45
GND D502 VSS12 PVCC5
USB&USB5V 137 44
47k
CRG03 RGBDT RGBDT VSS5
R602
NM
138 43
NC XTAL
C507
C505
C509 IC502 RGBDT 139 42
NC EXTAL
L501 1u/16 1 8 140 41
USB5V CTH1475-A PVIN VIN DSENS MD_BOOT0
(CTH1420-A-TLB) GND 2 7 GND 141 40
BSENS
CEJQ221M16-P25
SW GND BSENS MD_CLK0
3 6 51k NM SSENS 142 39
FB RT SYNC SSENS PLLVSS
4 5 R506 R507 SYNC ASENS 143 ASENS 38
RES
D501
47k
INV EN/SYNC
C503
18k
R505
PLLVCC 37
4
3
2
144 NC
NM
RB160L-40
220u/6.3
GND
NC
C502
VSS1
VCC1
PVCC2
VSS2
VCC2
PVCC3
VSS3
VCC3
PVCC4
VSS4
NMI
TELIN
/RDSLK
/USBFLG
VST
NC/TESTCLK
VDT
NC
470
ANTPW
USBCTL
MUTE
TESIN
VCK
EJECT
BD9008F
ROM
PVCC1
VDCONT
SYNC
DPDT/TESTDO
KYDT/TESTDI
NC
R501
47k
R604
R503 R502
6.8k
1
2
3
4
6
8 PCL
9
5
GND
10 NC
11
13
14
15
16
17
18
19
20
21
22
23
24
25
26
27
28
29
30
31
32
33
34
35
36
C508
5
6
7
8
22p/50
PCL 7 SYSPW
ROM
C506
GND
0.015u/16
TESTIN
TELIN1
RAM_MON 12 RAM_MON
2.2k
R610
10k
47k
R504
R620
0.1u/10
100k
NM
47k
TESTCK
47k
47k
C604
C606
R607
R608
C608
C610
C614
C621
R612
C616
0.1u/10
0.1u/10
10k
0.1u/10
0.1u/10
0.1u/10
0.1u/10
R508
R615
C618
IC501
6
6
2.2k
BD2226G USBCTL
R691
DSENS
C501 1u/10
2
1u/10
C504
S691
1
DSENS
GND GND
CSN1039-A
ANTPW
SYSPW
TELIN
VDCONT
USBCTL
SYNC
FLG
MUTE
VST
DPDT
KYDT
VCK
VDT
CN802 R817
CKS3836-A
SRC2
R803
2.2k
RGBDT
SOURCE 22 SSENS
NM R823 FLPILM 2.2k
DSENS FLAPILM 21
20 2.2k CSEN R816 2.2k
AUXL AUXL2 CSENS 20 CSENS
DEH-5300UB/XNUC
19 AUXL2 AUXL
SRC2 R802 100 AUXL
SOURCE
C818
REFERENCE AREA MAP AUX L 19
18 AUXR2 AUXR R821 22k
1000p/50
AUXR2 R801 100 AUXR
EVOL 201 - 230 GRILL 801 - 850 AUXR AUX R 18 R822 22k
17 AUXG2 AUXG R820
AUXGND AUXG2 GND 100 AUXG
AUXGND 17
7
7
12 US5V
R818
FLASH ROM 671 - 690 W.REM 961 - 970 ILMB ROT0 R812 2.2k ROT0
ILM+B ROT0 6
NM
5 ILMB
NM
ILM
C801
ROT1_2
D808
GND DGND 1
220p/50
C802 NM NM
0.1u/16
0.1u/16
0.1u/16
L851
NM
NM
NM
4.7k
R851
C851
C852
C812 1u/16
C810 220p/50
C820
C811 220p/50
C809
C807
C806
C808
C805 0.1u/16
D809 DZ2S068C
D806 DZ2S068C
D807 DZ2S068C
D810 DZ2S068C
ILM GND
8
8
The > mark found on some component parts indicates
GND
the importance of the safety factor of the part. GRILL DGND USBGND ILM GND SWVDD
GND
Therefore, when replacing, be sure to use parts of
identical designation.
A-a A-b
A-a
A-b
43
E
A
D
C
F
B
F
E
B
A
D
C
44
B
SEG5
SEG6
SEG7
SEG8
SEG9
SEG10
SEG11
SEG12
SEG13
SEG14
SEG15
SEG16
SEG17
SEG18
SEG19
1
1
1 SEG0
2 SEG1
3 SEG2
4 SEG3 C1801
5 SEG4
6 SEG5
DGND
1u/10
7 SEG6
8 SEG7
64
63
62
61
60
59
58
57
56
55
54
53
52
51
50
49
9 SEG8
SEG9
RED
1846~1850
1836~1845
1811~1835
1806~1810
1801~1805
RED
10
11 SEG10 SEG4 1 48 SEG20
GREEN
SEG20
VDD
SEG11
COLOR
12
GREEN
SEG5
SEG6
SEG7
SEG8
COLOR2
SEG9
COLOR1
SEG12 2
SEG10
47
SEG11
SEG13
SEG14
SEG15
SEG16
SEG12
13 SEG3 SEG21 SEG21
14 SEG13
15 SEG14 SEG2 3 SEG4 46 SEG22
16 SEG15 SEG2 SEG22
SEG3
V1801
AUX
SEG19
SEG18
18
SEG17
SEG18 5 44
R1879
R1867
SWITCH
19 SEG0 SEG24
ROTARY
REMOTE
SEG20 6 43
LCD
21 COM3 SEG25
22 SEG21 COM3 SEG25
23 SEG22 COM2 7 42 SEG26
SEG26
R1861,R1880
SEG23 COM2
R1876-R1878
R1874-R1875
R1864-R1866
R1862-R1863
24
10.2 KEYBOARD UNIT
REFERENCE
25 SEG24 COM1 8 41 SEG27
26 SEG25 COM1 SEG27
IC1801
27 SEG26 9 40
PD6340A
COM0 SEG28
SML-D12P8W(KL)
SEG27 COM0 SEG28
SML-D12V8W(PQ)
28
29 SEG28 10 39 SEG29
VLCD SEG29
CAW1998
SEG29
PART NUMBER
30
SEG30 11 38
680
820
820
270
31 KST3 KST3 SEG30 SEG30
2.2K
2.7K
1.8K
32 SEG31
VALUE
33 SEG32 KST2 12 37 SEG31
SEG33 KST2 SEG31
34
2
2
36
37 SEG36 14 35
SEG36
KST0 SEG33
SEG37
SEG38
SEG37 KST0 SEG33
38
DPDT
REM
39 SEG38 KDT0 15 34 SEG34
1896~1905
1861~1895
1856~1860
1851~1855
KDT3
42 SEG39
KST4
KST2
KYDT
NC2
NC1
X0
X1
VSS
MODA
43 COM2
44 COM3
C1861
17
18
19
20
21
22
23
24
25
26
27
28
29
30
31
32
ILM
USB
NM
R1880 R1861
D1861
ILMCLR
ILMGND
SMLXA4WBETW1(Z1)-TRB 270 270
1/4W 1/4W
CONNECTOR
NM NM R1862
R1802
R1801
DEH-5300UB/XNUC
D1863 D1862 R1868
NM R1808
X1801
DOWN DISP/BACK
CSS1547
DGND
NM
2.2k
2.2k
NM
R1809
NM NM R1863
3
3
KST4
GND
KDT2
KDT3
DGND
NM VCC
LIST UP CCG1192 3
R1806
SOURCE
KST4
KST3
KST2
KST1
KST0
NM NM NM R1864 NM
IC1806
100
2.2k
R1807
C1868 C1867 C1866
REMOTE
GP1UXC14RK
0
NM NM
RIGTH LEFT REGION
R1812
1
NM NM NM R1865
1
1
1
1
S1819
2.2k
SRC
1
6
S1826
S1823
S1811
S1812
LEFT
NM
DGND
1 2 3 R1813
NM
R1814
KDT0
NM NM NM R1866
4
4
4 5 6
2
5
S1824
S1821
S1820
S1813
UP
S1827
S1814
LIST
2
2
2
2
2
2
NM NM R1867
KDT1
RED
C1876 C1875 2.7k
COLOR 1
SOURCE BAND
1
1
1
NM
S1829
*
S1816
S1815
R1896
2
2
2
RIGHT
CLOCK
KDT2
B,C DISP OF
10k 1k
5 6 7 8
B KEYBOARD UNIT
SOURCE
KDT1
KDT2
KDT3
S1815 S1817
NM
NM
NM
NM
NM
NM
NM
1 2 1 2
S1816 S1818
VA1838
VA1836
VA1837
VA1839
C1839
C1838
C1840
1 2 1 2 ILMGND
4700p/50
4700p/50
C1837
C1836
DGND 220p/50 DPDT
S1822 CKN1082 2
1 R1837
1 2 100 ILMCLR2 3
3
2 KYDT 4
BAND/ESC R1836
4 ILMCLR1 5
S1825 AUX:+2.2 dBs 100
ROT1 6
1 2 ILM+B ILM+B 7
4 FRONT_AUX ROT0 8
SW5V 9
S1828
1 2
MULTI-CONTROL
SOURCE
AUXL
10
11
D
3
CSD1168
AUXG
AUXR
12 CN1
S1829 S1830 2 13
5
1 2 1 2 USBGND 14
3
S1831 USB5V 15
4 1
1 2 USBGND 16 C
R1847
R1846
DM
NM
27k
17
* DISP/BACK S1846
DGND
ILMGND
DP
18
19
DGND 20
D1852
NM
DGND
3
2
*
0
D1851
NM
L1856
NM
A CLOCK A : DEH-5300UB/XNUC
B,C DISP OFF B : DEH-5350UB/XNES1
R1856
R1857
ILMGND
C : DEH-5350UB/XNES CN1856
4
1
CKS6267
1
2
3
4
USB
5
D
VA1857
VA1856
D1857
NM
NM
6
NM
D1856
NM
COLOR 1 COLOR 2
R1874
R1876
R1877
R1878
R1879
NM
R1873
R1875
680
820
820
680
680
820
2.7k
ILMGND
DISP/BACK
REGION
BAND
USBGND
D1877
D1879
D1881
D1884
D1887
D1890
UP
6
D1875
C1875
BAND
LEFT
D1885
D1888
D1882
SOURCE
D1891
SOURCE
DOWN
D1878
D1880
E
C1876
LIST
D1876
RIGTH
D1883
D1886
D1889
1
D GREEN
Q1896
R1897
R1900
1 6
1k
1k
2 5
3 4 R1899
R1896
R1898
NM
10k
10k
HN1C01FU(YGR)
R1901
NM
F
ILMGND ILMCLR
B
DEH-5300UB/XNUC
5 6 7 8
45
1 2 3 4
A E:P5+P10
2.7
(1/10W)
(1/10SR,1608)
2.4
*
4.7u/6.3
R106
C104
(2125)
REFO
NM
2.4
PUEN
LD1 Q102
LTA123JUB
0.047u/10
3300p/50
C213
C214
LD Q101 R109 LD
VCC
2.2k
2SA1577(QR) R215
* D101
* C102
NM
NM
39k
R214
10k
LD-
15 15
C215
LD+ ASY
14 14 V+3A
B+D F BD EFM
13 13
VCC V+3A ATEST
12 12
75
74
73
72
71
T E
C101
P5+P10
B 11 11
NM
EFM
ATEST
ASY
AD.Vdd
GND
*
10 10
T F
C111
C110
P1+P6
9 9
NM
NM
VREF REFO 76
*
8 8 C221 A.Vdd1
VR 77
R108
7 7 A.GND1
1M
F 0.1u/10 C216 78
A+C
6 6
AC PD f RFI
MD PD 1800p/50 79
5 5 RFAGC AGCO
T TOM C220 80
TOM
HOLOGRAM UNIT 4 4 C3T
F FOM 0.1u/10 C219 81
FOM
3 3 AGCI
FOP F FOP 0.1u/10 82
2 2 RFO RFO
FOCUS ACT T C228 R229 83
TOP TOP
R217
5.6k
1 1 EQ2
470
C218
TRK ACT 84
4p/50
27p/50
EQ1
TOM
FOM
FOP
TOP
C217 R216 85
R218
4.7k
RF2-
F.ACT: Applying positive voltage to FOP, 56p/50 1.2k 86
RF-
the lens approaches DISC. CN101
AC
BD
87
E
F
CKS4808-A C222 A.GND2
T.ACT: Applying positive voltage to TOP, 88
A.Vdd2
the lens moves outer circumference of DISC. AC F 0.1u/10 89
A
BD F 90
B
T 91
C F
F
E T 92
E
REFO 93
REFO1 REFOUT
REFO2 C229 d C223 94
D Digital Out model only 68p/50 95
FE-
CIRCUIT No. 0.1u/10 FE FEO
96
A Analog Out model only C101 C102 C110 C111 C236 ADCIN
C224
ADCIN
* C204 C207 C235 C239 97
TE-
I IIC-BUS model only C240 C281 C282 C283 C284
C301 C307 C308
0.1u/10
c TE
47p/50 98
TEO
C601 C602 C225 99
P P-BUS model only C701 C702 C703 C705 C707 C708
0.01u/16 100
TE2
D101 TEC TEC
INTQ(INT1)
CN702
TH201
Q201
/RST
PD
LD
R106
* C239
NM
R297 R246
M1 SPDL MOTOR
1
2
3
4
5
R603 R604
R710 R711
CXE2273 R281 R282 R283
LD
D PD
RST
R291 R292 R293 R299
INTQ
BLK
S SOM C205 C206
A R601 R602 R606
D
RED I R225 R722 VDD
S SOP
P R242 R243 R707 R721 R723
GND
PL
C LCOM
REFO
OG
4 RESET
C LCOP Parts with Polarity
CN702
6 SO
M2 LOAD/CRG MOTOR
8 SI
IC201 IC301 * CKS5766-A
D101 2
Q101 Q102 Q201
CXC4026
C205 C301 C308
1 28 e
VR PreVcc
CVDD 3
5
SCK 7
VDD 1
OPIN3+ R308 S
3 OPIN2- 26 MD C209 C238 C240
9 OPIN3- 0.022u/16 18k C306 C307
R307
C305
4 OPOUT2 25
7
18k
C708
TIN
E HOME F OPOUT3
5 OPIN1+ 24 SIN R306 C R101 R102 R103
S901 HOME 3 FD SD
R243 R246
OPINSL
4
4 31
18k R606
R305
C304
6 OPIN1- 23 4700p/25
18k
HOME
a
2
CSN1080 OPOUTSL
7 OPOUT1 22 CIN 8 LOEJ
2125:PARTS
8EJ FIN
S905 8SNS 2 LDIN C104
4 31
8SNS
2
29 30
NM FIN1 FIN2
S903 DSCSNS
1 5
4 31
DSCSNS 8 21 CLCONT
2
GND1 CNT
CSN1081 9 20
CONT MUTE GND2 *
DSCSNS C306 10 PowVcc1 19 C307
PowVcc2 MOTOR DRIVER LOGIC TABLE
FOP F 1u/10 11 18 NM C
VO1- VO4- LOAD EJ PLAY OFF
F (1608) 12 17 (1608) C
FOM
VO1+ VO4+ CLCONT H H L L
TOM T 13 16 S
VO2- VO3- LOEJ L H
SWITCHES: TOP T 14 15 S
- -
CD CORE UNIT VO2+ VO3+ CONT L L H L
S901:HOME SWITCH.........ON-OFF IC301
S903:DSCSNS SWITCH.....ON-OFF BA5839FP
VD
S905:8EJ SWITCH..............ON-OFF
* C301
C308
PGND
*
CLCONT
LCOM
CONT
LCOP
LOEJ
SOM
SOP
C
DEH-5300UB/XNUC
46
1 2 3 4
5 6 7 8
C CD CORE UNIT(S11.1STD-DOUT)
MD
SD
TD
FD
PUEN
A
C232
PUEN
1000p/50
R236
10k
C231 SIGNAL LINE
R263 F
1000p/50
FOCUS SERVO LINE
4.7k T
TRACKING SERVO LINE
TEMP
ADENA
VDSENS
R235
/CDSRQ
SKIP
10k
/WAIT
C
R262 CARRIAGE SERVO LINE
S
4.7k GND
SPINDLE SERVO LINE
0.047u/10
3300p/50
0.1u/10
C213
C214
C212
R246
C235
(1608)
NM
VDD TEMP
NM
*
TEMP
*
R215 *
b
NM
TH201
R260
P R707
39k
10k
NM
0.1u/10
R214
10k
T
F
C
S
MONI2
MONI1
MONI0
C215
C16M
*
ASY
Q201
TESTIN
EFM NM
BSCK0
LRCK0
GND
ATEST
ADENA
75
74
73
72
71
70
69
68
67
66
65
64
63
62
61
60
59
58
57
56
55
54
53
52
51
ADENA
B
TEST
MD
VDCONT
SD
IO.Vdd2
EFM
ATEST
TD
FD
AD.GND
TEMP
VDSENS
Monitor3
Monitor2
Monitor1
Monitor0
IO.GND2
PUEN
ASY
SD2
AD.Vdd
/ADENA
SKIP
/TESTIN
/CDSRQ
P R721
76 50 NM I R225 /WAIT
A.Vdd1 PC3 Mask Flash
77 49 R723 P 0 SDA R281 56 22
A.GND1 SDA R282 56 22
78 48 NM I R722 SCL
RFI SCL R291 56 22
79 47 0 D R291 LRCK
AGCO /WAIT *
80 46 C283 56
C3T TX/EMPH D
81 45 R283 NM D R292 0
BCLK
AGCI LRCK D * *
82 44 R281 0 C281 C282
56
RFO SCKO
83 43 R282 D NM NM D R293 DATA
EQ2 DOUT *
84 42 56 C284 0
EQ1 PA7
85 41 NM LOEJ
RF2- LOEJ
86 40 CLCONT
RF- CLCONT
87 39 R264 CONT
A.GND2 CONT R245
88 IC201 38 1k
100k
DSCSNS
A.Vdd2 DSCSNS R253
89
A
PE5756A 8SNS
37 8SNS NM
90 36
B 12SNS R254
91 35
F HOME
EJSW
HOME 100k C
92 34 R240
E EJSW
93 33 /CDSTBY 47k
REFOUT /CDSTBY
94 32 ICECK
ICECK
FE- ICECK *
R297
R296
95 31
0
FEO IO.Vdd1 C211
96 30 NM
ADCIN IO.GND1 0.1u/10
97 29 R237 RESET
TE- RESET
98 28 C233 220
TEO C.GND
99 27 C210 0.01u/16
TE2 C.Vdd
00 26 0.1u/10 R232
R232
TEC Vpp
INTQ(INT1)
Mask 0
DA.GND1
0
DA.Vdd1
Flash 10k
DA.GND
DA.Vdd
VPP
REG16
D.GND
ICEMD
X.GND
REGC
REGS
ROUT
D.Vdd
/XTAL
X.Vdd
LOUT
XTAL
/SCK
/RST
/STB
SO
CVDD
PD
LD
A0
SI
NM
VPP
1
2
3
4
5
6
7
8
9
10
11
12
13
14
15
16
17
18
19
20
21
22
23
24
25
CVDD
1
0.1u/10
A
R294
470
SO
ICEMD
SCK
RST
A0
STB
C205
SI
2
INTQ
R294
X201 Mask 470
NM * CSS1603-A Flash 0
C203
VDD2
VDD1
3
A NM NM
0.1u/16 (1608) VDD
* C240 NM
C238 NM
* C204 NM
C299 NM
D R299
0
SCK
GND
CVDD
SCK
VPP
VDSENS
6
ICECK
CDSTBY
CDSRQ
RESET
VDSENS
SKIP
SDA
SCL
VD1
VD2
CN701
4 RESET
10 GND
CKS6146-A
8 SI
* CKS5766-A I/O
NM NM
2
(1608) VD
1 VD 7.5V
2 VD 7.5V
/CDSRQ R709
NM
NM
R601
R602
A 3 /CDSRQ
A 0 R706
CVDD 3
5
VPP 9
SCK 7
VDD 1
/CDSTBY /CDSTBY
* * 4
R702 220
ICECK
SCL
R603 R604 5 SCL
R708
* NM
C601 C602
NM * SKIP
SDA
100
R701 0
6
7
SKIP
SDA
A E
RESET 100
NM NM 8 RESET
CN701
9 VDD 3.3V
LRCK
10 GND GND
A R606 BCLK DATA
11 DATA
NM (1608) DATA BCLK
12 BCLK
LRCK
13 LRCK
1000p/50
AAGND1 AAGND2
C710
* C705
* C707
* C708
14 GND GND
(1608)
NM
NM
NM
15 PGND GND
BLE /WAIT
16 WAIT
OFF
L
NM
NM
* R711
* R710
* C703
* C701
C702
i h g
NM
NM
NM
-
PGND
L
*
(AGND)
(ROUT)
(LOUT)
GND1
GND2
GND3
DATA
LRCK
BCLK
WAIT
F
* NO MOUNT PARTS (NM)
PGND1
PGND2
B
D PANEL UNIT
B A
CN1851 EJECT CN802
D
DEH-5300UB/XNUC
48
1 2 3 4
5 6 7 8
10.5 WAVEFORMS
- CD CORE UNIT Note : 1. The encircled numbers denote measuring points in the circuit diagram.
A
2. Reference voltage REFO1(1.65 V)
1DSCSNS 5 V/div 500 ms/div 1DSCSNS 5 V/div 500 ms/div 1DSCSNS 5 V/div 500 ms/div
28SNS 5 V/div 5CLCONT 5 V/div 28SNS 5 V/div
4LOEJ 5 V/div 4LOEJ 5 V/div 4LOEJ 5 V/div
3HOME 5 V/div 6VD 10 V/div 3HOME 5 V/div
12 cm CD Loading operation 12 cm CD Loading operation 8 cm CD Loading operation
7SIN 1 V/div 2 s/div aFIN 200 mV/div 500 ms/div cTE 500 mV/div 200 ms/div
8CIN 500 mV/div bRFOK(MONI_3) 2 V/div dFE 500 mV/div
9TIN 500 mV/div 7SIN 2 V/div
12 cm CD-DA setup operation after loading 12 cm CD-DA Source On setup operation Source On setup operation
dFE 500 mV/div 20 ms/div eMDX 2 V/div 50 ms/div eMDX 2 V/div 5 μs/div
aFIN 500 mV/div 7SIN 500 mV/div 7SIN 500 mV/div
cTE 500 mV/div
9TIN 500 mV/div D
CD-DA Play operation Spindle waveform during play operation Spindle waveform during play operation
(Wider)
E
aFIN 500 mV/div 200 ms/div cTE 500 mV/div 2 ms/div fRFAGC 1 V/div 500 μs/div
dFE 500 mV/div fRFAGC 500 mV/div cTE 500 mV/div
9TIN 500 mV/div
Focus Search waveform Track Open waveform 100 Track Jump waveform (32 Track Jump x 3)
DEH-5300UB/XNUC
5 6 7 8
49
1 2 3 4
A
fRFAGC 1 V/div 2 ms/div fRFAGC 1 V/div 200 ms/div gLRCK 2 V/div 10 μs/div
cTE 500 mV/div cTE 1 V/div hBCLK 2 V/div
9TIN 500 mV/div 8CIN 500 mV/div iDATA 2 V/div
7SIN 2 V/div
32 Tracks Jump waveform
(Zoom of 100 Track Jump waveform) Search operation(Outter to Inner) Digital Out waveform
1DSCSNS 5 V/div 500 ms/div 1DSCSNS 5 V/div 500 ms/div 1DSCSNS 5 V/div 500 ms/div
5CLCONT 5 V/div 28SNS 5 V/div 28SNS 5 V/div
4LOEJ 5 V/div 4LOEJ 5 V/div 4LOEJ 5 V/div
3HOME 5 V/div 3HOME 5 V/div
12 cm CD Eject operation 8 cm CD Eject operation 12 cm CD Eject operation
Ref.:
REFO
Mode:
Normal
DEH-5300UB/XNUC
50
1 2 3 4
5 6 7 8
DEH-5300UB/XNUC
5 6 7 8
51
1 2 3 4
C962
C961
140 C259
C317
2
Connector Capacitor
C314
1
5 JA251 3 2 1 5 15
3
SIDE A
R256
R255
C256
C316
R251
C255
R961
R962
R254
R258
Q251
C258
C308
C305
C306
C307
C311
R257
C257
C260 R252 C252
R253
Q252 1
P251 C251
130
C315
R259
1 C313
C303
C302
C304
C301
C254
C310
1
B C253
C261 D502
C504
SIDE B R30
R333
C334
R331
C333
C501
C332
R334
R332
C331
IC501 R30
P.C.Board Chip Part 1 R30
R504
C505
C503
120 R501
C502
R503 R502
5
R506
D501
IC502
C508
C507
R507
R505
C506
1
L501
110
1
C509
100
C
90
80
70
D
60
50
40 C CN701
30
20
10
F
Y FRONT
0
A X 10 20 30 40 50 60 70 80
DEH-5300UB/XNUC
52
1 2 3 4
5 6 7 8
A
SIDE A
> P 251 (A,7,129) Fuse 3 A CEK1286
IC301
10 20
L901 Q751
15 25
C321
JA901 POWER SUPPLY E
1 C309 R754
R753
FUSE
C320 2 6 10 14 16 18
1 5 9 13 > C752
C308
C305
C306
C307
D751
C311
15 17
1
C312
D302
D301
C351
R352
Q752
C315
C754
C303
C302
C304
C301
Q351 R353
C319 C318 C901
C310
1
B
R351
R304 Q301 ANTENNA
C753
C751
R333
C334
R331
C333
C332
R334
R332
1
C331
R302 R301
R303 JA401
C208
C210
C206
C212
D901
D902
R952 R951
R934
D941 E E
KN401
D952
C927
D951
R942
10
C201
C951
R206
R207
C203
1 5 10 IC951
C215
L417 P401
E D931
1 5 C408 R413
R205 C204 R932 C401
L418 D401
Q941 C952 L420
L201 L404 R401
E
C414
R941
C202 L405 C443
R933
C456
R931
C213 C444
C209
C211
C403
C207
C205
L402
C214 L403 C402
C931
Q931 R403
L401
C450
C404
C451
L406 C413 C449 C406
C412
C409
C407
C411
C445 C446
C405
C415
R405
R402
C418 C410 D402
C417
C422
R551
C551
C416
R406 C420
15 10 5 1
C448
L407
C
L551 C423 R407
C421
C419 L408
Q551 L409 20
60
C425
KN601
20
5 1
E R408 C426 C424
C427 C454
25
C452 IC401
55
IC551 R409 C428
R558
10
C434
C455
15 R672 1
30
C710 L411
D601
50
R603
R601
C447 35 40 45
C430
C435 C431
R412
L410 C429
1 R671
R553
R559
R552
R557
R560
R427 C432
R602 R561 C433 C440 L412
C442
R605
R429
R415
C601
R562
C436
R410
R421
R612
L414
L416
C439
R606
R417 L419
140 135 130 125 120 115 110
C604 R418
1
C453
C605
C606
R419
105
5
R416
R607 C607
R608 R420
100
C612
10
C611
C613
C608 R634
C615
R609
R508 IC601 R613 R893
R610
C238
R615
90
R614
20
IC651
C616
C617
R616
C234 R892 R891 D
R617 C235
R201
85
25
C619
1 X601 C237 E Q892
C618 1 Q891
1 C620 15 10 E
80
30
R651 R618
R620
C621
IC231 Q873
D651
R231
C239
R232
75
R619
35
R629 1 5
C652 1 E
C651
C631 40 45 50 55 60 65 70
Q871
C232
C703
C702
R626
E
C625
C626
R874
R631
C872
R637
R623
R627
C628
C629 C233
C636
C622 R873
L701 R625
X602 C624 R639
C637
1 R622 R817
C633 C632 L602
R630 L601
CN701 C925
R752 R632 C924
R751 R640
C916
15
R633
C911
R708 C920
C701
R703
R911
R710
10
IC912
E
5
R714 R719
C708
R715 R720
R638
R801
R820
R802
R717
C707
R809
R810
1
R716 R816
R806
R812
IC801 R822
C802 C812
R808
L851
R811
C871
R871
D805
1
R814
R815
C851 1
D803
C808 5 L802
C803
R807
R851
D804
C809
C805
D802
C811
D801
C807
C820
C810
D807
D806
D810
R691
D809
C801
C806
1
S691
1 5 10 15 20
R818 D CN2
DSENS CN802 D808
R819
C818
R823
1 5 15
10 20
CN801 F
FRONT
PCL
D TESTIN
A
SIDE B
150
140
1
130
B
120
110
100
C
90
80
PCL
70
N D
60
50
40
E
30
20
1
1
10
F
Y
0
100 90 80 70 60 50 40 30 20 10 X A
DEH-5300UB/XNUC
5 6 7 8
55
F
E
B
A
D
C
56
B
B
1
1
KEYBOARD UNIT
11.2 KEYBOARD UNIT
IC1806
1
D1891
SRC
S1819 S1820 LCD
40 LIST S1821 S1814
D1876 UP S1813 V1801
D1864
D1879
40 35 30 25 20 15 10 5 1
2
2
C1876
D1880
D1865
C1865
S1812
MULTI-CONTROL S1816 CN1856
C1864
1
30 C1875
2
D1875 D1861
D1890 D1868
3
S1811 S1846
D1883 D1882
C1867
5
S1815
6
20 S1830
S1822
D1862
BAND C1862
C1863 C1872
1 3 C1869
4 C1874 5 6 AUX
/ESC 2 S1828 S1825 S1824
D1873
C1870
D1888
D1877 S1823
S1831 S1829 S1826 S1827 3
DISP S1817 S1818
DEH-5300UB/XNUC
10 /BACK * JA1836
D1872
D1887
D1863
D1878
C1873 1
D1889
D1874
D1884
D1869
D1870
D1885
DOWN
C1871
D1871
D1886
D1881
D1866
C1866
3
Y
3
0
X 10 20 30 40 50 60 70 80 90 100 110 120 130 140 150 160
*A CLOCK A : DEH-5300UB/XNUC
B,C DISP OFF B : DEH-5350UB/XNES1
C : DEH-5350UB/XNES
4
4
SIDE A
B
F
C
D
A
57
B
SIDE B
8
8
CN1
D
R1809
40
7
7
R1808
R1806
C1806
R1813
R1814
R1862
R1812
R1874
R1868
R1807
DEH-5300UB/XNUC
R1863
R1869
R1875
R1861
45 40 35
R1880
VA1856
D1856
50
30
C1861
30
15 5 1
1
R1857
C1801
R1879
R1873
X1801
55
L1856
R1867
1
25
R1856
CN1851 IC1801
R1801
60
1
D1857
20
R1802 R1846
VA1857
20 10
R1847
1 5 10 15
20
VA1837
R1837
C1838
R1872
R1900 R1851
R1897
C1836
D1851
D1852
R1898
C1851
R1811
R1878
Q1896
R1864
1
VA1839 C1840 R1866 R1871
R1901
VA1838 1 1
R1870
10
VA1836
1
R1865
R1899
R1896
C1837 R1877
6
6
R1876
C1839 R1836
Y
0
160 150 140 130 120 110 100 90 80 70 60 50 40 30 20 10 X
KEYBOARD UNIT
5
5
B
1 2 3 4
PICKUP UNIT(P10.5)(SERVICE)
B
60
1
CN101 M2
15 10 5 1 TH201
S901 LOADING/CARRIAGE
C102 HOME MOTOR
50 F
M1
REFO1
C218
D101
E SPINDLE
R217
C228
R218
C217
C216
C C235
MOTOR
CN702 C224 R216
R229 R246
C225
1
100 95 90 85 80
C213
5
C214
40 R215
75
1
C215 R306
5
70
R308
C307
65
R263
R262
R235
R236
C212
C240 C299 IC201 R307 R305
C207
15
60
25 30 20 15
C204
30
20
55
IC301
R264
1
C702
30 35 40 45 50
D
R225
R282
C211
C210 R708
R232
R281 R709 1 5 29 10
C306
20 R710
C701
10
CN701
Y 15 10 5 1 A CN701
E
0 10 20 30 40 50 60 70
X
C
DEH-5300UB/XNUC
58
1 2 3 4
5 6 7 8
R102
R101
60
C101 R103
C111
C110
C104
Q101
R108
E
Q102
R109
50
E
R106
C
C239
C220 C236
C229
40
C205
C301 C308
Q201
C206
R245
E
C233
R237
D
R721 R723
R722
R260
R702
R297
R701 20
R283
R242 C283 R602
C281
C602
R292
R291
R243 C282
R606 R604
R299
DSCSNS
R601
R706 C708 R293 C601
1 S903
C703
C710
C705
R603 10
C707 C284
R711
Y
E
70 60 50 40 30 20 10 0
X
C
DEH-5300UB/XNUC
5 6 7 8
59
1 2 3 4
30 1 5 15
B CN1
20
10 20
D1
10
C
Y
0
X 10 20 30 40 50 60
D
Y
CN2
15 5 1
10 20 10
E 20
A CN802
30
40
D
DEH-5300UB/XNUC
60
1 2 3 4
5 6 7 8
Circuit Symbol and No. Part No. Circuit Symbol and No. Part No.
Q 251 (A,23,131) Chip Transistor RN1910
A:DEH-5300UB/XNUC Q 252 (A,13,129) Chip Transistor RN1910
B:DEH-5350UB/XNES1 Q 351 (A,88,127) Chip Transistor RN4983
DEH-5300UB/XNUC
5 6 7 8
61
1 2 3 4
Circuit Symbol and No. Part No. Circuit Symbol and No. Part No.
L 408 (A,162,94) Inductor CTF1786
L 409 (A,138,94) Chip Coil LCTAW470J2520 R 508 (A,95,67) RS1/16SS103J
R 551 (A,121,95) RS1/16SS473J
L 415 (A,146,81) Inductor CTF1786 R 552 (A,117,85) RS1/16SS103J
A
L 420 (A,145,107) Inductor(A) LCYB68NJ1608 R 553 (A,118,85) RS1/16SS103J
L 501 (A,34,110) Coil CTH1475 R 556 (A,122,85) RS1/16SS272J
L 671 (A,133,78) Inductor CTF1786
L 802 (A,114,26) Inductor CTF1713 R 557 (A,120,85) RS1/16SS472J
R 558 (A,125,89) RS1/16SS472J
L 901 (A,112,141) Choke Coil 600 uH CTH1432 R 559 (A,116,85) RS1/16SS101J
X 401 (A,161,87) Oscillator 36.48 MHz CSS1805 R 560 (A,119,85) RS1/16SS101J
X 601 (A,129,61) Ceramic Resonator 16.934 MHz CSS1603 R 601 (A,112,85) RS1/16SS103J
X 602 (A,109,51) Oscillator 12.000 MHz YSS5005
S 691 (A,90,14) Switch(DSENS) CSN1039 R 602 (A,109,82) RS1/16SS473J
R 603 (A,111,85) RS1/16SS104J
> P251 (A,7,129) Fuse 3 A CEK1286 R 604 (A,98,81) RAB4CQ473J
B P 401 (A,155,109) Surge Protector IMSA-6802-01Y900 R 606 (A,100,78) RS1/16SS473J
CN701 (A,91,39) Connector VKN1192 R 607 (A,100,73) RS1/16SS473J
CN802 (A,110,15) Connector CKS3836
JA 251 (A,19,138) Pin Jack CKB1099 R 608 (A,97,73) RS1/16SS473J
R 609 (A,127,69) RS1/16SS101J
JA 401 (A,158,129) Antenna Jack YKS5041 R 610 (A,100,67) RS1/16SS222J
JA 901 (A,113,141) Plug CKM1586 R 611 (A,132,69) RS1/16SS101J
JA 961 (A,42,139) Connector CKS4124 R 612 (A,98,79) RS1/16SS473J
> Fuse(10 A) YEK5001
R 613 (A,132,68) RS1/16SS101J
RESISTORS R 615 (A,98,64) RS1/16SS104J
R 617 (A,127,65) RS1/16SS221J
R 201 (A,96,63) RAB4CQ102J R 619 (A,130,57) RAB4CQ473J
C R 231 (A,142,60) RS1/16SS821J R 620 (A,99,60) RS1/16SS473J
R 232 (A,143,60) RS1/16SS821J
R 251 (A,19,131) RS1/16SS821J R 621 (A,125,54) RS1/16SS473J
R 252 (A,29,131) RS1/16SS821J R 622 (A,103,50) RS1/16SS473J
R 623 (A,108,54) RS1/16SS152J
R 253 (A,9,129) RS1/16SS821J R 624 (A,103,52) RS1/16SS473J
R 254 (A,18,130) RS1/16SS821J R 626 (A,116,53) RS1/16SS5601F
R 255 (A,21,131) RS1/16SS223J
R 256 (A,26,131) RS1/16SS223J R 628 (A,123,53) RS1/16SS103J
R 257 (A,11,129) RS1/16SS223J R 629 (A,97,58) RS1/16SS102J
R 630 (A,122,49) (B,C) RS1/16SS473J
R 258 (A,15,130) RS1/16SS223J R 631 (A,121,53) (A) RS1/16SS473J
R 303 (A,86,123) RS1/16SS103J (B,C) RS1/16SS153J
D R 304 (A,86,125) RS1/16SS473J R 632 (A,117,47) RS1/16SS103J
R 351 (A,92,127) RS1/16SS103J R 633 (A,119,45) RS1/16SS101J
R 352 (A,90,128) RS1/16SS103J
R 353 (A,92,128) RS1/16SS221J R 636 (A,103,53) RS1/16SS473J
R 401 (A,161,106) RS1/16SS221J R 651 (A,91,60) RS1/16SS104J
R 671 (A,133,83) RS1/10SR473J
R 402 (A,161,100) RS1/16SS751J R 672 (A,129,88) RS1/10SR473J
R 403 (A,139,103) RS1/16SS152J R 691 (A,92,22) RS1/10SR222J
R 405 (A,142,99) RS1/16SS105J
R 406 (A,138,97) RS1/16SS471J R 701 (A,95,45) RS1/16SS473J
R 407 (A,139,96) RS1/16SS330J R 702 (A,95,39) RS1/16SS104J
R 703 (A,97,41) RS1/16SS104J
R 408 (A,138,92) RS1/16SS681J R 704 (A,96,49) RAB4CQ472J
E
R 410 (A,136,80) RS1/4SA8R2J R 707 (A,95,46) RS1/16SS221J
R 412 (A,137,85) RS1/4SA8R2J R 708 (A,95,44) RS1/16SS221J
R 413 (A,145,108) RS1/16SS105J
R 419 (A,132,72) RS1/16SS103J R 709 (A,95,43) RS1/16SS101J
R 710 (A,95,42) RS1/16SS221J
R 420 (A,133,72) RS1/16SS103J R 711 (A,95,41) RS1/16SS101J
R 421 (A,153,80) RS1/16SS0R0J R 712 (A,95,40) RS1/16SS102J
R 427 (A,142,84) RS1/16SS102J R 713 (A,96,37) RS1/16SS151J
R 428 (A,139,87) RS1/16SS0R0J
R 501 (A,22,120) RS1/10SR471J R 714 (A,96,36) RS1/16SS151J
R 715 (A,96,35) RS1/16SS151J
R 502 (A,23,117) RS1/16SS4702F R 716 (A,95,31) RS1/16SS221J
F R 503 (A,21,117) RS1/16SS682J R 717 (A,95,32) RS1/16SS104J
R 504 (A,20,120) RS1/16SS1002F R 751 (A,95,47) RS1/16SS473J
R 505 (A,26,113) RS1/16SS183J
R 506 (A,15,114) RS1/16SS513J R 752 (A,97,47) RS1/16SS103J
R 753 (A,139,134) RS1/10SR821J
DEH-5300UB/XNUC
62
1 2 3 4
5 6 7 8
Circuit Symbol and No. Part No. Circuit Symbol and No. Part No.
R 801 (A,117,30) RS1/10SR101J C 256 (A,28,131) CCSSCH101J50
R 802 (A,119,30) RS1/10SR101J
R 803 (A,106,25) RS1/10SR222J C 257 (A,10,129) CCSSCH101J50
C 258 (A,17,130) CCSSCH101J50 A
R 806 (A,105,25) RS1/10SR222J C 259 (A,35,139) CKSSYB102K50
R 807 (A,108,21) RS1/10SR222J C 301 (A,74,128) CKSRYB474K10
R 808 (A,103,24) RS1/16SS822J C 302 (A,81,128) CKSRYB474K10
R 809 (A,113,29) RS1/10SR8R2J
R 810 (A,115,29) RS1/10SR8R2J C 303 (A,76,128) CKSRYB474K10
C 304 (A,80,128) CKSRYB474K10
R 811 (A,122,26) RS1/10SR222J C 305 (A,74,132) CKSRYB474K10
R 812 (A,102,25) RS1/10SR222J C 306 (A,81,132) CKSRYB474K10
R 813 (A,100,25) RS1/10SR222J C 307 (A,76,132) CKSRYB474K10
R 814 (A,110,25) RS1/10SR222J
R 815 (A,111,25) RS1/10SR222J C 308 (A,79,132) CKSRYB474K10
C 309 (A,137,135) CKSRYB104K16
R 816 (A,122,30) RS1/10SR222J C 310 (A,82,129) 2.2 uF CCG1205 B
R 817 (A,122,50) RS1/16SS104J C 311 (A,82,131) 2.2 uF CCG1205
R 820 (A,118,30) RS1/10SR101J C 312 (A,98,128) CKSRYB104K16
R 821 (A,120,28) RS1/16SS223J
R 822 (A,117,27) RS1/16SS223J C 313 (A,67,128) CEVW100M16
C 314 (A,61,135) CCSSCH100D50
R 851 (A,98,23) RS1/16SS472J C 315 (A,84,129) CCSSCH100D50
R 872 (A,125,28) RS1/10SR473J C 317 (A,62,136) CCSSCK1R0C50
R 873 (A,148,53) RS1/16SS562J C 318 (A,107,129) CCSRCH100D50
R 874 (A,148,55) RS1/16SS103J
R 891 (A,148,65) RS1/16SS103J C 319 (A,103,129) CCSRCH100D50
C 320 (A,96,133) CCSRCH100D50
R 892 (A,146,65) RS1/16SS473J C 321 (A,92,137) CCSRCH100D50
R 893 (A,147,67) RS1/4SA821J C 351 (A,94,127) 10 uF CCG1192 C
R 911 (A,141,41) RS1/10SR1R0J C 401 (A,155,107) CCSSCH330J50
R 912 (A,144,42) RS1/10SR1R0J
R 931 (A,121,106) RS1/16SS223J C 402 (A,158,105) CCSSCH6R0D50
C 403 (A,161,105) CKSSYB103K16
R 932 (A,118,107) RS1/16SS473J C 404 (A,150,100) CKSSYB104K10
R 933 (A,115,106) RS1/16SS472J C 405 (A,147,100) CKSSYB104K10
R 934 (A,115,114) RS1/4SA102J C 406 (A,160,101) CKSSYB103K16
R 961 (A,50,134) RS1/16SS102J
R 962 (A,48,134) RS1/16SS102J C 407 (A,148,100) CKSSYB104K10
C 409 (A,162,101) CKSSYB103K16
C 410 (A,148,99) CKSSYB103K16
CAPACITORS C 411 (A,145,100) CKSSYB103K16
C 412 (A,144,101) 10 uF CCG1192 D
C 201 (A,106,108) 10 uF CCG1192
C 202 (A,100,106) CCSSCH100D50 C 413 (A,155,101) CKSSYB103K16
C 203 (A,103,108) 4.7 uF CCG1201 C 414 (A,152,102) CKSRYB105K10
C 204 (A,100,107) CCSSCH100D50 C 415 (A,140,99) CKSSYB103K16
C 205 (A,94,106) CKSRYB105K10 C 416 (A,159,96) CKSRYB224K16
C 417 (A,160,96) CKSSYB104K10
C 206 (A,94,118) CKSRYB105K10
C 207 (A,97,106) CKSRYB105K10 C 418 (A,138,98) 10 uF CCG1192
C 208 (A,96,119) CKSRYB105K10 C 419 (A,158,93) CKSRYB105K10
C 209 (A,98,106) CKSRYB105K10 C 420 (A,140,97) CKSSYB104K10
C 210 (A,98,119) CKSRYB105K10 C 421 (A,137,96) CCSSCH101J50
C 422 (A,143,98) CKSSYB104K10
E
C 211 (A,95,106) CKSSYB224K6R3
C 212 (A,95,119) CKSSYB224K6R3 C 423 (A,136,96) CKSSYB103K16
C 215 (A,102,108) CCSSCH100D50 C 424 (A,162,92) CKSSYB472K25
C 232 (A,138,56) CKSSYB103K16 C 425 (A,162,93) CKSSYB472K25
C 233 (A,139,55) 10 uF CCG1192 C 426 (A,158,91) CKSSYB104K10
C 427 (A,138,91) CCSSCH820J50
C 234 (A,138,66) 10 uF CCG1192
C 237 (A,142,62) CCSRCH182J50 C 428 (A,161,90) CCSSCH9R0D50
C 238 (A,143,64) CCSRCH182J50 C 429 (A,161,85) CCSSCH9R0D50
C 239 (A,141,60) CKSSYB102K50 C 430 (A,139,85) CKSRYB474K10
C 251 (A,31,129) 4.7 uF CCG1201 C 431 (A,158,84) CKSSYB104K10
C 437 (A,156,82) CKSSYB104K10
C 252 (A,35,131) 4.7 uF CCG1201 F
C 253 (A,31,127) 4.7 uF CCG1201 C 440 (A,147,83) CKSSYB104K10
C 254 (A,35,128) 4.7 uF CCG1201 C 441 (A,152,82) 2.2 uF CCG1205
C 255 (A,20,130) CCSSCH101J50 C 443 (A,145,104) (B,C) CKSSYB103K16
C 445 (A,142,101) CKSSYB223K16
DEH-5300UB/XNUC
5 6 7 8
63
1 2 3 4
Circuit Symbol and No. Part No. Circuit Symbol and No. Part No.
C 447 (A,142,86) CKSSYB102K50 C 901 (A,133,125) 3 300 uF/16 V CCH1732
C 451 (A,142,103) (A) CCSSCJ3R0C50 C 913 (A,140,40) CKSSYB102K50
C
604
605
(A,99,76)
(A,126,74)
CKSSYB104K10
CKSSYB104K10
B
Unit Number :
C 606 (A,100,75) CKSSYB104K10
C 607 (A,128,73) CKSSYB104K10
Unit Name : Keyboard Unit
C 608 (A,100,71) CKSSYB104K10
C 609 (A,127,70) CKSSYB104K10 MISCELLANEOUS
DEH-5300UB/XNUC
5 6 7 8
65
1 2 3 4
Circuit Symbol and No. Part No.
D
Unit Number : QWM3209
Unit Name : Panel Unit
MISCELLANEOUS
C
D 1 (A,3,17) LED(RED) SML-D12V8W(PQ)
D 2 (A,55,37) LED(RED) SML-D12V8W(PQ)
S 1 (A,59,37) Push Switch(EJECT) CSG1155
CN1 (A,38,24) Connector CKS6037
CN2 (B,16,9) Connector CKS3863
DEH-5300UB/XNUC
66
1 2 3 4